高级搜索

新型给水污泥-粉煤灰陶粒性能与除磷效果

,  ,  ,  ,  , 

downloadPDF

上一篇

下一篇

朱宏伟, 于涛, 郭志鹏, 魏东洋, 贺涛, 张恒军. 新型给水污泥-粉煤灰陶粒性能与除磷效果[J]. 环境工程学报, 2018, 12(10): 2741-2750. doi: 10.12030/j.cjee.201803010
引用本文: 朱宏伟, 于涛, 郭志鹏, 魏东洋, 贺涛, 张恒军. 新型给水污泥-粉煤灰陶粒性能与除磷效果[J]. 环境工程学报, 2018, 12(10): 2741-2750. doi: 10.12030/j.cjee.201803010
shu
ZHU Hongwei, YU Tao, GUO Zhipeng, WEI Dongyang, HE Tao, ZHANG Hengjun. Phosphorus removal performance of novel ceramsite made from water treatment sludge and fly ash[J]. Chinese Journal of Environmental Engineering, 2018, 12(10): 2741-2750. doi: 10.12030/j.cjee.201803010
Citation: ZHU Hongwei, YU Tao, GUO Zhipeng, WEI Dongyang, HE Tao, ZHANG Hengjun. Phosphorus removal performance of novel ceramsite made from water treatment sludge and fly ash[J]. Chinese Journal of Environmental Engineering, 2018, 12(10): 2741-2750. doi: 10.12030/j.cjee.201803010
shu

新型给水污泥-粉煤灰陶粒性能与除磷效果

  • 1.

    兰州理工大学石油化工学院，兰州 730050

  • 2.

    环境保护部华南环境科学研究所，广州 510535

  • 3.

    正业设计股份有限公司，哈尔滨 150090

  • 基金项目:

    广州市科技计划科学研究专项（201607010259）

    广东省自然科学基金资助项目（2016A030313021）

    中央级公益性科研院所基本科研业务专项（PM-ZX021-201510-002）

Phosphorus removal performance of novel ceramsite made from water treatment sludge and fly ash

  • 1.

    School of Petrochemical Engineering, Lanzhou University of Technology, Lanzhou 730050, China

  • 2.

    South China Institute of Environmental Sciences, Ministry of Environmental Protection, Guangzhou 510535, China

  • 3.

    Zhengye Design Group Company Limited, Harbin 150090, China

  • Fund Project:

  • 摘要: 为资源化利用自来水厂剩余污泥，以给水污泥、粉煤灰、水玻璃制备新型给水污泥-粉煤灰陶粒（ceramsite made by water treatment sludge and fly ash，CWTSFA），用作污水处理填料。采用短时多段高温煅烧法烧制新型给水污泥陶粒，通过等温吸附实验探讨其吸附磷机理，通过动态吸附实验及CWTSFA基质折流曝气生态滤池除磷效果探究其在实际水处理中的应用前景。实验结果表明：CWTSFA内部存在许多孔径不均匀、密闭和贯通的孔状结构，表面存在釉和通向内部的孔道；不含有机物，Al3+、Ca2+、Fe3+等金属离子含量较高，高温煅烧使部分原料成分改变，形成新物相莫来石。持续振荡24 h后，CWTSFA平均磨损率仅1.49%，对磷酸盐静态吸附去除率最高达到94.92%，为化学吸附；当HRT=24 h时，CWTSFA动态吸附磷出水浓度稳定在0.03 mg·L-1左右，持续运行49 d后去除率由93.33%下降至81.82%，CWTSFA基折流曝气生态滤池运行19 d可自然挂膜，对总磷去除率稳定在92%以上。CWTSFA具有较强的抗水力冲刷能力及对磷酸盐的吸附效果，用作水处理填料能在较短时间内完成挂膜，且总磷出水水质良好，具有实际应用前景。
    Abstract: In order to recycle the excessive sludge from a water treatment plant, a ceramsite was prepared as packings for water treatment with the addition of fly ash and water glass. A short time multi stage high temperature calcination was used as the preparation method. The phosphorus removal performance of CWTSFA was evaluated in a baffled aeration ecological filter that fed with actual water. The phosphorus adsorption mechanism was revealed by isothermal adsorption. The results showed that the pores inside the CWTSFA were unevenly distributed, closed and interconnected. Glazes were found on the surface and interior channels of CWTSFA. The concentration of metal ions in CWTSFA (Al3+, Ca2+ and Fe3+) was high and new phase of mullite was identified after high temperature calcination. After continuous oscillation of 24 h, the average wear rate of CWTSFA was 1.49%, and the highest removal efficiency of phosphate was 94.92%. At an HRT of 24 h, the effluent concentration of CWTSFA dynamic adsorption was stable at 0.03 mg·L-1, and the removal rate decreased from 93.33% to 81.82% after 49 days of continuous operation. The biofilm was acclimated after 19 days in the CWTSFA base biologic aerated filter. The removal efficiency of total phosphorus was up to 92%. In addition, CWTSFA showed a strong resistance towards corrosion. The CWTSFA prepared from excessive sludge with the addition of fly ash and water glass exhibited a great potential as an effective packing for removing phosphorous in water treatment.
  • 加载中
  • [1] AHMAD T, AHMAD K, AHAD A, et al.Characterization of water treatment sludge and its reuse as coagulant[J].Journal of Environmental Management,2016,182:606-611 10.1016/j.jenvman.2016.08.010
    [2] YANG L, WEI J, ZHANG Y M, et al.Reuse of acid coagulant-recovered drinking waterworks sludge residual to remove phosphorus from wastewater[J].Applied Surface Science,2014,305(6):337-346 10.1016/j.apsusc.2014.03.081
    [3] LI Z F, JIANG N, WU F F, et al.Experimental investigation of phosphorus adsorption capacity of the waterworks sludges from five cities in China[J].Ecological Engineering,2013,53:165-172 10.1016/j.ecoleng.2012.12.038
    [4] 马宏林，贺涛，魏东洋，等. 响应面分析法优化给水污泥基质吸附除磷工艺[J]. 环境工程学报,2015,9(2):546-552
    [5] 马啸宙，魏东洋，马宏林，等. 基于给水污泥吸附水溶液中磷的影响因素[J]. 环境工程学报,2015,9(8):3659-3666
    [6] 韩云婷，王拯，方晓航，等. 改性给水污泥对高磷酸盐废水的吸附研究[J]. 环境工程学报,2011,5(4):772-776
    [7] 王信，马啸宙，周雯，等. 给水污泥负载Fe合物除磷行为效果及机理[J]. 环境工程学报,2016,10(10):5420-5428 10.12030/j.cjee.201602116
    [8] 王乐乐，杨鼎宜，刘亚东，等. 轻质污泥陶粒研制及其膨胀机理的探讨[J]. 混凝土,2013(4):40-43
    [9] 兰善红，杨丹，范洪波，等. 新型粉煤灰陶粒的制备及其处理印染废水的研究[J]. 环境科学与技术,2011,34(S1):35-37
    [10] 徐振华，刘建国，宋敏英，等. 污泥、底泥与粉煤灰烧结陶粒的工艺研究[J]. 安全与环境学报,2012,12(4):21-26
    [11] 贺君，王启山，任爱玲. 给水厂与污水厂污泥制陶粒技术研究[J]. 环境工程学报,2009,3(9):1653-1657
    [12] 齐元峰，岳钦艳，岳敏，等. 用于水处理填料的超轻污泥-粉煤灰陶粒的研制[J]. 功能材料,2010,41(6):1097-1101
    [13] 苏子艺，余江，王慈，等. 生活污泥制备轻质高比表面积陶粒的试验研究[J]. 深圳大学学报(理工版),2014,31(4):374-378
    [14] 郭玉顺，丁建彤. 粉煤灰陶粒烧胀规律与膨胀机理研究[J]. 粉煤灰,2003(3):15-18
    [15] 李琼辉. 基于人工湿地的新型陶粒基质制备及其固磷性能的研究[D].哈尔滨:哈尔滨工业大学,2014
    [16] 中华人民共和国国家质量监督检验检疫总局, 中国国家标准化管理委员会.轻集料及其试验方法 第1部分 轻集料:GB/T 17431.1-2010[S].北京: 中国环境科学出版社,2010
    [17] 郗斐，赵大传. 轻质/超轻粉煤灰陶粒的研制及陶粒膨胀机理的探讨和应用[J]. 功能材料,2010,41(S3):518-523
    [18] 朱翔，吴复忠，金会心. 添加剂对陶粒轻集料性能的影响[J]. 硅酸盐通报,2014,33(3):641-645
    [19] 曲烈，王渊，杨久俊，等. 焙烧温度对污泥陶粒烧胀过程及结构特征的影响[J]. 材料导报,2016,30(6):125-128
    [20] BAO T, CHEN T H, LIU H B, et al.Preparation of magnetic porous ceramsite and its application in biological aerated filters[J].Journal of Water Process Engineering,2014,4(12):185-195 10.1016/j.jwpe.2014.10.004
    [21] 孔德顺，宋说讲，王茜等. 基于碱融活化的高岭土水热法制备干燥剂NaP分子筛[J]. 硅酸盐通报,2017,36(11):3653-3658
    [22] 杨浪，贾菲菲，宋少先. 不同处理方法对白云母离子交换能的影响[J]. 金属矿山,2016(7):132-135
    [23] 欧阳东，易超. 利用高岭土下脚料制备纤维硅酸钙板的试验研究[J]. 硅酸盐通报,2013,32(10):1945-1948
    [24] 杨仪潇，刘张敏，邓湘云,等. 氟化铝添加量对碳化硅/莫来石复合多孔陶瓷性能的影响[J]. 硅酸盐通报,2015,34(8):2315-2319
    [25] 喻云峰，廖佳，吴改. “红碧石”的宝石矿物学特征[J]. 矿物学报,2017,37(6):801-806
    [26] 李亮. 粉煤灰陶粒制备试验研究[J]. 硅酸盐通报,2017,36(5):1577-1581
    [27] 刘景明，陈立颖，宋存义，等. 由化工脱水污泥烧制陶粒[J].北京科技大学学报,2008,30(10):1090-1094
    [28] 邱珊，黄旭，刘子述，等. 秸秆灰为添加剂的粉煤灰免烧陶粒的试制[J]. 哈尔滨工业大学学报,2013,45(2):36-40
    [29] POULSEN S L, JAKOBSEN H J, SKIBSTED J.Incorporation of phosphorus guest ions in the calcium silicate phases of portland cement from 31P MAS NMR spectroscopy[J].Inorganic Chemistry,2010,49(12):5522-5529 10.1021/ic100140j
    [30] CHENG G, LI Q, SU Z, et al.Preparation, optimization, and application of sustainable ceramsite substrate from coal fly ash/waterworks sludge/oyster shell for phosphorus immobilization in constructed wetlands[J].Journal of Cleaner Production,2018,175:572-581 10.1016/j.jclepro.2017.12.102
    [31] 国家环境保护总局, 国家质量监督检验检疫总局.地表水环境质量标准:GB 3838-2002[S].北京: 中国环境科学出版社,2002
    [32] ERICKSON A J, GULLIVER J S, WEISS P T.Capturing phosphates with iron enhanced sand filtration[J].Water Research,2012,46(3):3032-3042 10.1016/j.watres.2012.03.009
    [33] BROOKS A S, ROZENWALD M N, GEOHRING L D, et al.Phosphorus removal by wollastonite: A constructed wetland substrate[J].Ecological Engineering,2000,15(1):121-132 10.1016/S0925-8574(99)00056-7
    [34] 李倩炜，周笑绿，李环，等. 粉煤灰陶粒填料制备及用作曝气生物滤池填料的性能考察[J]. 化工进展,2015,34(9):3379-3382
  • 加载中
WeChat 点击查看大图
计量
  • 文章访问数:  3087
  • HTML全文浏览数:  2920
  • PDF下载数:  155
  • 施引文献:  0
出版历程
  • 刊出日期:  2018-10-11

新型给水污泥-粉煤灰陶粒性能与除磷效果

  • 1. 兰州理工大学石油化工学院，兰州 730050
  • 2. 环境保护部华南环境科学研究所，广州 510535
  • 3. 正业设计股份有限公司，哈尔滨 150090
基金项目:

广州市科技计划科学研究专项（201607010259）

广东省自然科学基金资助项目（2016A030313021）

中央级公益性科研院所基本科研业务专项（PM-ZX021-201510-002）

摘要: 为资源化利用自来水厂剩余污泥，以给水污泥、粉煤灰、水玻璃制备新型给水污泥-粉煤灰陶粒（ceramsite made by water treatment sludge and fly ash，CWTSFA），用作污水处理填料。采用短时多段高温煅烧法烧制新型给水污泥陶粒，通过等温吸附实验探讨其吸附磷机理，通过动态吸附实验及CWTSFA基质折流曝气生态滤池除磷效果探究其在实际水处理中的应用前景。实验结果表明：CWTSFA内部存在许多孔径不均匀、密闭和贯通的孔状结构，表面存在釉和通向内部的孔道；不含有机物，Al3+、Ca2+、Fe3+等金属离子含量较高，高温煅烧使部分原料成分改变，形成新物相莫来石。持续振荡24 h后，CWTSFA平均磨损率仅1.49%，对磷酸盐静态吸附去除率最高达到94.92%，为化学吸附；当HRT=24 h时，CWTSFA动态吸附磷出水浓度稳定在0.03 mg·L-1左右，持续运行49 d后去除率由93.33%下降至81.82%，CWTSFA基折流曝气生态滤池运行19 d可自然挂膜，对总磷去除率稳定在92%以上。CWTSFA具有较强的抗水力冲刷能力及对磷酸盐的吸附效果，用作水处理填料能在较短时间内完成挂膜，且总磷出水水质良好，具有实际应用前景。

English Abstract

参考文献 (34)

目录

/

返回文章
返回

Copyright © 2019 中国科学院生态环境研究中心