污泥厌氧消化反应器CFD数值模拟研究进展

曹秀芹; 徐国庆; 袁海光; 江坤; 仇付国; 尹伟齐; 付昆明

doi:10.12030/j.cjee.201803001

[1]

曹秀芹，赵振东，杨平，等. 污泥厌氧消化反应器搅拌性能的CFD模拟[J]. 给水排水,2016,42(3):137-141

[2]

XU W.Scale-up and optimization of biohydrogen production reactor from laboratory-scale to industrial-scale on the basis of computational fluid dynamics simulation[J].International Journal of Hydrogen Energy,2010,35(20):10960-10966 10.1016/j.ijhydene.2010.07.060

[3]

WU B X.Advances in the use of CFD to characterize design and optimize bioenergy systems[J].Computers and Electronics in Agriculture,2013,92(3):195-208 10.1016/j.compag.2012.05.008

[4]

WU B X.CFD simulation of mixing in egg-shaped anaerobic digesters[J].Water Research,2010,44(5):1507-1519 10.1016/j.watres.2009.10.040

[5]

METZNER A B, REED J C.Flow of non-Newtonian fluids correlation of laminar transition and turbulent-flow regions[J].AIChE Journal,1955,1(4):434-440 10.1002/aic.690010409

[6]

TERASHIMA M, GOEL R, KOMATSU K, et al.CFD simulation of mixing in anaerobic digesters[J].Bioresource Technology,2009,100(7):2228-2233 10.1016/j.biortech.2008.07.069

[7]

YU L, MA J, CHEN S.Numerical simulation of mechanical mixing in high solid anaerobic digester[J].Bioresource Technology,2011,102(2):1012–1018 10.1016/j.biortech.2010.09.079

[8]

WU B.CFD investigation of turbulence models for mechanical agitation of non-Newtonian fluids in anaerobic digesters[J].Water Research,2011,45(5):2082-2094 10.1016/j.watres.2010.12.020

[9]

TOM B, BECHTEL P E.Laminar pipeline flow of wastewater sludge: Computational fluid dynamics approach[J].Journal of Hydraulic Engineering,2003,129(2):153-158 10.1061/(ASCE)0733-9429(2003)129:2(153)

[10]

LóPEZ-JIMéNEZA P A, ESCUDERO-GONZáLEZA J, MARTíNEZC T M, et al.Application of CFD methods to an anaerobic digester: The case of Ontinyent WWTP, Valencia, Spain[J].Journal of Water Process Engineering,2015,7:131-140 10.1016/j.jwpe2015.05.006

[11]

王福军. 计算流体动力学分析:CFD软件原理与应用[M]. 北京: 清华大学出版社,2004:136-137

[12]

COUGHTRIE A R, BORMAN D J, SLEIGH P A.Effects of turbulence modelling on prediction of flow characteristics in a bench-scale anaerobic gas-lift digester[J].Bioresource Technology,2013,1138(2):297-306 10.1016/j.biortech.2013.03.162

[13]

WU B X.CFD simulation of gas and non-Newtonian fluid two-phase flow in anaerobic digesters[J].Water Research,2010,44(13):3861-3874 10.1016/j.watres.2010.04.043

[14]

WU B X.Computational fluid dynamics investigation of turbulence models for non-Newtonian fluid flow in anaerobic digesters[J].Environmental Science and Technology,2010,44(23):8989-8995 10.1021/es1010016

[15]

WU B X.Large eddy simulation of mechanical mixing in anaerobic digesters[J].Biotechnology & Bioengineering,2012,109:804-812 10.1002/bit.24345

[16]

YU L, MA J W, FREAR C, et al.Multiphase modeling of settling and suspension in anaerobic digester[J].Applied Energy,2013,111:28-39 10.1016/j.apenergy.2013.04.073

[17]

KARIM K, THOMA G J, ALDAHHAN M H.Gas-lift digester configuration effects on mixing effectiveness[J].Water Research,2007,41:3051-3060 10.1016/j.watres.2007.03.042

[18]

KARIM K, VARMA R, VESVIKAR M.et al.Flow pattern visualization of a simulated digester[J].Water Research,2004,38:3659-3670 10.1016/j.watres.2004.06.009

[19]

KARIM K, THOMA G J, ALDAHHAN M H.Gas-lift digester configuration effects on mixing effectiveness[J].Water Research,2007,41:3051-3060 10.1016/j.watres.2007.03.042

[20]

ZHANG Y, YU G R, YU L, et al.Computational fluid dynamics study on mixing mode and power consumption in anaerobic mono- and co-digestion[J].Bioresource Technology,2016,203:166-172 10.1016/j.biortech.2015.12.023

[21]

宋金礼，陈贵军，王娟. 发酵罐内固液两相流的数值模拟[J]. 节能,2015,34(5):22-25

[22]

VESVIKAR M S, ALDAHHAN M H.Effect of scale on hydrodynamics of internal gas-lift loop reactor-type anaerobic digester using CFD[J].Chemical Product and Process Modeling,2015,10(3):179-192 10.1515/cppm-2015-0009

