高级搜索

超重力强化H2O2-NaOH复合吸收液脱硝

,  ,  ,  ,  ,  , 

downloadPDF

上一篇

下一篇

段开娇, 吴博, 唐光阳, 贾丽娟, 彭金辉, 常玉, 刘天成. 超重力强化H2O2-NaOH复合吸收液脱硝[J]. 环境工程学报, 2018, 12(9): 2566-2571. doi: 10.12030/j.cjee.201805016
引用本文: 段开娇, 吴博, 唐光阳, 贾丽娟, 彭金辉, 常玉, 刘天成. 超重力强化H2O2-NaOH复合吸收液脱硝[J]. 环境工程学报, 2018, 12(9): 2566-2571. doi: 10.12030/j.cjee.201805016
shu
DUAN Kaijiao, WU Bo, TANG Guangyang, JIA Lijuan, PENG Jinhui, CHANG Yu, LIU Tiancheng. Denitration with H2O2-NaOH compound absorption liquid in rotating packed bed[J]. Chinese Journal of Environmental Engineering, 2018, 12(9): 2566-2571. doi: 10.12030/j.cjee.201805016
Citation: DUAN Kaijiao, WU Bo, TANG Guangyang, JIA Lijuan, PENG Jinhui, CHANG Yu, LIU Tiancheng. Denitration with H2O2-NaOH compound absorption liquid in rotating packed bed[J]. Chinese Journal of Environmental Engineering, 2018, 12(9): 2566-2571. doi: 10.12030/j.cjee.201805016
shu

超重力强化H2O2-NaOH复合吸收液脱硝

  • 1.

    云南民族大学化学与环境学院，昆明 650500

  • 2.

    非常规冶金教育部重点实验室，昆明 650093

  • 3.

    云南技师学院，昆明 650300

  • 基金项目:

    国家自然科学基金资助项目(51568068)

    云南省应用基础研究项目(2017FD119)

    云南省教育厅科学研究项目(2016ZZX127)

Denitration with H2O2-NaOH compound absorption liquid in rotating packed bed

  • 1.

    School of Chemistry and Environment, Yunnan Minzu University, Kunming 650500, China

  • 2.

    Key Laboratory of Unconventional Metallurgy, Ministry of Education, Kunming 650093, China

  • 3.

    Yunnan Technician College, Kunming 650300, China

  • Fund Project:

  • 摘要: 在旋转填充床中进行H2O2-NaOH复合吸收液脱硝的实验研究。考察了旋转填充床的转速、气液比、吸收液的浓度和组分以及循环时间等因素对脱硝率的影响，并检测了吸收产物。结果表明：脱硝率随旋转填充床的转速、吸收液的浓度和组分的提高而增大；随气液比、循环时间的增大而降低。最佳的反应参数为旋转床转速1 000 r·min-1，气液比10:1，复合吸收液浓度0.04 mol·L-1 NaOH和0.2 mol·L-1 H2O2，NOx的脱除率为92%。在循环使用510 min内，脱硝率保持在88%以上，吸收产物为含NO2-和NO3-离子的溶液。
    Abstract: Denitration with H2O2-NaOH compound absorption liquid in rotating packed bed (RPB) was investigated in this study. Rotating speed of RPB, gas-liquid ratio, concentration of H2O2 and NaOH, cycle time of compound absorption liquid, as well as relationship between cycle time and ion concentration were comprehensively studied respectively. The results showed that denitration efficiency increased with the increasing of rotating speed of RPB and concentration of compound absorption liquid, but it decreased with the increasing of gas-liquid ratio and cycle time of component absorption liquid. Denitration efficiency achieved 92% under the optimum conditions of 1 000 r·min-1 rotating speed, 10:1 gas liquid ratio and 0.04 mol·L-1 NaOH and 0.2 mol·L-1 H2O2. Moreover, denitration efficiency was still as high as 88% even the cycle time was up to 510 min and both NO2- and NO3- ions were detected in the absorption product.
  • 加载中
  • [1] 李建梅,李国栋. 中国水泥工业氮氧化物排放现状及对策建议[J]. 应用化工, 2013, 42(9): 1687-1689
    [2] 王访,贾丽娟,高冀芸,等. 泥磷液相催化氧化氮氧化物[J]. 化工环保, 2018, 38(1): 72-76
    [3] LI D X, SHI P H, WANG J B, et al.High-efficiency absorption of high NOx concentration in water or PEG using capillary pneumatic nebulizer packed with an expanded graphite filter[J].Chemical Engineering Journal, 2014, 237(1): 8-15 10.1016/j.cej.2013.09.069
    [4] ZHANG R, ZHANG J, YI L, et al.Removal of high concentration NOx by absorption with urea and adjustment of the oxidization degree[J].Petrochemical Technology, 2014, 43(7):827-831
    [5] XIAN C M, CHEN L, SU P C, et al.Scenario analysis of denitration for Chinese coal-fired power generation[J].Materials Science Forum, 2015, 814: 425-429
    [6] 张小曳,孙俊英,王亚强,等. 我国雾霾成因及其治理的思考[J]. 科学通报, 2013, 58(13): 1178-1187
    [7] DUAN K J, CHEN B H, LIU Z M, et al.Mn promoted Pd/TiO2-Al2O3 catalyst for the selective catalytic reduction of NOx by H2[J].Applied Catalysis B: Environmental, 2015, 176: 618-626 10.1016/j.apcatb.2015.04.048
    [8] WEJKOWSKI R, WOJNAR W.Selective catalytic reduction in a rotary air heater (RAH-SCR) [J].Journal of the Taiwan Institute of Chemical Engineers, 2018, 145: 367-373 10.1016/j.energy.2017.12.077
    [9] 乔南利,杨忆新,宋焕巧,等. 低温NH3-SCR脱硝催化剂的研究现状与进展[J]. 化工环保, 2017, 37(3):282-288
    [10] 刘有智. 化工过程强化方法与技术[M]. 北京: 化学工业出版社, 2017
    [11] QIAN Z, CHEN Q, GROSSMANN I E.Optimal synthesis of rotating packed bed reactor[J].Computers & Chemical Engineering, 2017, 105:152-160
    [12] LI Y W, CHU G W, SUN B C.Absorption of ammonia into water-in-oil microemulsion in a rotor-stator reactor[J].Chemical Engineering and Processing: Process Intensification, 2015, 87: 68-74 10.1016/j.cep.2014.11.011
    [13] LUO Y, CHU G W, CHEN J F, et al.Two stage blade-packing rotating packed bed for intensification of continuous distillation[J].Chinese Journal of Chemical Engineering, 2016, 24(1):109-115 10.1016/j.cjche.2015.06.015
    [14] 高文雷,曾泽泉,陈建铭,等. 旋转填充床中湿法脱硝的研究[J]. 高校化学工程学报, 2014, 28(5): 1160-1165
    [15] 谷德银,刘有智,祁贵生,等. 新型旋转填料床的气相传质特性[J]. 过程工程学报, 2015, 15(1):35-39
    [16] LI Y, LU Y Z, ZHANG L, et al.Absorption of NOx into nitric acid solution in rotating packed bed[J].Chinese Journal of Chemical Engineering, 2010,18(2): 44-248 10.1016/S1004-9541(08)60349-3
    [17] 刘有智,李鹏,李裕,等. 超重力法处理高浓度氮氧化物废气中试研究[J].化工进展, 2007, 26(7): 1058-1062
  • 加载中
WeChat 点击查看大图
计量
  • 文章访问数:  2573
  • HTML全文浏览数:  2405
  • PDF下载数:  174
  • 施引文献:  0
出版历程
  • 刊出日期:  2018-09-20

超重力强化H2O2-NaOH复合吸收液脱硝

  • 1. 云南民族大学化学与环境学院，昆明 650500
  • 2. 非常规冶金教育部重点实验室，昆明 650093
  • 3. 云南技师学院，昆明 650300
基金项目:

国家自然科学基金资助项目(51568068)

云南省应用基础研究项目(2017FD119)

云南省教育厅科学研究项目(2016ZZX127)

摘要: 在旋转填充床中进行H2O2-NaOH复合吸收液脱硝的实验研究。考察了旋转填充床的转速、气液比、吸收液的浓度和组分以及循环时间等因素对脱硝率的影响，并检测了吸收产物。结果表明：脱硝率随旋转填充床的转速、吸收液的浓度和组分的提高而增大；随气液比、循环时间的增大而降低。最佳的反应参数为旋转床转速1 000 r·min-1，气液比10:1，复合吸收液浓度0.04 mol·L-1 NaOH和0.2 mol·L-1 H2O2，NOx的脱除率为92%。在循环使用510 min内，脱硝率保持在88%以上，吸收产物为含NO2-和NO3-离子的溶液。

English Abstract

参考文献 (17)

目录

/

返回文章
返回

Copyright © 2019 中国科学院生态环境研究中心