高级搜索

CeO2-CuO/粉煤灰吸附SO2/NO性能分析

,  , 

downloadPDF

上一篇

下一篇

刘恒恒, 赵玲, 康琦. CeO2-CuO/粉煤灰吸附SO2/NO性能分析[J]. 环境工程学报, 2018, 12(10): 2807-2817. doi: 10.12030/j.cjee.201805042
引用本文: 刘恒恒, 赵玲, 康琦. CeO2-CuO/粉煤灰吸附SO2/NO性能分析[J]. 环境工程学报, 2018, 12(10): 2807-2817. doi: 10.12030/j.cjee.201805042
shu
LIU Hengheng, ZHAO Ling, KANG Qi. Performance analysis of CeO2-CuO/fly ash for adsorption of SO2/NO[J]. Chinese Journal of Environmental Engineering, 2018, 12(10): 2807-2817. doi: 10.12030/j.cjee.201805042
Citation: LIU Hengheng, ZHAO Ling, KANG Qi. Performance analysis of CeO2-CuO/fly ash for adsorption of SO2/NO[J]. Chinese Journal of Environmental Engineering, 2018, 12(10): 2807-2817. doi: 10.12030/j.cjee.201805042
shu

CeO2-CuO/粉煤灰吸附SO2/NO性能分析

  • 1.

    内蒙古大学生态与环境学院，呼和浩特 010021

  • 基金项目:

    国家自然科学基金资助项目（21567018，21347001）

    内蒙古自然科学基金资助项目（2017MS0214，2013MS0203）

Performance analysis of CeO2-CuO/fly ash for adsorption of SO2/NO

  • 1.

    School of Ecology and Environment, Inner Mongolia University, Hohhot 010021, China

  • Fund Project:

  • 摘要: 利用室温液相浸渍法将粉煤灰制备成CeO2-CuO/粉煤灰，提高了粉煤灰对SO2/NO的吸附效率。采用XRF、XRD、SEM等手段对其进行表征测试，结果表明，粉煤灰的晶相结构主要为石英和莫来石，且改性后表面变得更为粗糙，孔隙增多。利用吸附反应装置优化SO2/NO的反应条件，结果表明：在样品量为0.3 g、温度为50 ℃、SO2流速为8 mL·min-1、O2流速为4?mL·min-1时，CeO2-CuO/粉煤灰对SO2吸附效果最佳；在样品量为0.4?g、温度为70?℃、NO流速为6?mL·min-1、O2流速为4?mL·min-1时，对NO吸附效果最佳。共吸附会降低各自的吸附效率。利用原位FTIR分析表明：SO2在CeO2-CuO/粉煤灰表面主要生成硫酸盐和亚硫酸盐物种；NO则主要生成硝酸盐和亚硝酸盐物种。
    Abstract: CeO2-CuO/fly ash prepared by liquid phase impregnation at room temperature improved its adsorption efficiency for SO2/NO. The samples were characterized by X-ray fluorescence (XRF), X-ray diffraction (XRD), scanning electron microscopy (SEM), the results represented that fly ash’s crystal structure mainly consisted of quartz and mullite, and the surface of fly ash became coarser with more pores after modification. Adsorption-reactive device was used to optimize the reactive conditions of SO2/NO. The results showed that the CeO2-CuO/fly ash adsorbent has the best adsorption effect on SO2 when the sample weight is 0.3?g, the temperature is 50?℃, the flow rate of SO2 is 8?mL·min-1, and flow rate of O2 is 4?mL·min-1. When the sample weight is 0.4?g, the temperature is 70?℃, the flow rate of NO is 6?mL·min-1, and the flow rate of O2 is 4?mL·min-1, the adsorption effect of NO is best. Co-adsorption decreases the respective adsorption efficiency. In situ FTIR spectroscopy results showed the main species are sulfate and sulfite for SO2 adorption, and nitrate and nitrite for NO adsorption.
  • 加载中
  • [1] MATHIEU Y, TZANIS L, SOULARD M, et al.Adsorption of SOx by oxide materials: A review[J].Fuel Processing Technology,2013,114:81-100 10.1016/j.fuproc.2013.03.019
    [2] WANG J, LEI Y, YANG J, et al.China’s air pollution control calls for sustainable strategy for the use of coal[J].Environmental Science and Technology,2012,46(8):4263-4264 10.1021/es301226n
    [3] Karjalainen P, Ro?kko T, Pirjola L, et al.Sulfur driven nucleation mode formation in diesel exhaust under transient driving conditions[J].Environmental Science and Technology,2014,48(4):2336-2343 10.1021/es405009g
    [4] CHANG Y H.China needs a tighter PM2.5 limit and a change in priorities[J].Environmental Science and Technology,2012,46(13):7069-7070 10.1021/es3022705
    [5] 吴元锋, 仪桂云, 刘全润, 等. 粉煤灰综合利用现状[J]. 洁净煤技术,2013,19(6):100-104
    [6] 施云芬, 魏冬雪. 改性粉煤灰陶粒的制备及其吸附SO2性能研究[J]. 硅酸盐通报,2012,31(3):567-570
    [7] 陆靓燕, 陈延林, 鲍秀婷, 等. 粉煤灰对二氧化硫吸附性能的研究[J]. 粉煤灰综合利用,2007(1):16-18
    [8] RUBEL A, ANDREWS R, GONZALEZ R, et al.Adsorption of Hg and NOx on coal by-products[J].Fuel,2005,84(7/8):911-916 10.1016/j.fuel.2005.01.006
    [9] 贾小彬. 粉煤灰-凹凸棒石负载锰氧化物催化剂低温SCR脱硝性能研究[D]. 合肥: 合肥工业大学, 2013 合肥
    [10] 崔同明, 李水娥, 李慧赢, 等. 粉煤灰的改性及从模拟烟气中吸附脱除SO2试验研究[J].湿法冶金,2017,36(3):234-237
    [11] 靳朋勃. 粉煤灰沸石化及其处理废水的试验研究[D]. 镇江: 江苏大学, 2007
    [12] 欧阳小平. 粉煤灰制备沸石负载CuO/CeO2催化氧化燃料废水研究[D]. 南昌: 南昌大学,2011
    [13] 丁磊.CeO2/Fe2O3/粉煤灰复合吸附剂的制备及其对模拟直接染料废水的吸附特征[D].呼和浩特: 内蒙古师范大学,2015
    [14] 刘云颗. 粉煤灰提取氧化铝研究现状[J]. 无机盐工业,2007,39(10):16-18
    [15] 李利敏. 粉煤灰的改性及其对聚丙烯阻燃和力学性能的影响[D]. 北京: 北京化工大学,2017
    [16] 齐一谨, 徐中慧, 徐亚红, 等. 粉煤灰固化处理生活垃圾焚烧飞灰效果研究[J]. 环境科学与技术,2017,40(6):98-103
    [17] 柯昌君, 江盼, 吴维舟. 粉煤灰蒸压活性的红外光谱研究[J]. 武汉理工大学学报,2009,3(7):36-39
    [18] DUNG N T, CHANG T P, CHEN C T.Hydration process and compressive strength of slag-CFBC fly ash materials without portland cement[J].Journal of Materials in Civil Engineering,2015,27(7):1-9 10.1061/(ASCE)MT.1943-5533.0001177
    [19] 梅笛.MnOx/粉煤灰催化剂的制备与研究[D]. 武汉: 武汉理工大学,2015
    [20] Heterogeneous uptake of sulfur dioxide on aluminum and magnesium oxide particles[J].Journal of Physical Chemistry B,2001,105(25):6109-6120 10.1021/jp004423z
    [21] JOHN M H L, THOMAS Z, PETER D C.SO2 Adsorption and transformations on γ-Al2O3 surfaces: A density functional theory study[J].Journal of Physical Chemistry C,2010,114(23):10444-10454 10.1021/jp910895g
    [22] LEE Y W, PARK J W, CHOUNG J H, et al.Adsorption characteristics of SO2 on activated carbon prepared from coconut shell with potassium hydroxide activation[J].Environmental Science and Technology,2002,36(5):1086-1092 10.1021/es010916l
    [23] ZHANG Y X, MENG M, DAI F F, et al.States and function of potassium carbonate species in the polytitanate nanobelt supported catalysts used for efficient NOx storage and reduction[J].Journal of Physical Chemistry C,2013,117(45):23691-23700 10.1021/jp406950u
    [24] LIU F, ASAKURA K, HE H, et al.Influence of calcination temperature on iron titanate catalyst for the selective catalytic reduction of NOx with NH3[J].Catalysis Today,2011,164(1):520-527 10.1016/j.cattod.2010.10.008
    [25] 赵清森.CuO/γ-Al2O3及其改性催化剂脱硫脱硝性能研究[D]. 武汉: 华中科技大学, 2009
    [26] 刘逸锋, 沈本贤, 皮志鹏, 等.CeO2表面氧化转移FCC烟气中SO2的反应过程[J]. 化工学报,2016,67(12):5015-5023
    [27] 付名利, 林俊敏, 于润芃, 等.MnOx和CeO2 催化剂在含NO气氛中氧化模拟碳烟的研究[J]. 环境科学学报,2013,33(8):2134-2142
    [28] 袁德玲.CuNiTi类水滑石衍生物富氧丙烯选择性催化还原NO的研究[D]. 大连: 大连理工大学,2013
    [29] PICONE A L,
  • 加载中
WeChat 点击查看大图
计量
  • 文章访问数:  2897
  • HTML全文浏览数:  2750
  • PDF下载数:  143
  • 施引文献:  0
出版历程
  • 刊出日期:  2018-10-11
刘恒恒, 赵玲, 康琦. CeO2-CuO/粉煤灰吸附SO2/NO性能分析[J]. 环境工程学报, 2018, 12(10): 2807-2817. doi: 10.12030/j.cjee.201805042
引用本文: 刘恒恒, 赵玲, 康琦. CeO2-CuO/粉煤灰吸附SO2/NO性能分析[J]. 环境工程学报, 2018, 12(10): 2807-2817. doi: 10.12030/j.cjee.201805042
shu
LIU Hengheng, ZHAO Ling, KANG Qi. Performance analysis of CeO2-CuO/fly ash for adsorption of SO2/NO[J]. Chinese Journal of Environmental Engineering, 2018, 12(10): 2807-2817. doi: 10.12030/j.cjee.201805042
Citation: LIU Hengheng, ZHAO Ling, KANG Qi. Performance analysis of CeO2-CuO/fly ash for adsorption of SO2/NO[J]. Chinese Journal of Environmental Engineering, 2018, 12(10): 2807-2817. doi: 10.12030/j.cjee.201805042
shu

