沼液回流对秸秆与污泥混合中温厌氧消化的影响
Effect of slurry recirculation on mesophilic anaerobic digestion of straw and sludge
-
摘要: 为了提高秸秆与市政污泥混合厌氧消化的消化产率，以秸秆污泥混合物作为底物，在批次实验中研究不同沼液回流对中温（35 ℃）混合厌氧消化过程的影响。实验采用0% 、20%、30%、40%、50%和60%等6种不同的沼液回流量，分析不同沼液回流量下产气量、甲烷含量、发酵过程氨氮含量、sCOD、总挥发酸（VFAs）的变化情况。结果表明：50%的沼液回流产气量和甲烷产量均最大，分别是1 645 mL和797.5 mL，TS和VS去除率达到17.5%和47.8%，单位VS甲烷产量为613.45 mL·g-1，较未加沼液的发酵瓶提高了37.7%，且无VFAs积累。过高的沼液回流量提升了厌氧反应的氨氮浓度，对厌氧产气过程产生了抑制。50%沼液回流量可以作为秸秆污泥混合厌氧消化最佳回流量。Abstract: In order to improve the digestibility of anaerobic co-digestion of straw and municipal sludge, the effects of slurry recirculation on the anaerobic co-digestion process at medium temperature (35 ℃) were studied in batch experiments with the mixture of straw and sludge as the substrate. The recirculation ratio of 0%, 20%, 30%, 40%, 50% and 60%, were adopted and the change of gas yield, methane content, ammonia nitrogen content, sCOD and total volatile acid (VFAs) were analyzed in the fermentation process. The results showed that the maximum gas and methane production (1 645 mL for gas production and 797.5 mL for methane production) were obtained at a recirculation ratio of 50% with a TS removal efficiency of 17.5% and a VS removal efficiency of 47.8%. The methane production rate was up to 613.45 mL·g-1, which was 37.7% higher than that without slurry recirculation, and there was no VFAs accumulation. Excessive slurry recirculation enhances the concentration of ammonia nitrogen in anaerobic reaction and inhibits anaerobic gas production process, therefore, the recirculation ratio of 50% can be used as the optimal ratio in anaerobic digestion of straw and sludge.
-
Key words:
- slurry recirculation /
- corn straw /
- municipal sludge /
- anaerobic digestion /
- thermo alkali /
- ultrasound
-
-
[1] 毕于运,高春雨,王亚静,等. 中国秸秆资源数量估算[J].农业工程学报,2009,25 (12):221－227 [2] STAMS A J M.Metabolic interactions between anaerobic bacteria in methanogenic environments[J].Antonie van Leeuwenhoek,1994,66(1/2/3):271-294 10.1007/BF00871644 [3] 夏益华. 预处理对水葫芦和稻秸厌氧消化产沼气性能的影响研究[D].杭州:浙江大学,2014 [4] 郭香麟,左剑恶,史续川,等.餐厨垃圾与秸秆中温和高温厌氧消化对比[J].环境科学,2017,38(7):3070-3077 10.13227/j.hjkx.201612267 [5] 付融冰,杨海真,甘明强,等.中国城市污水厂污泥处理现状及其进展[J].环境科学与技术,2004,27(5):108-110 [6] 熊振湖.我国污水厂污泥处理与资源化研究[J].天津城市建设学院学报,1999,5(3):6-9 [7] 杨朝勇,王琨,赵庆良.我国污水厂污泥处理与资源化研究[J].环境科学与管理,2017,42(10):97-101 [8] 李伟. 粪便与玉米秸秆混合发酵产气效果研究[D].杨凌:西北农林科技大学,2011 [9] 张晗,王文政,袁旭峰,等.沼液回流对棉花秸秆产甲烷效率及微生物群的影响[J].中国沼气,2018,36(1):19-24 [10] 苏小红,刘伟,王欣.沼液回流对牛粪高温厌氧发酵产气性能的影响[J].黑龙江科学,2015,6(1):1-3 [11] 卢艳娟,尤宇嘉.沼液回流对厌氧沼气工程的影响[J].中国沼气,2015,33(3):66-68 [12] 王佳君,陆洪宇,陈志强,等.接种量对餐厨垃圾中温厌氧产甲烷潜能的影响[J].环境工程学报,2017,11(1):541-545 10.12030/j.cjee.201508090 [13] ANGELIDAKI I,ALVES M,BOLZONELLA D, et al.Defining the biomethane potential(BMP) of solid organic wastes and energy crops:A proposed protocol for batch assays[J].Water Science and Technology,2009,59(5):927-934 10.1016/j.biortech.2007.01.057 [14] CHEN Y,CHENG J J,CREAMER K S.Inhibition of anaerobic digestion process:A review[J].Bioresource Technology,2008,99(10):4044-4064 10.2116/wst.2009.040 [15] 邓玉营,黄振兴,阮文权.沼液回流比与有机负荷对秸秆厌氧发酵特性的影响[J].农业机械学报,2016,47(11):198-206 [16] 张应鹏,陈广银,黑昆仑,等.沼液全量连续回流对稻秸厌氧发酵特性的影响[J].生态与农村环境学报,2017,33(9):845-851 -
点击查看大图
计量
- 文章访问数: 2070
- HTML全文浏览数: 1968
- PDF下载数: 148
- 施引文献: 0
下载:
