2种烟煤掺混干化污泥中温热解制气

李钢; 舒新前

doi:10.12030/j.cjee.201803026

环境工程学报

2种烟煤掺混干化污泥中温热解制气

李钢, 舒新前. 2种烟煤掺混干化污泥中温热解制气[J]. 环境工程学报, 2018, 12(10): 2966-2972. doi: 10.12030/j.cjee.201803026

引用本文:

李钢, 舒新前. 2种烟煤掺混干化污泥中温热解制气[J]. 环境工程学报, 2018, 12(10): 2966-2972. doi: 10.12030/j.cjee.201803026

LI Gang, SHU Xinqian. Medium-level temperature pyrolysis of mixture of dried sewage sludge and bituminous coal for syngas production[J]. Chinese Journal of Environmental Engineering, 2018, 12(10): 2966-2972. doi: 10.12030/j.cjee.201803026

Citation:

LI Gang, SHU Xinqian. Medium-level temperature pyrolysis of mixture of dried sewage sludge and bituminous coal for syngas production[J]. Chinese Journal of Environmental Engineering, 2018, 12(10): 2966-2972. doi: 10.12030/j.cjee.201803026

2种烟煤掺混干化污泥中温热解制气

李钢^1,2,,
舒新前¹

1.
中国矿业大学北京化学与环境工程学院，北京 100083
2.
河南工程学院资源与环境学院，郑州 451191
基金项目:
河南省科技厅科技发展计划科技攻关项目（132102210462）

河南工程学院博士基金资助项目（D2012003）

Medium-level temperature pyrolysis of mixture of dried sewage sludge and bituminous coal for syngas production

LI Gang^1,2,,
SHU Xinqian¹

1.
School of Chemical & Environmental Engineering, China University of Mining & Technology Beijing, Beijing 100083, China
2.
School of Resource & Environment, Henan University of Engineering, Zhengzhou 451191, China
Fund Project:

摘要: 以2种不同产地烟煤和某污水处理厂污水污泥作为研究对象，在实验室预处理，将两者按不同比例掺混后使用管式电阻炉进行中温热解实验，探讨了烟煤与干化污泥掺混热解产气特性。实验结果表明：烟煤掺混干化污泥热解，不改变两者热解产H2、CO和CH4的规律。在相同热解温度下，烟煤的掺混比例越高，产生H2体积百分含量越大。对于CH4，掺混物料产气峰值热解温度由800 ℃降低至700 ℃。混合物料中污泥掺混比例增加会增加CO含量。通过热重实验，随着物料中配入干化污泥质量比重增加，热解反应所需活化能减小。
- 烟煤 /
- 干化污泥 /
- 中温热解 /
- 氢气
Abstract: Medium-level temperature co-pyrolysis gas production characteristics on some dried sewage sludge and two different kinds of bituminous coals were investigated on the experimental tube furnace with different mixing ratio for sample pretreatment, respectively. The results of co-pyrolysis of bituminous coal and dried sewage sludge indicated that the values of H2，CO and CH4 concentration were similar to those of bituminous coal or dried sewage sludge in each pyrolysis stage. At the same pyrolysis temperature, the higher the blending ratio of bituminous coal could lead to generate the larger the H2 concentration. For CH4 gas, the pyrolysis temperature of the peak concentration was dropped from 800 ℃ to 700 ℃. The increase of dried sewage sludge mixing ratio in the mixture pyrolysis would increase the CO content. The activation energy of pyrolysis different blend samples was analyzed using a thermogravimetric analyzer, it was found that dried sewage sludge addition could decrease activation energy, the higher the proportion of dried sewage sludge in the mixture was, the less activation energy was.
- bituminous coal /
- dried sewage sludge /
- medium-level temperature pyrolysis /
- hydrogen

