高级搜索

投加方式和通风速率对脱水污泥堆肥效果的影响

,  ,  , 

downloadPDF

上一篇

下一篇

张凤, 任勇翔, 张海阳, 杨垒. 投加方式和通风速率对脱水污泥堆肥效果的影响[J]. 环境工程学报, 2018, 12(8): 2372-2378. doi: 10.12030/j.cjee.201803070
引用本文: 张凤, 任勇翔, 张海阳, 杨垒. 投加方式和通风速率对脱水污泥堆肥效果的影响[J]. 环境工程学报, 2018, 12(8): 2372-2378. doi: 10.12030/j.cjee.201803070
shu
ZHANG Feng, REN Yongxiang, ZHANG Haiyang, YANG Lei. Influence of feeding mode and aeration rate on dewatered sludge aerobic composting[J]. Chinese Journal of Environmental Engineering, 2018, 12(8): 2372-2378. doi: 10.12030/j.cjee.201803070
Citation: ZHANG Feng, REN Yongxiang, ZHANG Haiyang, YANG Lei. Influence of feeding mode and aeration rate on dewatered sludge aerobic composting[J]. Chinese Journal of Environmental Engineering, 2018, 12(8): 2372-2378. doi: 10.12030/j.cjee.201803070
shu

投加方式和通风速率对脱水污泥堆肥效果的影响

  • 1.

    西安建筑科技大学，陕西省环境工程重点实验室，西安 710055

  • 基金项目:

    陕西省科技统筹重点项目（2015KTZDSF01-06）

Influence of feeding mode and aeration rate on dewatered sludge aerobic composting

  • 1.

    Shaanxi Key Laboratory of Environmental Engineering, Xi’an University of Architecture and Technology, Xi’an 710055, China

  • Fund Project:

  • 摘要: 为了在降低能耗的前提下获得更高的污泥堆肥效率和提高堆肥产品质量，利用梨形筒式好氧堆肥反应器，设置2种物料投加方式和3种通风速率，研究堆肥过程中温度、含水率、总氮以及发芽指数（GI）的变化特性。结果表明，与间歇式堆肥相比，连续式堆肥可以显著提高堆体温度和堆体腐熟度，降低堆体含水率及缩短腐熟期，但氮素损失也显著增大（P-1的连续式堆肥，堆体维持高温时间最长，且最终温度稳定在较高温度47～48 ℃，堆末含水率最低，氮素损失处于三者的中间水平，腐熟期最短。综合分析，在通风速率为1.95 L·min-1的连续运行方式下，梨形筒式反应器用于污泥稳定高效堆肥是可行的。
    Abstract: In order to obtain higher efficiency and better quality of sludge compost under the condition of lower energy consumption，two feeding modes and three aeration rates were conducted in a pyriform rotating drum reactor．Characteristics of temperature，moisture content，total nitrogen and germination index (GI) during composting process were studied．The results indicated that continuous composting could significantly increase the compost temperature and the maturity of the compost，decrease the moisture content and reduce the maturity period compared with batch composting．However，the nitrogen loss was also markedly increased (P-1 had the longest time of high temperature，the lowest moisture content at the end of compost，the shortest maturity period and the final temperature was stable at a higher temperature of 47 to 48 ℃．Also，it’s nitrogen loss was in the middle level of the three aeration rates．Overall，under the continuous operation mode of 1.95 L·min-1 aeration rate，the pyriform rotating drum reactor was feasible for sludge stabilization and high efficiency composting．
  • 加载中
  • [1] AGGELIDES S M，LONDRA P A．Effects of compost produced from town wastes and sewage sludge on the physical properties of a loamy and a clay soil[J]．Bioresource Technology,2000,71(3):253-259 10.1016/S0960-8524(99)00074-7
    [2] DOUBLET J，FRANCOU C，POITRENAUD M，et al．Sewage sludge composting: influence of initial mixtures on organic matter evolution and N availability in the final composts[J]．Waste Management,2010,30(10):1922-1930 10.1016/j.wasman.2010.04.032
    [3] 陈威，任勇翔，王晓昌，等．接种微生物与人粪便同步连续投加对好氧堆肥效果的影响[J]．环境工程学报,2014,8(2):677-682
    [4] 赵秀玲，朱新萍，罗艳丽，等．温度与秸秆比例对牛粪好氧堆肥的影响[J]．环境工程学报,2014,8(1):334-340
    [5] WU S H，SHEN Z Q，YANG C P，et al．Effects of C/N ratio and bulking agent on speciation of Zn and Cu and enzymatic activity during pig manure composting[J]．International Biodeterioration & Biodegradation,2017,119:429-436 10.1016/j.ibiod.2016.09.016
    [6] 张红玉，王桂琴，顾军，等．通风方式对厨余垃圾堆肥H2S和NH3排放的影响[J]．中国农业大学学报,2017,22(12):124-130
    [7] YUAN J，CHADWICK D，ZHANG D，et al．Effects of aeration rate on maturity and gaseous emissions during sewage sludge composting[J]．Waste Management,2016,56:403-410 10.1016/j.wasman.2016.07.017
    [8] 国家环境保护总局．水和废水监测分析方法[M]．4版．北京：中国环境科学出版社,2002:255-257
    [9] 李季，彭生平．堆肥工程实用手册[M]．2版．北京：化学工业出版社,2011:160-161
    [10] HASSEN A，BELGUITH K，JEDIDI N，et al．Microbial characterization during composting of municipal solid waste[J]．Bioresource Technology,2001,80(3):217-225 10.1016/S0960-8524(01)00065-7
    [11] FINSTEIN M S，MILLER F C，HOGAN J A，et al．Analysis of EPA guidance on composting sludge.Part II: Biological process control[J]．Biocycle,1987,28(3):38-40
    [12] 魏自民．生活垃圾微生物强化堆肥技术[M]．北京：中国环境科学出版社，2008:14
    [13] DIAZ L F，BERTOLDI M，BIDLINGMAIER W，et al．堆肥科学与技术[M]．鞠美庭，刘金鹏，赵晶晶，等译．北京：化学工业出版社,2013：36-37
    [14] VILLASE?OR J，RODRíGUEZ L，FERNáNDEZ F J．Composting domestic sewage sludge with natural zeolites in a rotary drum reactor[J]．Bioresource Technology,2011,102(2):1447-1454 10.1016/j.biortech.2010.09.085
    [15] LI R H，WANG Q，ZHANG Z Q，et al．Nutrient transformation during aerobic composting of pig manure with biochar prepared at different temperatures[J]．Environmental Technology,2015,36(7):815-826 10.1080/09593330.2014.963692
    [16] PAGANS E，BARRENA R，FONT X，et al．Ammonia emissions from the composting of different organic wastes.Dependency on process temperature[J]．Chemosphere,2006,62(9):1534-1542 10.1016/j.chemosphere.2005.06.044
    [17] MEUNCHANG S，PANICHSAKPATANA S，WEAVER R W．Co-composting of filter cake and bagasse; by-products from a sugar mill[J]．Bioresource Technology,2005,96(4):437-442 10.1016/j.biortech.2004.05.024
    [18] 黄国锋，钟流举，张振钿，等．有机固体废弃物堆肥的物质变化及腐熟度评价[J]．应用生态学报,2003,14(5):813-818
    [19] MOREIRA R，SOUSA J P，CANHOTO C．Biological testing of a digested sewage sludge and derived composts[J]．Bioresource Technology,2008,99(17):8382-8389 10.1016/j.biortech.2008.02.046
    [20] WONG M H．Phytotoxicity of refuse compost during the process of maturation[J]．Environmental Pollution,1985,37(2):159-174 10.1016/0143-1471(85)90006-6
    [21] MAGALH?ES A M T，SHEA P J，JAWSON M D，et al．Practical simulation of composting in the laboratory[J]．Waste Management & Research,1993,11(11):143–154 10.1006/wmre.1993.1015
    [22] 杨延梅．通风量对厨余堆肥氮素转化及氮素损失的影响[J]．环境科学与技术,2010,33(12):1-4
  • 加载中
WeChat 点击查看大图
计量
  • 文章访问数:  1973
  • HTML全文浏览数:  1795
  • PDF下载数:  148
  • 施引文献:  0
出版历程
  • 刊出日期:  2018-08-17

投加方式和通风速率对脱水污泥堆肥效果的影响

  • 1. 西安建筑科技大学，陕西省环境工程重点实验室，西安 710055
基金项目:

陕西省科技统筹重点项目（2015KTZDSF01-06）

摘要: 为了在降低能耗的前提下获得更高的污泥堆肥效率和提高堆肥产品质量，利用梨形筒式好氧堆肥反应器，设置2种物料投加方式和3种通风速率，研究堆肥过程中温度、含水率、总氮以及发芽指数（GI）的变化特性。结果表明，与间歇式堆肥相比，连续式堆肥可以显著提高堆体温度和堆体腐熟度，降低堆体含水率及缩短腐熟期，但氮素损失也显著增大（P-1的连续式堆肥，堆体维持高温时间最长，且最终温度稳定在较高温度47～48 ℃，堆末含水率最低，氮素损失处于三者的中间水平，腐熟期最短。综合分析，在通风速率为1.95 L·min-1的连续运行方式下，梨形筒式反应器用于污泥稳定高效堆肥是可行的。

English Abstract

参考文献 (22)

目录

/

返回文章
返回

Copyright © 2019 中国科学院生态环境研究中心