高级搜索

活性炭协同Fe2+催化H2O2氧化处理染料废水及其表面附着污染物对催化活性的影响

,  ,  ,  , 

downloadPDF

上一篇

下一篇

杨梦婷, 杜夕铭, 卢钧, 唐聪, 陈泉源. 活性炭协同Fe2+催化H2O2氧化处理染料废水及其表面附着污染物对催化活性的影响[J]. 环境工程学报, 2018, 12(8): 2170-2177. doi: 10.12030/j.cjee.201802035
引用本文: 杨梦婷, 杜夕铭, 卢钧, 唐聪, 陈泉源. 活性炭协同Fe2+催化H2O2氧化处理染料废水及其表面附着污染物对催化活性的影响[J]. 环境工程学报, 2018, 12(8): 2170-2177. doi: 10.12030/j.cjee.201802035
shu
YANG Mengting, DU Ximing, LU Jun, TANG Cong, CHEN Quanyuan. Effect of activated carbon attached pollutants and synergize Fe2+ on treatment of dye wastewater by catalytic oxidation of H2O2[J]. Chinese Journal of Environmental Engineering, 2018, 12(8): 2170-2177. doi: 10.12030/j.cjee.201802035
Citation: YANG Mengting, DU Ximing, LU Jun, TANG Cong, CHEN Quanyuan. Effect of activated carbon attached pollutants and synergize Fe2+ on treatment of dye wastewater by catalytic oxidation of H2O2[J]. Chinese Journal of Environmental Engineering, 2018, 12(8): 2170-2177. doi: 10.12030/j.cjee.201802035
shu

活性炭协同Fe2+催化H2O2氧化处理染料废水及其表面附着污染物对催化活性的影响

  • 1.

    东华大学环境科学与工程学院，上海 201620

  • 2.

    上海污染控制与生态安全研究院，上海 200092

  • 基金项目:

    国家重点研发计划（2016YFC0400502）

Effect of activated carbon attached pollutants and synergize Fe2+ on treatment of dye wastewater by catalytic oxidation of H2O2

  • 1.

    School of Environmental Science and Engineering, Donghua University, Shanghai 201620, China

  • 2.

    Shanghai Institute of Pollution Control and Ecological Security, Shanghai 200092, China

  • Fund Project:

  • 摘要: 采用动态连续处理装置研究颗粒活性炭（GAC）催化H2O2氧化活性红X-3B染料（RRX-3B）的效能以及GAC表面吸附污染物对催化性能的影响，考察GAC与Fe2+协同催化作用。研究结果表明：RRX-3B的处理效果随着流速的增加而逐渐降低；新GAC/H2O2体系降解效果优于单独GAC吸附与单独H2O2氧化，GAC重复使用存在部分失活现象使其脱色率和COD去除率下降，且表面预先吸附污染物的GAC在重复使用过程中下降更为明显；固定H2O2投加量为5 mmol·L-1，按n（Fe2+）：n（H2O2）为1:20投加Fe2+，GAC与Fe2+联合体系能持续有效使RRX-3B氧化脱色，重复使用4次后脱色率仍可达99.65%，GAC和Fe2+之间存在协同催化H2O2降解RRX-3B的作用。GAC表面附着的Fe2+能够加强催化作用，且有效延长其使用寿命。
    Abstract: By using granular activated carbon (GAC) to catalyze H2O2 oxidation reactive red X-3B (RRX-3B), the catalytic effect GAC in dynamic and continuous treatment equipment and the influence of adsorbed pollutants catalytic performance of GAC was studied. The synergistic catalysis of GAC and Fe2+ was also explored. The results showed that the degradation effect of reactive red dye wastewater is gradually reduced with the increase of flow velocity. The degradation efficiency of the new GAC/H2O2 system was better than that of the separate GAC adsorption and the separate H2O2 oxidation. The reuse of activated carbon resulted in partial inactivation, which made the decolorization rate and COD removal rate decrease, and the removal rate of GAC with surface attachment pollutants decreased more obviously during the reuse process. The dosage of fixed H2O2 was 5 mmol·L-1, and the amount of Fe2+ was added according to n (Fe2+):n (H2O2) equal to 1:20. The combined system of GAC and Fe2+ can persistently and effectively oxidize the decolorizing RRX-3B, and the decolorization rate still reaches 99.65% when the GAC is reused for 4 times. There is a synergistic effect between GAC and Fe2+ on the degradation of RRX-3B by H2O2. The Fe2+ adsorbed on the surface of GAC can enhance the catalytic activity and prolong the service life of GAC effectively.
  • 加载中
  • [1] 倪军，罗小芳，詹勇，等.新型碳材料在催化领域中的应用及进展[J].分子催化,2016,30(3):282-296
    [2] CODONY C A, GONZALEZOLMOS R.Regeneration of siloxane-exhausted activated carbon by advanced oxidation processes[J].Journal of Hazardous Materials,2015,285:501-508 10.1016/j.jhazmat.2014.11.053
    [3] 王宇轩，王应军，方明珠.活性炭负载CuO催化过硫酸盐去除活性艳红X-3B染料[J].环境工程学报,2016,10(1):230-236
    [4] 杨长河，曹定龙，俞明芬，等.吸附DBP饱和活性炭的低温等离子体再生实验[J].高电压技术,2015,41(10):3505-3511
    [5] YANG X, YANG S Y, WANG L L, et al.Activated carbon catalyzed persulfate oxidation of azo dye acid orange 7 in aqueous solution[J].Environmental Science,2011,32(7):1960-1966
    [6] ZHANG J, SHAO X, SHI C, et al.Decolorization of acid orange 7 with peroxymonosulfate oxidation catalyzed by granular activated carbon[J].Chemical Engineering Journal,2013,232(10):259-265 10.1016/j.cej.2013.07.108
    [7] 杨鑫，杨世迎，邵雪停，等.活性炭催化过氧化物高级氧化技术降解水中有机污染物[J].化学进展,2010,22(10):2071-2078
    [8] HUANG H H, LU M C, CHEN J N, et al.Catalytic decomposition of hydrogen peroxide and 4-chlorophenol in the presence of modified activated carbons[J].Chemosphere,2003,51(9):935-943
    [9] REY A, ZAZO J A, CASAS J A, et al.Influence of the structural and surface characteristics of activated carbon on the catalytic decomposition of hydrogen peroxide[J].Applied Catalysis A: General,2011,402(1/2):146-155 10.1016/j.apcata.2011.05.040
    [10] 汪毅，赵冬霞，封莉，等.活性炭催化臭氧氧化深度处理工艺对酵母发酵废水中有机物的去除特性分析[J].环境工程学报,2017,11(11):5820-5827 10.12030/j.cjee.201608144
    [11] OLIVEIRA T F D, CHEDEVILLE O, AUDUET H, et al.Use of ozone/activated carbon coupling to remove diethyl phthalate from water: Influence of activated carbon textural and chemical properties[J].Desalination,2011,276(1):359-365 10.1016/j.desal.2011.03.084
    [12] 刘新亮，尹海亮，蔺爱国，等.Fenton试剂的反应机理及动力学研究进展[J].工业水处理,2017,37(5):10-14 10.11894/1005-829x.2017.37(5).010
    [13] 国家环境保护局.水质 化学需氧量的测定 重铬酸盐法:GB 11914-1989[S].北京:中国环境科学出版社,1989
    [14] JOSEPH J P, ESTHER O, ALLISON M.Advanced oxidation processes for organic contaminant destruction based on the Fenton reaction and related chemistry[J].Critical Reviews in Environmental Science & Technology,2006,36(1):1-84 10.1080/10643380500326564
    [15] MESQUITA I, MATOS L C, DUARTE F, et al.Treatment of azo dye-containing wastewater by a Fenton-like process in a continuous packed-bed reactor filled with activated carbon[J].Journal of Hazardous Materials,2012,237-238:30-37 10.1016/j.jhazmat.2012.07.066
    [16] HULING S G, HWANG S.Iron amendment and Fenton oxidation of MTBE-spent granular activated carbon[J].Water Research，2010,44(8):2663-2671 10.1016/j.watres.2010.01.035
    [17] 张勇，陈春，龚万兵，等.活性炭负载Pt/Fe3O4催化剂及其选择性转移加氢肉桂醛的催化性能[J].化学物理学报, 2017,30(4):467-473 10.1063/1674-0068/30/cjcp1703059
    [18] 李章良，黄建辉，肖尚忠，等.活性炭负载Fe3+催化H2O2氧化邻苯二甲酸二甲酯[J].环境工程学报,2014,8(3):827-833
    [19] YU G, LU S, CHEN H, et al.Diesel fuel desulfurization with hydrogen peroxide promoted by formic acid and catalyzed by activated carbon[J].Carbon,2005,43(11):2285-2294 10.1016/j.carbon.2005.04.008
    [20] WANG L, YAO Y, SUN L, et al.Activation of hydrogen peroxide by activated carbon fibers coupled with Fe(Ⅲ)-citrate for degradation of dyes at neutral pH[J].Acta Chimica Sinica,2013,71(12):1633-1638 10.6023/A13080832
    [21] FANG G, LIU C, GAO J, et al.New insights into the mechanism of the catalytic decomposition of hydrogen peroxide by activated carbon: Implications for the degradation of diethyl phthalate[J].Industrial & Engineering Chemistry Research,2014,53(51):19925-19933 10.1021/ie504184r
    [22] 张先龙，郭勇，张恒建，等.助剂Fe添加对柱状MnOx/PG-AC催化剂低温选择性催化还原(SCR)性能影响[J].环境化学,2015, 34(8):1535-1544
    [23] 葛磊，王静，陈欢，等.活性炭负载水合氧化铁对草甘膦吸附性能的研究[J].环境工程学报,2009,3(10):1745-1748
    [24] 肖冠南，王梓屹，宋翔，等.活性炭负载铁催化剂催化氧化聚乙烯醇废水[J].工业水处理,2016,36(12):35-38
  • 加载中
WeChat 点击查看大图
计量
  • 文章访问数:  3851
  • HTML全文浏览数:  3496
  • PDF下载数:  228
  • 施引文献:  0
出版历程
  • 刊出日期:  2018-08-17
杨梦婷, 杜夕铭, 卢钧, 唐聪, 陈泉源. 活性炭协同Fe2+催化H2O2氧化处理染料废水及其表面附着污染物对催化活性的影响[J]. 环境工程学报, 2018, 12(8): 2170-2177. doi: 10.12030/j.cjee.201802035
引用本文: 杨梦婷, 杜夕铭, 卢钧, 唐聪, 陈泉源. 活性炭协同Fe2+催化H2O2氧化处理染料废水及其表面附着污染物对催化活性的影响[J]. 环境工程学报, 2018, 12(8): 2170-2177. doi: 10.12030/j.cjee.201802035
shu
YANG Mengting, DU Ximing, LU Jun, TANG Cong, CHEN Quanyuan. Effect of activated carbon attached pollutants and synergize Fe2+ on treatment of dye wastewater by catalytic oxidation of H2O2[J]. Chinese Journal of Environmental Engineering, 2018, 12(8): 2170-2177. doi: 10.12030/j.cjee.201802035
Citation: YANG Mengting, DU Ximing, LU Jun, TANG Cong, CHEN Quanyuan. Effect of activated carbon attached pollutants and synergize Fe2+ on treatment of dye wastewater by catalytic oxidation of H2O2[J]. Chinese Journal of Environmental Engineering, 2018, 12(8): 2170-2177. doi: 10.12030/j.cjee.201802035
shu

