谷氨酸发酵废菌体的水解与替代酵母膏生产多聚谷氨酸

刘旭; 武琳慧; 刘姣姣; 卢松; 赵吉

doi:10.12030/j.cjee.201803037

环境工程学报

谷氨酸发酵废菌体的水解与替代酵母膏生产多聚谷氨酸

, , , ,

刘旭, 武琳慧, 刘姣姣, 卢松, 赵吉. 谷氨酸发酵废菌体的水解与替代酵母膏生产多聚谷氨酸[J]. 环境工程学报, 2018, 12(8): 2403-2411. doi: 10.12030/j.cjee.201803037

引用本文:

刘旭, 武琳慧, 刘姣姣, 卢松, 赵吉. 谷氨酸发酵废菌体的水解与替代酵母膏生产多聚谷氨酸[J]. 环境工程学报, 2018, 12(8): 2403-2411. doi: 10.12030/j.cjee.201803037

LIU Xu, WU Linhui, LIU Jiaojiao, LU Song, ZHAO Ji. Hydrolysis of glutamic acid fermented waste bacteria and substitution of yeast extract for production of polyglutamic acid[J]. Chinese Journal of Environmental Engineering, 2018, 12(8): 2403-2411. doi: 10.12030/j.cjee.201803037

Citation:

LIU Xu, WU Linhui, LIU Jiaojiao, LU Song, ZHAO Ji. Hydrolysis of glutamic acid fermented waste bacteria and substitution of yeast extract for production of polyglutamic acid[J]. Chinese Journal of Environmental Engineering, 2018, 12(8): 2403-2411. doi: 10.12030/j.cjee.201803037

谷氨酸发酵废菌体的水解与替代酵母膏生产多聚谷氨酸

1.
内蒙古大学生态与环境学院，呼和浩特 010021
2.
内蒙古阜丰生物科技有限公司，呼和浩特 010070
基金项目:
国家科技支撑计划课题（2015BAD15B04）

Hydrolysis of glutamic acid fermented waste bacteria and substitution of yeast extract for production of polyglutamic acid

1.
School of Ecology and Environment, Inner Mongolia University, Huhhot 010021, China
2.
Inner Mongolia Fufeng Biological Technology Co.Ltd., Huhhot 010070, China
Fund Project:

摘要: 为研究谷氨酸发酵废菌体水解液用作培养基氮源的可行性，以蛋白质水解度和溶解度为衡量指标，采用化学、生物、物理以及这几种方法的联合处理，通过正交优化实验，得出了菌体蛋白水解的最佳工艺条件为化学-生物联合处理，在盐酸浓度3 mol·L-1、温度110 ℃、料液比1:0.5、水解12 h后使用酸性蛋白酶酶解，调节料液pH为4、酶底比2.5%、温度55 ℃、酶解8 h，水解完成后蛋白质水解度达到47.18%，溶解度达到94.09%。在总氮相等的情况下，将水解液和酵母膏以不同的比例组合，替代正常发酵产γ-聚谷氨酸过程的氮源。结果表明谷氨酸发酵废菌体经过最佳工艺水解后，其水解液可以用作发酵产γ-聚谷氨酸的氮源。
- 菌体蛋白 /
- 水解 /
- 氮源 /
- γ-聚谷氨酸
Abstract: The feasibility of using the hydrolysate of waste microbial biomass from glutamate fermentation as a nitrogen source for γ-polyglutamic acid fermentation was investigated. Hydrolysis of the waste microbial biomass was firstly optimized with protein hydrolysability and solubility as indictors. The optimal hydrolysis conditions were achieved by orthogonal experimental design with chemical, biological, physical and combined methods. The chemical-biochemical combined method led to a protein hydrolysabilty of 47.18% and solubility of 94.09%. With this method, chemical hydrolysis was firstly conducted at 110 °C for 12 h with a substrate to liquid ratio of 1:0.5 and a hydrochloric concentration of 3 mol·L-1, followed by enzymatic hydrolysis at 55 °C for 8 h at pH 4.0 and an acidic protease loading of 2.5% (on substrate). Under the same nitrogen concentration, the hydrolysate and yeast extract were mixed at different ratios and used as a nitrogen source for γ-polyglutamic acid fermentation. The results show that it is feasible to use the hydrolysate of waste microbial biomass prepared at the optimal hydrolysis conditions as the nitrogen source for γ-polyglutamic acid fermentation.
- bacterial protein /
- hydrolysis /
- nitrogen resource /
- γ-polyglutamic acid

[1]	董力青,黄敏,曾凤彩.谷氨酸发酵废液中菌体蛋白的应用进展[J].发酵科技通讯,2013,42(1):49-50
[2]	杨小姣,冯雪荣,孙金斗,等.谷氨酸发酵废水中提取菌体蛋白研究进展[J].中国酿造,2009(8):20-24
[3]	袁品坦.谷氨酸菌体蛋白的开发和利用[J].饲料研究,1991(3):2-4
[4]	赵晓芳.味精菌体蛋白资源调研及营养价值评定[D].泰安：山东农业大学,2003
[5]	马猛华,徐国华,田智斌,等.谷氨酸菌体蛋白的应用与开发[J].中国酿造,2014,33(2):9-12
[6]	詹文圆.以干鸡粪、醋渣、味精菌体蛋白以及花生秧粉为主要原料生产木腐食用菌浓缩培养基的方法：CN103172417A[P].2013-06-26
[7]	孟逸群,孟庆华.一种含镍液体络合肥的生产方法：CN102701871A[P].2012-10-03
[8]	秦东清,赵修念.一种利用谷氨酸菌体制备肉味呈味料的方法：CN102178206A[P].2011-09-14
[9]	朱宇旌,张勇,王秉玉.一种味精蛋白粉中提取寡肽的方法：CN103005154A[P].2013-04-03
[10]	杨晓玲,张建英,刘艳芳,等.谷氨酸发酵废醪菌渣营养分析及其RNA的提取[J].河北科技师范学院学报,2010,24(3):34-36
[11]	游庆红,张新民,陈国广,等.γ-聚谷氨酸的生物合成及应用[J].现代化工,2002(12):56-59
[12]	SHIHI L, VAN Y T.The production of poly-(gamma-glutamic acid) from microorganisms and its various applications[J].Bioresource Technology,2001,79(3):207-225 10.1016/s0960-8524(01)00074-8
[13]	SUNGM H, PARK C, KIMC J, et al.Natural and edible biopolymer poly-gamma-glutamic acid: Synthesis, production, and applications[J].Chemical Record,2010,5(6):352-366 10.1002/tcr.20061
[14]	宁正祥.食品成分分析手册[M].北京：中国轻工业出版社，1998：119-124
[15]	姚菁华,肖雷.谷氨酸菌体蛋白的酶解试验研究[J].淮海工学院学报(自然科学版),2002,11(4):52-55
[16]	魏少军,谭青乔,刘淑云,等.利用谷氨酸发酵废菌体生产酵母精[J].发酵科技通讯,2002,31(4):7-8.
[17]	楚杰,王德源,张力群,等.利用谷氨酸废菌体生产复合氨基酸饲料添加剂的研究[J].山东食品发酵,2004(1):12-13
[18]	丛泽峰,李辉,韩隽,等.菌体蛋白水解液应用于谷氨酸发酵的研究[J].中国调味品,2017,42(2):109-111
[19]	王霜,吴振强,余若黔,等.谷氨酸菌体破碎条件的优化研究[J].生物技术,1997(5):26-30
[20]	徐虹, 欧阳平凯. 生物高分子:微生物合成的原理与实践[M].北京：化学工业出版社,2010：6-9
[21]	KO Y H, GROSS R A.Effects of glucose and glycerol on γ-poly(glutamic acid) formation by Bacillus licheniformis ATCC 9945a[J].Biotechnology & Bioengineering,1998,57(4):430-437 10.1002/(SICI)1097-0290(19980220)57:43.0.CO;2-N
[22]	]XU H, JIANG M, LI H, et al.Efficient production of poly(γ-glutamic acid) by newly isolated Bacillus subtilis NX-2[J].Process Biochemistry,2005,40(2):519-523 10.1016/j.procbio.2003.09.025
[23]	GOTO A, KUNIOKA M.Biosynthesis and hydrolysis of poly(γ-glutamic acid) from Bacillus subtilis IF03335[J].Bioscience Biotechnology & Biochemistry,1992,56(7):1031-1035 10.1016/b978-0-444-81708-2.50046-4

点击查看大图

计量

文章访问数: 3162
HTML全文浏览数: 2914
PDF下载数: 147
施引文献: 0

刘旭, 武琳慧, 刘姣姣, 卢松, 赵吉. 谷氨酸发酵废菌体的水解与替代酵母膏生产多聚谷氨酸[J]. 环境工程学报, 2018, 12(8): 2403-2411. doi: 10.12030/j.cjee.201803037

引用本文:

刘旭, 武琳慧, 刘姣姣, 卢松, 赵吉. 谷氨酸发酵废菌体的水解与替代酵母膏生产多聚谷氨酸[J]. 环境工程学报, 2018, 12(8): 2403-2411. doi: 10.12030/j.cjee.201803037

Citation:

LIU Xu, WU Linhui, LIU Jiaojiao, LU Song, ZHAO Ji. Hydrolysis of glutamic acid fermented waste bacteria and substitution of yeast extract for production of polyglutamic acid[J]. Chinese Journal of Environmental Engineering, 2018, 12(8): 2403-2411. doi: 10.12030/j.cjee.201803037

谷氨酸发酵废菌体的水解与替代酵母膏生产多聚谷氨酸

1. 内蒙古大学生态与环境学院，呼和浩特 010021
2. 内蒙古阜丰生物科技有限公司，呼和浩特 010070

基金项目:

国家科技支撑计划课题（2015BAD15B04）

关键词:

菌体蛋白 /
水解 /
氮源 /
γ-聚谷氨酸

摘要: 为研究谷氨酸发酵废菌体水解液用作培养基氮源的可行性，以蛋白质水解度和溶解度为衡量指标，采用化学、生物、物理以及这几种方法的联合处理，通过正交优化实验，得出了菌体蛋白水解的最佳工艺条件为化学-生物联合处理，在盐酸浓度3 mol·L-1、温度110 ℃、料液比1:0.5、水解12 h后使用酸性蛋白酶酶解，调节料液pH为4、酶底比2.5%、温度55 ℃、酶解8 h，水解完成后蛋白质水解度达到47.18%，溶解度达到94.09%。在总氮相等的情况下，将水解液和酵母膏以不同的比例组合，替代正常发酵产γ-聚谷氨酸过程的氮源。结果表明谷氨酸发酵废菌体经过最佳工艺水解后，其水解液可以用作发酵产γ-聚谷氨酸的氮源。

English Abstract

Hydrolysis of glutamic acid fermented waste bacteria and substitution of yeast extract for production of polyglutamic acid

1. School of Ecology and Environment, Inner Mongolia University, Huhhot 010021, China
2. Inner Mongolia Fufeng Biological Technology Co.Ltd., Huhhot 010070, China

Fund Project:

Keywords:

Abstract: The feasibility of using the hydrolysate of waste microbial biomass from glutamate fermentation as a nitrogen source for γ-polyglutamic acid fermentation was investigated. Hydrolysis of the waste microbial biomass was firstly optimized with protein hydrolysability and solubility as indictors. The optimal hydrolysis conditions were achieved by orthogonal experimental design with chemical, biological, physical and combined methods. The chemical-biochemical combined method led to a protein hydrolysabilty of 47.18% and solubility of 94.09%. With this method, chemical hydrolysis was firstly conducted at 110 °C for 12 h with a substrate to liquid ratio of 1:0.5 and a hydrochloric concentration of 3 mol·L-1, followed by enzymatic hydrolysis at 55 °C for 8 h at pH 4.0 and an acidic protease loading of 2.5% (on substrate). Under the same nitrogen concentration, the hydrolysate and yeast extract were mixed at different ratios and used as a nitrogen source for γ-polyglutamic acid fermentation. The results show that it is feasible to use the hydrolysate of waste microbial biomass prepared at the optimal hydrolysis conditions as the nitrogen source for γ-polyglutamic acid fermentation.

全文HTML

参考文献 (23)

下载: 全尺寸图片幻灯片

返回文章

用微信扫码二维码

分享至好友和朋友圈

谷氨酸发酵废菌体的水解与替代酵母膏生产多聚谷氨酸

Hydrolysis of glutamic acid fermented waste bacteria and substitution of yeast extract for production of polyglutamic acid

计量

出版历程

谷氨酸发酵废菌体的水解与替代酵母膏生产多聚谷氨酸

English Abstract

Hydrolysis of glutamic acid fermented waste bacteria and substitution of yeast extract for production of polyglutamic acid

全文HTML

目录