超声破解对剩余污泥内含营养物及粒径的影响

江云; 朱曙光; 欧阳匡中; 左明明; 姜宇; 管冰镜; 翟苏皖; 王志伟; 丁晨风

doi:10.12030/j.cjee.201709034

环境工程学报

超声破解对剩余污泥内含营养物及粒径的影响

, , , , , , , ,

江云, 朱曙光, 欧阳匡中, 左明明, 姜宇, 管冰镜, 翟苏皖, 王志伟, 丁晨风. 超声破解对剩余污泥内含营养物及粒径的影响[J]. 环境工程学报, 2018, 12(5): 1303-1309. doi: 10.12030/j.cjee.201709034

引用本文:

JIANG Yun, ZHU Shuguang, OUYANG Kuangzhong, ZUO Mingming, JIANG Yu, GUAN Bingjing, ZHAI Suwan, WANG Zhiwei, DING Chenfeng. Effect of ultrasonic cracking on nutrients and particle size of excess sludge[J]. Chinese Journal of Environmental Engineering, 2018, 12(5): 1303-1309. doi: 10.12030/j.cjee.201709034

Citation:

JIANG Yun, ZHU Shuguang, OUYANG Kuangzhong, ZUO Mingming, JIANG Yu, GUAN Bingjing, ZHAI Suwan, WANG Zhiwei, DING Chenfeng. Effect of ultrasonic cracking on nutrients and particle size of excess sludge[J]. Chinese Journal of Environmental Engineering, 2018, 12(5): 1303-1309. doi: 10.12030/j.cjee.201709034

超声破解对剩余污泥内含营养物及粒径的影响

1.
安徽建筑大学环境与能源工程学院，合肥 230601
2.
安徽省绿色建筑先进技术研究院，合肥 230601
基金项目:
安徽省科技重大专项 (16030801118)

安徽省高校自然科学研究重大项目 (KJ2016SD14，KJ2017ZD40)

天津市水质科学与技术重点实验室开放基金资助项目 (TJKLAST-ZD-2014-03)

Effect of ultrasonic cracking on nutrients and particle size of excess sludge

1.
College of Environment and Energy Engineering, Anhui Jianzhu University, Hefei 230601, China
2.
Anhui Advanced Technology Research Institute of Green Building, Hefei 230601, China
Fund Project:

摘要: 利用超声技术破解剩余污泥，不仅能有效降低污泥含水率，提高污泥稳定性，还能在上清液中释放C、N和P等有机物，为污泥资源化利用提供条件。通过考察超声时间、功率及频率等因素，分析超声空化对污泥稳定化程度和污泥内含营养物质释放的影响规律，形成超声破解污泥的最优实验方案。综合考虑超声效果与节能，选择超声频率22 kHz，超声功率800 W，超声时间15 min为优化的工艺条件，其上清液中的COD浓度高达954.33 mg·L-1，总氮含量为153.16 mg·L-1，总磷含量为72.65 mg·L-1，污泥颗粒粒径显著减小，d50从原泥的34.82 μm减小至2.99 μm，并形成少量纳米级颗粒，探讨了纳米颗粒对污泥活性的影响，有利于后续污泥稳定化和减量化。
- 超声波技术 /
- 污泥颗粒 /
- 超声时间 /
- 超声功率 /
- 超声频率
Abstract: Ultrasonic cracking excess sludge can not only decrease the water content in sludge and improve its stability, but also can release some organic species such as C, N and P from the sludge, which is beneficial for resource recycling and utilization. By examining the time, power and frequency of ultrasonic treatment, the effects of ultrasonic cavitation on the sludge stability and the nutrients releasing were systematically analyzed, which achieved the optimized experimental program for ultrasonic cracking excess sludge. Comprehensively considering the ultrasonic effect and energy–saving, the ultrasonic time of 15 min and power of 800 W with the frequency of 22 kHz were selected as the proper experimental parameters. In this condition, the concentrations of SCOD, total nitrogen and total phosphorus in the supernatant raised up to 954.33 mg·L-1, 153.16 mg·L-1 and 72.65 mg·L-1, respectively. Furthermore, the particle size of sludge was significantly reduced. For example, the particle size of d50 in the initial sludge was reduced from 34.82 μm to 2.99 μm. In addition, a small amount of nanoparticles were also produced. The effect of nanoparticles on sludge activity was briefly discussed, which was proposed to be conducive to the stabilization and reduction of subsequent sludge.
- ultrasonic technology /
- sludge particulates /
- ultrasonic time /
- ultrasonic power /
- ultrasonic frequency

[1]	SUN L.Application of biological contact oxidation process of sewage treatment in a hospital study[J].Applied Mechanics & Materials,2015,727-728:123-125 10.4028/www.scientific.net/AMM.727-728.123
[2]	VINCENT J, FORQUET N, MOLLE P, et al.Mechanical and hydraulic properties of sludge deposit on sludge drying reed beds (SDRBs): Influence of sludge characteristics and loading rates[J].Bioresource Technology,2012,116(4):161-169 10.1016/j.biortech.2012.04.023
[3]	戴晓虎，戴翎翎，段妮娜. 科技创新为我国污泥绿色化低碳发展提供对策[J]. 建设科技,2017(1):48-50 10.16116/j.cnki.jskj.2017.01.010
[4]	王晓霞. 剩余污泥减量化处理中细胞物质的释放特性与磷回收研究[D]. 上海：华东理工大学,2010
[5]	高丽英，汤兵. 解偶联代谢污泥减量机理及其新工艺[J]. 工业用水与废水,2012,43(1):6-10
[6]	曹秀芹，刘雷，甘一萍，等. 溶胞技术在污泥处理中的研究与进展[C]//《中国城镇水务发展国际研讨会论文集》编委会.第六届亚太地区基础设施发展部长级论坛暨第二届中国城镇水务发展国际研讨会论文集.北京：中国城市出版社，2007:458-466
[7]	唐少楠，邓风，何超群，等. 超声波在水处理中的应用研究[J]. 西南给排水,2010,32(2):29-33
[8]	?AHINKAYA S，SEVIMLI M F.Sono-thermal pre-treatment of waste activated sludge before anaerobic digestion[J].Ultrasonics Sonochemistry,2013,20(1):587-594 10.1016/j.ultsonch.2012.07.006
[9]	陈金. 超声波促进城市污泥水解效果研究[D]. 成都：西南交通大学, 2011
[10]	BRAR S K，VERMA M，TYAGI R D，et al． Engineered nanoparticles in wastewater and wastewater sludge evidence and impacts[J]． Waste Management,2010,30(3):504-520 10.1016/j.wasman.2009.10.012
[11]	王芬. 剩余污泥超声破解的性能与机理研究[D]. 天津：天津大学, 2004
[12]	喻艳菁，丁国际，邱慧琴，等. 超声处理对剩余污泥的粒径和溶出物的影响[J]. 环境科学学报,2009,29(4):703-708 10.3321/j.issn:0253-2468.2009.04.005
[13]	陈路全. 加碱和超声破解预处理对剩余污泥厌氧消化的影响[D]. 天津：天津大学, 2008
[14]	王拓，严冰，赵乐军. 超声波破解污泥对厌氧水解过程中有机物水解的影响[J]. 工业用水与废水,2014,45(2):88-91 10.3969/j.issn.1009-2455.2014.02.025
[15]	徐慧敏, 何国富, 戴晓虎,等. 超声联合碱解预处理对剩余污泥破解和厌氧消化的影响[J]. 环境工程学报,2017,11(5):3073-3078 10.12030/j.cjee.201601202
[16]	李圣增，李进科，秦华. 水中COD测量不确定度的评定[J]. 中国计量,2008,31(1):144-146
[17]	杨继贤，张传义. 膜生物反应器脱氮除磷新技术[M].徐州：中国矿业大学出版社, 2009
[18]	王怡，刘潘，彭党聪. 超声及碱处理促进剩余污泥水解的试验研究[J]. 中国给水排水,2010,26(15):28-31
[19]	吕娟. 纳米颗粒在污水处理和剩余污泥处置中的迁移[J]. 水资源与水工程学报,2012,23(6):163-167
[20]	CHOI O，DENG K K，KIM N J，et al． The inhibitory effects of silver nanoparticles，silver ions，and silver chloride colloids on microbial growth[J].Water Research,2008,42(12):3066-3074 10.1016/j.watres.2008.02.021
[21]	由美雁.超声破解剩余污泥的研究及剩余污泥破解三阶段论[C]//中国环境科学学会.中国环境科学学会学术年会论文集:第3卷. 北京：中国环境科学学会，2016:3301-3307
[22]	金宜英, 李欢, 王志玉,等. 利用有机污泥生产液态有机肥的方法: CN101037354 .A[P]. 2007-09-19
[23]	朱曙光, 陶张晶, 秦莹,等. 一种采用剩余污泥制备的蛋白质及其制备方法和应用: CN105777859.A[P]. 2016-07-20

