高级搜索

UASB-SBR工艺处理规模化畜禽养殖废水

,  ,  ,  , 

downloadPDF

上一篇

下一篇

杜龑, 周北海, 袁蓉芳, 包向明, 李冬溦. UASB-SBR工艺处理规模化畜禽养殖废水[J]. 环境工程学报, 2018, 12(2): 497-504. doi: 10.12030/j.cjee.201708147
引用本文: 杜龑, 周北海, 袁蓉芳, 包向明, 李冬溦. UASB-SBR工艺处理规模化畜禽养殖废水[J]. 环境工程学报, 2018, 12(2): 497-504. doi: 10.12030/j.cjee.201708147
shu
DU Yan, ZHOU Beihai, YUAN Rongfang, BAO Xiangming, LI Dongwei. Treatment of large-scale livestock wastewater by UASB-SBR process[J]. Chinese Journal of Environmental Engineering, 2018, 12(2): 497-504. doi: 10.12030/j.cjee.201708147
Citation: DU Yan, ZHOU Beihai, YUAN Rongfang, BAO Xiangming, LI Dongwei. Treatment of large-scale livestock wastewater by UASB-SBR process[J]. Chinese Journal of Environmental Engineering, 2018, 12(2): 497-504. doi: 10.12030/j.cjee.201708147
shu

UASB-SBR工艺处理规模化畜禽养殖废水

  • 1.

    北京科技大学能源与环境工程学院,北京 100083

  • 2.

    北京科技大学工业典型污染物资源化处理北京市重点实验室,北京 100083

  • 3.

    江苏泰源环保科技股份有限公司,宜兴 214266

  • 4.

    北京博世科环保科技有限公司,北京 100020

  • 基金项目:

    国家水体污染控制与治理科技重大专项(2015ZX07203-011)

Treatment of large-scale livestock wastewater by UASB-SBR process

  • 1.

    School of Energy and Environmental Engineering, University of Science and Technology Beijing, Beijing 100083,China

  • 2.

    Beijing Key Laboratory of Resource-Oriented Treatment of Industrial Pollutants, University of Science and Technology Beijing, Beijing 100083,China

  • 3.

    Jiangsu Taiyuan Environmental Science and Technology Co.Ltd., Yixing 214266,China

  • 4.

    Beijing BOSCH Environmental Science and Technology Co.Ltd., Beijing 100020,China

  • Fund Project:

  • 摘要: 针对规模化畜禽养殖废水常规厌氧-好氧组合处理工艺及SBR处理工艺脱氮效率低、运行费用高等问题,采用UASB-SBR工艺,研究3种不同的SBR模式对处理效果的影响。结果表明,UASB容积负荷(以COD计)8 kg·(m3·d)-1、pH 7.0、温度35 ℃、HRT 25 h时,COD去除率为80%~85%；SBR在进水15 min、反应480 min、沉淀60 min、出水15 min、闲置810 min条件下,对废水COD、NH+4-N、和TN去除率分别为91.8%、98.7%和71.6%,出水COD≤180 mg·L-1、NH+4-N2-N积累率超过50%,出现了NO-2-N积累,短程硝化反硝化是主要脱氮方式。
    Abstract: In this paper, a treatment process of UASB-SBR was built to treat the large scale livestock wastewater, which aimed to solve the problem of conventional anaerobic-aerobic treatment process and SBR treatment process including low denification efficiency, high operating costs and so on. Based on the treatment process, three kinds of SBR experiment were studied. It can be seen from the experiment that when the volume loading(calculated by COD) was 8 kg·(m3·d)-1, with the pH value of 7,the temperature of 35 ℃ and HRT of 25 h, the removal efficiency of COD was from 80% to 85% during the anaerobic process (UASB). For the optimized SBR treatment conditions (influent 15 min, reaction 480 min, precipitation 60 min, effluent 15 min, idle 810 min), the removal efficiency of COD,NH+4-N and TN in livestock wastewater in SBR were 91.8%,98.7% and 71.6%, respectively. The effluent COD was less than 180 mg·L-1, NH+4-N<15 mg·L-1, TN<50 mg·L-1, meeting the Discharge Standard of Pollutants for Livestock and Poultry Breeding(GB 18596-2001). The nitrite accumulation occurred and shortcut nitrification denitrification was the main way of nitrogen removal.
  • 加载中
  • [1] CHEN Q, WANG Y L, ZHAO L, et al.Synchronous start-up of anaerobic baffled reactor-membrane biofilm bioreactor(ABR-MABR)coupling process treating synthetic livestock and poultry wastewater[J].Research of Environmental Sciences,2017,0(2):298-305
    [2] JIA H, WU R J, HUANG J, et al.Review and forecast on biology treatment technology of intensive livestock wastewater[J].Technology of Water Treatment,2008,4(7):7-11
    [3] XIAO H, YANG P, PENG H, et al.Nitrogen removal from livestock and poultry breeding wastewaters using a novel sequencing batch biofilm reactor[J].Water Science and Technology,2010,2(11):2599-2606
    [4] KIM T H, NAM Y K, LIM S J.Effects of ionizing radiation on struvite crystallization of livestock wastewater[J].Radiation Physics & Chemistry,2014,7(2):332-336
    [5] ZHAO B, LI J, BUELNA G, et al.A combined upflow anaerobic sludge bed and trickling biofilter process for the treatment of swine wastewater[J].Environmental Technology,2016,7(10):1265-1275
    [6] YAMAMOTO T, TAKAKI K, KOYAMA T, et al.Long-term stability of partial nitritation of swine wastewater digester liquor and its subsequent treatment by anammox[J].Bioresource Technology,2008,9:6419-6425
    [7] BERNET N, DELGENES N, AKUNNA J C, et al.Combined anaerobic and aerobic SBR for the treatment of piggery wastewater[J].Water Research,2000,4(2):611-619
    [8] 王欢,裴伟征,李旭东,等.低碳氮比猪场废水短程硝化反硝化-厌氧氨氧化脱氮[J].环境科学,2009,0(3):815-821
    [9] 邱丽娟,陈亮,黄满红.UASB反应器处理染料及印染废水的研究进展[J].化工环保,2009,9(5):416-419
    [10] 段焱,邓仕槐,朱春兰,等.悬浮填料SBR处理畜禽废水效果研究[J].安全与环境工程,2010,7(4):9-12
    [11] GUO J, PENG Y, WANG S, et al.Long-term effect of dissolved oxygen on partial nitrification performance and microbial community structure[J].Bioresource Technology,2009,0(11):2796-2802
    [12] 彭举威,王宏哲,崔玉波,等.高效厌氧折流板反应器分区进水的启动实验[J].环境科学与技术, 2008(11):28-33
    [13] 王亮,陈重军,陈英旭,等.规模化猪场养殖废水UASB-SFSBR-MAP处理工艺中试研究[J].环境科学,2013,4(3):979-985
    [14] DENG L W, ZHENG P, CHEN Z A.Anaerobic digestion and posttreatment of swine wastewater using IC-SBR process with bypass of raw wastewater[J].Process Biochemistry,2006,1(4):965-969
    [15] 任健,李军,苏雷,等.酸化液对厌氧释磷好氧吸磷速率的影响研究[J].环境工程,2011,9(S1):103-107
    [16] 刘光瑞,马邕文,万金泉.不同容积负荷下有机废水发酵产酸和产乙醇特性[J].环境工程学报,2016,0(2):729-734
    [17] 吴美容,张瑞,周俊,等.温度对产甲烷菌代谢途径和优势菌群结构的影响[J].化工学报,2014,5(5):1602-1606
    [18] 闫立龙,王晓辉,梁海晶,等.UASB去除猪场废水有机物影响因素研究[J].安全与环境学报,2013,3(3):61-65
    [19] 班巧英,李建政,张立国,等.HRT对UASB运行效能及丙酸氧化菌群组成的影响[J].化工学报,2012,3(11):3673-3679
    [20] GAO D W, PENG Y Z, LI B K, et al.Shortcut nitrification denitrification by real-time control strategies[J].Bioresource Technology,2009,0(7):2298-2300
    [21] 苏东霞,李冬,张肖静,等.曝停时间比对间歇曝气SBR短程硝化的影响[J].中国环境科学,2014,4(5):1152-1158
    [22] MOTA C,HEAD M A,RIDENOURE J A,et al.Effects of aeration cycles on nitrifying bacterial populations and nitrogen removal in intermittently aerated reactors[J].Applied & Environmental Microbiology,2005,71(12):8565-8572
    [23] 高大文,彭永臻,王淑莹.短程硝化生物脱氮工艺的稳定性[J].环境科学,2005,6(1):63-67
    [24] 彭永臻,杨岸明,李凌云,等.短程硝化最优曝气时间控制与硝化种群调控[J].哈尔滨工业大学学报,2013,5(2):101-105
    [25] 朱春兰,邓仕槐,肖鸿,等.新型SBBR处理畜禽废水脱氮实验研究[J].环境工程学报,2010,4(7):1525-1528
    [26] 孙洪伟,吕心涛,魏雪芬,等.游离氨(FA)耦合曝气时间对硝化菌活性的抑制影响[J].环境科学,2016,7(3):1075-1081
  • 加载中
WeChat 点击查看大图
计量
  • 文章访问数:  3916
  • HTML全文浏览数:  3475
  • PDF下载数:  660
  • 施引文献:  0
出版历程
  • 刊出日期:  2018-02-08
杜龑, 周北海, 袁蓉芳, 包向明, 李冬溦. UASB-SBR工艺处理规模化畜禽养殖废水[J]. 环境工程学报, 2018, 12(2): 497-504. doi: 10.12030/j.cjee.201708147
引用本文: 杜龑, 周北海, 袁蓉芳, 包向明, 李冬溦. UASB-SBR工艺处理规模化畜禽养殖废水[J]. 环境工程学报, 2018, 12(2): 497-504. doi: 10.12030/j.cjee.201708147
shu
DU Yan, ZHOU Beihai, YUAN Rongfang, BAO Xiangming, LI Dongwei. Treatment of large-scale livestock wastewater by UASB-SBR process[J]. Chinese Journal of Environmental Engineering, 2018, 12(2): 497-504. doi: 10.12030/j.cjee.201708147
Citation: DU Yan, ZHOU Beihai, YUAN Rongfang, BAO Xiangming, LI Dongwei. Treatment of large-scale livestock wastewater by UASB-SBR process[J]. Chinese Journal of Environmental Engineering, 2018, 12(2): 497-504. doi: 10.12030/j.cjee.201708147
shu

UASB-SBR工艺处理规模化畜禽养殖废水

  • 1. 北京科技大学能源与环境工程学院,北京 100083
  • 2. 北京科技大学工业典型污染物资源化处理北京市重点实验室,北京 100083
  • 3. 江苏泰源环保科技股份有限公司,宜兴 214266
  • 4. 北京博世科环保科技有限公司,北京 100020
基金项目:

国家水体污染控制与治理科技重大专项(2015ZX07203-011)

摘要: 针对规模化畜禽养殖废水常规厌氧-好氧组合处理工艺及SBR处理工艺脱氮效率低、运行费用高等问题,采用UASB-SBR工艺,研究3种不同的SBR模式对处理效果的影响。结果表明,UASB容积负荷(以COD计)8 kg·(m3·d)-1、pH 7.0、温度35 ℃、HRT 25 h时,COD去除率为80%~85%；SBR在进水15 min、反应480 min、沉淀60 min、出水15 min、闲置810 min条件下,对废水COD、NH+4-N、和TN去除率分别为91.8%、98.7%和71.6%,出水COD≤180 mg·L-1、NH+4-N2-N积累率超过50%,出现了NO-2-N积累,短程硝化反硝化是主要脱氮方式。

English Abstract

参考文献 (26)

返回顶部

目录

/

返回文章
返回

Copyright © 2019 中国科学院生态环境研究中心