活性炭协同Fe2+催化H2O2氧化处理染料废水及其表面附着污染物对催化活性的影响

  • 1. 东华大学环境科学与工程学院，上海 201620
  • 2. 上海污染控制与生态安全研究院，上海 200092
基金项目:

国家重点研发计划（2016YFC0400502）

摘要: 采用动态连续处理装置研究颗粒活性炭（GAC）催化H2O2氧化活性红X-3B染料（RRX-3B）的效能以及GAC表面吸附污染物对催化性能的影响，考察GAC与Fe2+协同催化作用。研究结果表明：RRX-3B的处理效果随着流速的增加而逐渐降低；新GAC/H2O2体系降解效果优于单独GAC吸附与单独H2O2氧化，GAC重复使用存在部分失活现象使其脱色率和COD去除率下降，且表面预先吸附污染物的GAC在重复使用过程中下降更为明显；固定H2O2投加量为5 mmol·L-1，按n（Fe2+）：n（H2O2）为1:20投加Fe2+，GAC与Fe2+联合体系能持续有效使RRX-3B氧化脱色，重复使用4次后脱色率仍可达99.65%，GAC和Fe2+之间存在协同催化H2O2降解RRX-3B的作用。GAC表面附着的Fe2+能够加强催化作用，且有效延长其使用寿命。

English Abstract

参考文献 (24)

返回顶部

目录

/

返回文章
返回

Copyright © 2019 中国科学院生态环境研究中心