点击查看大图

计量

文章访问数: 2822
HTML全文浏览数: 2399
PDF下载数: 363
施引文献: 0

超声破解对剩余污泥内含营养物及粒径的影响

1. 安徽建筑大学环境与能源工程学院，合肥 230601
2. 安徽省绿色建筑先进技术研究院，合肥 230601

基金项目:

安徽省科技重大专项 (16030801118)

安徽省高校自然科学研究重大项目 (KJ2016SD14，KJ2017ZD40)

天津市水质科学与技术重点实验室开放基金资助项目 (TJKLAST-ZD-2014-03)

关键词:

摘要: 利用超声技术破解剩余污泥，不仅能有效降低污泥含水率，提高污泥稳定性，还能在上清液中释放C、N和P等有机物，为污泥资源化利用提供条件。通过考察超声时间、功率及频率等因素，分析超声空化对污泥稳定化程度和污泥内含营养物质释放的影响规律，形成超声破解污泥的最优实验方案。综合考虑超声效果与节能，选择超声频率22 kHz，超声功率800 W，超声时间15 min为优化的工艺条件，其上清液中的COD浓度高达954.33 mg·L-1，总氮含量为153.16 mg·L-1，总磷含量为72.65 mg·L-1，污泥颗粒粒径显著减小，d50从原泥的34.82 μm减小至2.99 μm，并形成少量纳米级颗粒，探讨了纳米颗粒对污泥活性的影响，有利于后续污泥稳定化和减量化。

English Abstract

Effect of ultrasonic cracking on nutrients and particle size of excess sludge

1. College of Environment and Energy Engineering, Anhui Jianzhu University, Hefei 230601, China
2. Anhui Advanced Technology Research Institute of Green Building, Hefei 230601, China

Fund Project:

Keywords:

Abstract: Ultrasonic cracking excess sludge can not only decrease the water content in sludge and improve its stability, but also can release some organic species such as C, N and P from the sludge, which is beneficial for resource recycling and utilization. By examining the time, power and frequency of ultrasonic treatment, the effects of ultrasonic cavitation on the sludge stability and the nutrients releasing were systematically analyzed, which achieved the optimized experimental program for ultrasonic cracking excess sludge. Comprehensively considering the ultrasonic effect and energy–saving, the ultrasonic time of 15 min and power of 800 W with the frequency of 22 kHz were selected as the proper experimental parameters. In this condition, the concentrations of SCOD, total nitrogen and total phosphorus in the supernatant raised up to 954.33 mg·L-1, 153.16 mg·L-1 and 72.65 mg·L-1, respectively. Furthermore, the particle size of sludge was significantly reduced. For example, the particle size of d50 in the initial sludge was reduced from 34.82 μm to 2.99 μm. In addition, a small amount of nanoparticles were also produced. The effect of nanoparticles on sludge activity was briefly discussed, which was proposed to be conducive to the stabilization and reduction of subsequent sludge.

全文HTML

参考文献 (23)

下载: 全尺寸图片幻灯片

返回文章

用微信扫码二维码

分享至好友和朋友圈

超声破解对剩余污泥内含营养物及粒径的影响

Effect of ultrasonic cracking on nutrients and particle size of excess sludge

计量

出版历程

超声破解对剩余污泥内含营养物及粒径的影响

English Abstract

Effect of ultrasonic cracking on nutrients and particle size of excess sludge

全文HTML

目录