[1]	贺永德.现代煤化工技术手册[M]. 2版.北京:化学工业出版社,2010
[2]	于娜,魏永杰,胡敏,等. 北京城区和郊区大气细粒子有机物污染特征及来源解析[J]. 环境科学学报,2009,29(2),243-249
[3]	杨书申,邵龙义,李卫军,等. 煤炭燃烧对上海市大气质量影响的分析[J]. 煤炭学报,2007,32(10):1070-1074
[4]	温昶,徐明厚,于敦喜,等．煤粉O₂ /CO₂燃烧时PM_2.5及其Fe、S 的生成特性[J]. 化工学报,2011,62(4):1062-1069
[5]	吕建燚,李定凯．温度对煤粉燃烧生成的一次颗粒物特性的影响[J]. 中国电机工程学报,2007,27(20):24-29
[6]	张辉,胡勤海,吴祖成,等. 城市污泥能源化利用研究进展[J]. 化工进展,2013,32(5):1145-1151
[7]	李杰,潘兰佳,余广炜,等. 污泥生物炭制备吸附陶粒[J]. 环境科学,2017,38(9): 3970-3978 10.13227/j.hjkx.201702161
[8]	丁文杰,陈文和,邓明佳,等. 污泥直接干化尾气中恶臭污染物质重要性评价:以指标权重评分法为例[J]. 环境科学,2016,37(2):782-788
[9]	宋薇,刘建国,聂永丰.含油污泥组成及其对热解特性的影响[J].环境科学,2008,29(7):2063-2067
[10]	李伟东,李明,李伟锋,等. 改性污泥与无烟煤成浆性的研究[J]. 燃料化学学报,2009,37(1):26-30
[11]	王学涛,李强,穆晓军,等. 城市污泥与煤混合热解特性实验研究[J]. 电站系统工程,2014,30(4):1-2
[12]	张文丹,戴财胜. 烟煤与造纸污泥混配物的热解特性研究[J]. 煤炭转化,2012,35(1):13-15
[13]	高新勇,金晶,张号,等. 市政污泥与烟煤的混合热解特性实验研究[J]. 煤炭转化,2014,37(1):83-87
[14]	陈晓平,顾利锋,韩晓强,等. 污泥及其与煤混合物的热解特性和灰熔融特性[J]. 东南大学学报(自然科学版),2008,38(6):1038-1043
[15]	李钢,舒新前,崔树军,等. 干化污泥热解产物的经验方程研究[J]. 河南工程学院学报(自然科学版),2010,22(1):11-14
[16]	高晋生. 煤的热解、炼焦和煤焦油加工[M]. 北京:化学工业出版社,2010
[17]	陈冠益,方梦祥,骆仲泱,等. 生物质固定床热解特性的试验研究与分析[J]. 太阳能学报, 1999,20(2):122-129
[18]	李爱民,任远,李水清,等. 木块在回转窑内热解特性的试验研究[J].燃烧科学与技术,1999(2):121-127
[19]	常风民,王启宝,王凯军. 城市污泥与煤混合热解特性及动力学分析[J]. 环境工程学报,2015, 9(5):2412-2418
[20]	张号,金晶,郭明山,等. 石化污泥与烟煤混合共热解特性实验研究[J]. 太阳能学报,2015,36(2):280-284
[21]	李钢,崔树军,舒新前,等. 干化污泥热解制备可燃气过程中石英砂的影响[J]. 环境工程学报,2010,4(10):2333-2338
[22]	谢克昌,赵炜. 煤化工概论[M]. 北京:化学工业出版社,2012
[23]	陈昌国,张代钧,鲜晓红,等. 煤的微晶结构与煤化度[J]. 煤炭转化,1997,20(1):45-49
[24]	朱学栋,朱子彬,韩崇家. 煤的热解研究III.煤中官能团与热解生成物[J]. 华东理工大学学报,2000,26(1):14-17
[25]	王鹏,文芳,步学朋,等. 煤热解特性研究[J]. 煤炭转化,2005,28(1):8-13
[26]	于娟,章明川,范卫东,等. 不同升温方式下活化能分布热解模型的适用性[J]. 上海交通大学学报, 2003,37(7):1027-1030

点击查看大图

计量

文章访问数: 1707
HTML全文浏览数: 1606
PDF下载数: 121
施引文献: 0

2种烟煤掺混干化污泥中温热解制气

李钢^1,2,,
舒新前¹

1. 中国矿业大学北京化学与环境工程学院，北京 100083
2. 河南工程学院资源与环境学院，郑州 451191

基金项目:

河南省科技厅科技发展计划科技攻关项目（132102210462）

河南工程学院博士基金资助项目（D2012003）

关键词:

烟煤 /
干化污泥 /
中温热解 /
氢气

摘要: 以2种不同产地烟煤和某污水处理厂污水污泥作为研究对象，在实验室预处理，将两者按不同比例掺混后使用管式电阻炉进行中温热解实验，探讨了烟煤与干化污泥掺混热解产气特性。实验结果表明：烟煤掺混干化污泥热解，不改变两者热解产H2、CO和CH4的规律。在相同热解温度下，烟煤的掺混比例越高，产生H2体积百分含量越大。对于CH4，掺混物料产气峰值热解温度由800 ℃降低至700 ℃。混合物料中污泥掺混比例增加会增加CO含量。通过热重实验，随着物料中配入干化污泥质量比重增加，热解反应所需活化能减小。

English Abstract

Medium-level temperature pyrolysis of mixture of dried sewage sludge and bituminous coal for syngas production

LI Gang^1,2,,
SHU Xinqian¹

1. School of Chemical & Environmental Engineering, China University of Mining & Technology Beijing, Beijing 100083, China
2. School of Resource & Environment, Henan University of Engineering, Zhengzhou 451191, China

Fund Project:

Keywords:

Abstract: Medium-level temperature co-pyrolysis gas production characteristics on some dried sewage sludge and two different kinds of bituminous coals were investigated on the experimental tube furnace with different mixing ratio for sample pretreatment, respectively. The results of co-pyrolysis of bituminous coal and dried sewage sludge indicated that the values of H2，CO and CH4 concentration were similar to those of bituminous coal or dried sewage sludge in each pyrolysis stage. At the same pyrolysis temperature, the higher the blending ratio of bituminous coal could lead to generate the larger the H2 concentration. For CH4 gas, the pyrolysis temperature of the peak concentration was dropped from 800 ℃ to 700 ℃. The increase of dried sewage sludge mixing ratio in the mixture pyrolysis would increase the CO content. The activation energy of pyrolysis different blend samples was analyzed using a thermogravimetric analyzer, it was found that dried sewage sludge addition could decrease activation energy, the higher the proportion of dried sewage sludge in the mixture was, the less activation energy was.

全文HTML

参考文献 (26)

下载: 全尺寸图片幻灯片

返回文章

用微信扫码二维码

分享至好友和朋友圈

2种烟煤掺混干化污泥中温热解制气

Medium-level temperature pyrolysis of mixture of dried sewage sludge and bituminous coal for syngas production

计量

出版历程

2种烟煤掺混干化污泥中温热解制气

English Abstract

Medium-level temperature pyrolysis of mixture of dried sewage sludge and bituminous coal for syngas production

全文HTML

目录