CeO2-CuO/粉煤灰吸附SO2/NO性能分析

  • 1. 内蒙古大学生态与环境学院，呼和浩特 010021
基金项目:

国家自然科学基金资助项目（21567018，21347001）

内蒙古自然科学基金资助项目（2017MS0214，2013MS0203）

摘要: 利用室温液相浸渍法将粉煤灰制备成CeO2-CuO/粉煤灰，提高了粉煤灰对SO2/NO的吸附效率。采用XRF、XRD、SEM等手段对其进行表征测试，结果表明，粉煤灰的晶相结构主要为石英和莫来石，且改性后表面变得更为粗糙，孔隙增多。利用吸附反应装置优化SO2/NO的反应条件，结果表明：在样品量为0.3 g、温度为50 ℃、SO2流速为8 mL·min-1、O2流速为4?mL·min-1时，CeO2-CuO/粉煤灰对SO2吸附效果最佳；在样品量为0.4?g、温度为70?℃、NO流速为6?mL·min-1、O2流速为4?mL·min-1时，对NO吸附效果最佳。共吸附会降低各自的吸附效率。利用原位FTIR分析表明：SO2在CeO2-CuO/粉煤灰表面主要生成硫酸盐和亚硫酸盐物种；NO则主要生成硝酸盐和亚硝酸盐物种。

English Abstract

参考文献 (29)

返回顶部

目录

/

返回文章
返回

Copyright © 2019 中国科学院生态环境研究中心