高级搜索

零价铁耦合芬顿氧化法处理TNT红水

,  , 

downloadPDF

上一篇

下一篇

王如凡, 徐文杰, 叶正芳. 零价铁耦合芬顿氧化法处理TNT红水[J]. 环境工程学报, 2018, 12(8): 2153-2160. doi: 10.12030/j.cjee.201801059
引用本文: 王如凡, 徐文杰, 叶正芳. 零价铁耦合芬顿氧化法处理TNT红水[J]. 环境工程学报, 2018, 12(8): 2153-2160. doi: 10.12030/j.cjee.201801059
shu
WANG Rufan, XU Wenjie, YE Zhengfang. Treatment of TNT red water by Fenton oxidation coupled with zero valent iron[J]. Chinese Journal of Environmental Engineering, 2018, 12(8): 2153-2160. doi: 10.12030/j.cjee.201801059
Citation: WANG Rufan, XU Wenjie, YE Zhengfang. Treatment of TNT red water by Fenton oxidation coupled with zero valent iron[J]. Chinese Journal of Environmental Engineering, 2018, 12(8): 2153-2160. doi: 10.12030/j.cjee.201801059
shu

零价铁耦合芬顿氧化法处理TNT红水

  • 1.

    北京大学，北京市新型污水深度处理工程技术研究中心，北京100871

  • 基金项目:

    北京市科技计划项目（Z151100000915065）

Treatment of TNT red water by Fenton oxidation coupled with zero valent iron

  • 1.

    Beijing Engineering Research Center for Advanced Wastewater Treatment, Peking University, Beijing 100871, China

  • Fund Project:

  • 摘要: 采用零价铁耦合芬顿氧化法处理TNT红水，研究了初始pH、零价铁投加量、过氧化氢（H2O2）投加量及温度对红水中总有机碳（TOC）去除效果的影响，同时进行了TOC去除过程中反应动力学的探讨。结果表明，零价铁耦合芬顿氧化体系可有效降解TNT红水中的2,4-二硝基甲苯-3-磺酸钠和2,4-二硝基甲苯-5-磺酸钠。在初始pH为2，温度为20 ℃的条件下，加入1.5 g·L-1零价铁反应1 h后，再加入100 mL·L-1H2O2反应4 h，红水中二硝基甲苯磺酸盐浓度从500 mg·L-1降至0 mg·L-1，去除率为100%，TOC浓度从150 mg·L-1降至30 mg·L-1，去除率达到80%。反应中TOC的降解过程遵循拟二级反应动力学方程。零价铁耦合芬顿氧化法可以作为TNT红水的有效处理途径。
    Abstract: The TNT red water was treated by Fenton oxidation coupled with zero valent iron reduction in current experiment. The effects of initial pH, zero valent iron dosage, H2O2 dosage and temperature on TOC removal were examined, and the reaction kinetics were discussed. Results showed that the 2,4-DNT-3-SO3Na and 2,4-DNT-5-SO3Na in TNT red water could be effectively degraded by Fenton oxidation coupled with zero valent iron. The nitro aromatic pollutants were completely removed from TNT red water under the conditions of initial pH 2, reaction temperature 20 ℃, after 1.5 g·L-1 zero valent iron was first added for 1 h reaction, and then 100 mL·L-1 H2O2 was added for 4 h reaction, concentration of dinitrotoluene sulfonate decreased from 500 to 0 mg·L-1,with a removal efficiency of 100%, TOC decreased from 150 to 30 mg·L-1, with a removal efficiency of 80%. The TOC removal process agreed with pseudo second-order kinetic model. In conclusion, Fenton oxidation coupled with zero valent iron reduction could be an effective strategy in the treatment of TNT red water.
  • 加载中
  • [1] ZHU S N, LIU G H, YE Z, et al.Reduction of dinitrotoluene sulfonates in TNT red water using nanoscale zerovalent iron particles[J].Environmental Science & Pollution Research International,2012,19(6):2372-2380 10.1007/s11356-012-0749-8
    [2] BARRETORODRIGUES M, SILVA F T, PAIVA T C.Characterization of wastewater from the Brazilian TNT industry[J].Journal of Hazardous Materials,2009,164(1):385-388 10.1016/j.jhazmat.2008.07.152
    [3] 赵泉林,叶正芳,王中友,等.TNT废水处理研究进展[J]. 环境化学,2010,29(5):796-801
    [4] ZHANG M, LIU G H, SONG K, et al.Biological treatment of 2,4,6-trinitrotoluene (TNT) red water by immobilized anaerobic–aerobic microbial filters[J].Chemical Engineering Journal,2015,259:876-884 10.1016/j.cej.2014.08.041
    [5] ZHANG M, ZHAO Q, YE Z.Organic pollutants removal from 2,4,6-trinitrotoluene (TNT) red water using low cost activated coke[J].Journal of Environmental Sciences,2011,23(12):1962-1969 10.1016/S1001-0742(10)60619-5
    [6] ZHAO Q, YE Z, ZHANG M.Treatment of 2,4,6-trinitrotoluene (TNT) red water by vacuum distillation[J].Chemosphere,2010,80(8):947-950 10.1016/j.chemosphere.2010.05.004
    [7] 常双君, 刘玉存. 超临界水氧化处理TNT炸药废水的研究[J]. 含能材料, 2007,15(3):285-288
    [8] ESTEVE-Nú?EZ A, CABALLERO A, RAMOS J L.Biological degradation of 2,4,6-trinitrotoluene[J].Microbiology and Molecular Biology Reviews,2001,65(3):335-352 10.1128/MMBR.65.3.335-352.2001
    [9] BARRETORODRIGUES M, SILVA F T, PAIVA T C B.Combined zero-valent iron and fenton processes for the treatment of Brazilian TNT industry wastewater[J].Journal of Hazardous Materials,2009,165(1):1224-1228 10.1016/j.jhazmat.2008.09.120
    [10] 张默贺,叶正芳,赵泉林,等. 铁碳微电解预处理TNT红水[J]. 环境工程学报,2012,6(9):3115-3120
    [11] XU W, ZHAO Q, JIANG Z, et al.Desorption of nitroaromatic compounds from explosive-contaminated soil by washing[J].Journal of Soil Contamination,2016,25(8):905-916 10.1080/15320383.2016.1224227
    [12] XIN Z, LIN Y M, SHAN X Q, et al.Degradation of 2,4,6-trinitrotoluene (TNT) from explosive wastewater using nanoscale zero-valent iron[J].Chemical Engineering Journal,2010,158(3):566-570 10.1016/j.cej.2010.01.054
    [13] YIN W, WU J, LI P, et al.Experimental study of zero-valent iron induced nitrobenzene reduction in groundwater: The effects of pH, iron dosage, oxygen and common dissolved anions[J].Chemical Engineering Journal,2012,184(3):198-204 10.1016/j.cej.2012.01.030
    [14] OH S Y, SEO Y D, RYU K S.Reductive removal of 2,4-dinitrotoluene and 2,4-dichlorophenol with zero-valent iron-included biochar[J].Bioresource Technology,2016,216:1014-1021 10.1016/j.biortech.2016.06.061
    [15] XU W, ZHAO Q, WANG R, et al.Optimization of organic pollutants removal from soil eluent by activated carbon derived from peanut shells using response surface methodology[J].Vacuum,2017,141:307-315 10.1016/j.vacuum.2017.04.031
    [16] YE Z, ZHAO Q, ZHANG M, et al.Acute toxicity evaluation of explosive wastewater by bacterial bioluminescence assays using a freshwater luminescent bacterium, Vibrio qinghaiensis sp.Nov[J].Journal of Hazardous Materials,2011,186(2/3):1351-1354 10.1016/j.jhazmat.2010.12.013
    [17] 国家环境保护总局. 水和废水监测分析方法[M].4版.北京：中国环境科学出版社,2002
    [18] BERGENDAHL J A, THIES T P.Fenton’s oxidation of MTBE with zero-valent iron[J].Water Research,2004,38(2):327-334 10.1016/j.watres.2003.10.003
    [19] ZHANG Y, DOUGLAS G B, PU L, et al.Zero-valent iron-facilitated reduction of nitrate: Chemical kinetics and reaction pathways[J].Science of the Total Environment,2017,598:1140-1150 10.1016/j.scitotenv.2017.04.071
    [20] PULLIN H, CRANE R A, MORGAN D J, et al.The effect of common groundwater anions on the aqueous corrosion of zero-valent iron nanoparticles and associated removal of aqueous copper and zinc[J].Journal of Environmental Chemical Engineering,2017,5(1):1166-1173 10.1016/j.jece.2017.01.038
    [21] KHAN A, PRABHU S M, PARK J, et al.Azo dye decolorization by ZVI under circum-neutral pH conditions and the characterization of ZVI corrosion products[J].Journal of Industrial & Engineering Chemistry,2017,47:86-93 10.1016/j.jiec.2016.11.017
    [22] LIU A, LIU J, HAN J, et al.Evolution of nanoscale zero-valent iron (nZVI) in water: Microscopic and spectroscopic evidence on the formation of nano- and micro-structured iron oxides[J].Journal of Hazardous Materials,2017,322:129-135 10.1016/j.jhazmat.2015.12.070
    [23] 丰娇,吴耀国,张娜. 零价铁-Fenton试剂体系降解有机污染物的研究进展[J]. 化工环保,2012,32(5):413-418
    [24] YUN W K, HWANG K Y.Effects of reaction conditions on the oxidation efficiency in the Fenton process[J].Water Research,2000,34(10):2786-2790 10.1016/S0043-1354(99)00388-7
    [25] LIU J, OU C, HAN W, et al.Selective removal of nitroaromatic compounds from wastewater in an integrated zero valent iron (ZVI) reduction and ZVI/H2O2 oxidation process[J].RSC Advances,2015,5(71):57444-57452 10.1039/C5RA08487C
    [26] ZHANG H, ZHANG J, ZHANG C, et al.Degradation of C.I.acid orange 7 by the advanced Fenton process in combination with ultrasonic irradiation[J].Ultrasonics Sonochemistry,2009,16(3):325-330 10.1016/j.ultsonch.2008.09.005
    [27] ZHANG H, CHOI H J, HUANG C P.Optimization of Fenton process for the treatment of landfill leachate[J].Journal of Hazardous Materials,2005,125(1):166-174 10.1016/j.jhazmat.2005.05.025
    [28] KHATAEE A R, VATANPOUR V, AMANIGHADIM A R.Decolorization of C.I.acid blue 9 solution by UV/nano-TiO2,Fenton,Fenton-like,electro-Fenton and electrocoagulation processes: A comparative study[J].Journal of Hazardous Materials,2009,161(2):1225-1233 10.1016/j.jhazmat.2008.04.075
    [29] 薛江鹏,王建中,赵泉林,等.Fenton试剂氧化处理火炸药污染土壤淋洗液[J]. 环境工程学报,2015,9(9):4365-4370
    [30] MOON B H, PARK Y B, PARK K H.Fenton oxidation of orange II by pre-reduction using nanoscale zero-valent iron[J].Desalination,2011,268(1):249-252 10.1016/j.desal.2010.10.036
    [31] DU J, GUO W, LI X, et al.Degradation of sulfamethoxazole by a heterogeneous Fenton-like system with microscale zero-valent iron: Kinetics, effect factors, and pathways[J].Journal of the Taiwan Institute of Chemical Engineers,2017,81:232-238 10.1016/j.jtice.2017.10.017
    [32] HAO O J, PHULL K K, DAVIS A P, et al.Wet air oxidation of trinitrotoluene manufacturing red water[J].Water Environment Research,1993,65(3):213-220 10.2175/WER.65.3.4
    [33] MATTA R, HANNA K, CHIRON S.Fenton-like oxidation of 2,4,6-trinitrotoluene using different iron minerals[J].Science of the Total Environment,2007,385(1):242-251 10.1016/j.scitotenv.2007.06.030
    [34] CHEN W S, JUAN C N, WEI K M.Mineralization of dinitrotoluenes and trinitrotoluene of spent acid in toluene nitration process by Fenton oxidation[J].Chemosphere,2005,60(8):1072-1079 10.1016/j.chemosphere.2005.01.021
  • 加载中
WeChat 点击查看大图
计量
  • 文章访问数:  4191
  • HTML全文浏览数:  3893
  • PDF下载数:  216
  • 施引文献:  0
出版历程
  • 刊出日期:  2018-08-17
王如凡, 徐文杰, 叶正芳. 零价铁耦合芬顿氧化法处理TNT红水[J]. 环境工程学报, 2018, 12(8): 2153-2160. doi: 10.12030/j.cjee.201801059
引用本文: 王如凡, 徐文杰, 叶正芳. 零价铁耦合芬顿氧化法处理TNT红水[J]. 环境工程学报, 2018, 12(8): 2153-2160. doi: 10.12030/j.cjee.201801059
shu
WANG Rufan, XU Wenjie, YE Zhengfang. Treatment of TNT red water by Fenton oxidation coupled with zero valent iron[J]. Chinese Journal of Environmental Engineering, 2018, 12(8): 2153-2160. doi: 10.12030/j.cjee.201801059
Citation: WANG Rufan, XU Wenjie, YE Zhengfang. Treatment of TNT red water by Fenton oxidation coupled with zero valent iron[J]. Chinese Journal of Environmental Engineering, 2018, 12(8): 2153-2160. doi: 10.12030/j.cjee.201801059
shu

零价铁耦合芬顿氧化法处理TNT红水

  • 1. 北京大学，北京市新型污水深度处理工程技术研究中心，北京100871
基金项目:

北京市科技计划项目（Z151100000915065）

摘要: 采用零价铁耦合芬顿氧化法处理TNT红水，研究了初始pH、零价铁投加量、过氧化氢（H2O2）投加量及温度对红水中总有机碳（TOC）去除效果的影响，同时进行了TOC去除过程中反应动力学的探讨。结果表明，零价铁耦合芬顿氧化体系可有效降解TNT红水中的2,4-二硝基甲苯-3-磺酸钠和2,4-二硝基甲苯-5-磺酸钠。在初始pH为2，温度为20 ℃的条件下，加入1.5 g·L-1零价铁反应1 h后，再加入100 mL·L-1H2O2反应4 h，红水中二硝基甲苯磺酸盐浓度从500 mg·L-1降至0 mg·L-1，去除率为100%，TOC浓度从150 mg·L-1降至30 mg·L-1，去除率达到80%。反应中TOC的降解过程遵循拟二级反应动力学方程。零价铁耦合芬顿氧化法可以作为TNT红水的有效处理途径。

English Abstract

参考文献 (34)

返回顶部

目录

/

返回文章
返回

Copyright © 2019 中国科学院生态环境研究中心