[23]

WU B X.CFD simulation of gas mixing in anaerobic digesters[J].Computers & Electronics in Agriculture,2014,109:278-286 10.1016/j.compag.2014.10.007

[24]

SOUSA LIMA M G, DE LIMA A G B, BRITO NUNES F C.Theoretical/experimental study of an upflow anaerobic sludge blanket reactor treating domestic wastewater[J].International Journal of Chemical Reactor Engineering,2011,9(1):1542-6580 10.1515/1542-6580.2599

[25]

WANG X, DING J, GUO W Q, et al.A hydrodynamics–reaction kinetics coupled model for evaluating bioreactors derived from CFD simulation[J].Bioresource Technology,2010,101(24):9749-9757 10.1016/j.biortech.2010.07.115

[26]

MURTHY B N, GHADGE R S, JOSHI J B.CFD simulations of gas–liquid–solid stirred reactor: Prediction of critical impeller speed for solid suspension[J].Chemical Engineering Science,2007,62(24):7184?7195 10.1016/j.ces.2007.07.005

[27]

VESVIKAR M S, ALDAHHAN M H.Flow pattern visualization in a mimic anaerobic digester using CFD [J].Biotechnology and Bioengineering,2005,89:719-732 10.1002/bit.20388

[28]

MERONEY R N, COLORADO P E.CFD simulation of mechanical draft tube mixing in anaerobic digester tanks[J].Water Research,2009,43(4):1040-1050 10.1016/j.watres.2008.11.035

[29]

WU B X.CFD analysis of mechanical mixing in anaerobic digesters[J].Transactions of the ASABE,2009,52(4):1371-1382 10.13031/2013.27786

[30]

WU B X.CFD prediction of mixing time in anaerobic digesters[J].Transactions of the ASABE,2010,53(2):553-563 10.13031/2013.29570

[31]

MENDOZAL A M, MARTINEZ T M, MONTANANA V F, et al.Modeling flow inside an anaerobic digester by CFD techniques[J].International Journal of Energy and Environmental,2011,2(6):963-974

[32]

WU B X, CHEN Z B.An integrated physical and biological model for anaerobic lagoons[J].Bioresource Technology,2011,102:5032-5038 10.1016/j.biortech.2011.01.076

[33]

BRIDGEMAN J.Computational fluid dynamics modelling of sewage sludge mixing in an anaerobic digester[J].Advances in Engineering Software,2012,44(1):54-62 10.1016/j.advengsoft.2011.05.037

[34]

SINDALL R, BRIDGEMAN J, CARLIELL M C.Velocity gradient as a tool to characterise the link between mixing and biogas production in anaerobic waste digesters[J].Water Science & Technology,2013,67(12):2800-2806 10.2166/wst.2013.206

[35]

曹秀芹，赵振东，杨平，等.基于污泥流变特性对厌氧消化反应器的模拟研究[J].给水排水,2016,52(7):36-41

[36]

WANG F P, ZHANG C S, HUO S H.Influence of fluid dynamics on anaerobic digestion of food waste for biogas production[J].Environmental Technology,2017,38(9):1160-1168 10.1080/09593330.2016.1220429

[37]

WU B X.CFD study of submersible mixers in anaerobic digesters[J].Transactions of the ASABE,2017,60(2):275-282 10.13031/trans.12096

[38]

曹秀芹，丁浩，蒋竹荷，等. 液-液射流搅拌提高热水解污泥混合性能分析[J].环境工程学报,2018,12(1):316-323 10.12030/j.cjee.201706194

[39]

王乐，樊敏，詹翔宇，等. 气体搅拌下厌氧消化反应器CFD数值模拟及模型研究[J].农业机械学报,2018,49(2):305-312

[40]

MEISTER M, REZAVAND M, EBNER C, et al.Mixing non-Newtonian flows in anaerobic digesters by impellers and pumped recirculation[J].Advances in Engineering Software,2018,115:194-203 10.1016/j.advengsoft.2017.09.015

[41]

CRAIG K J, NIEUWOUDT M N, NIEMAND L J.CFD simulation of anaerobic digester with variable sewage sludge rheology[J].Water Research,2013,47(13):4485-4497 10.1016/j.watres.2013.05.011

[42]

SAJJADI B, RAMAN A A A, PARTHASARATHY R.Fluid dynamic analysis of non-Newtonian flow behavior of municipal sludge simulant in anaerobic digesters using submerged recirculating jets[J].Chemical Engineering Journal,2016,298:259-270 10.1016/j.cej.2016.03.069

[43]

METZNER A B, OTTO R E.Agitation of non-Newtonian fluids[J].American Institute of Chemical Engineers,1957,3(1):3-10 10.1002/aic.690030103

[44]

LIU J B, YANG M, ZHANG J Y, et al.A comprehensive insight into the effects of microwave-H₂O₂, pretreatment on concentrated sewage sludge anaerobic digestion based on semi-continuous operation[J].Bioresource Technology,2018,256:118-127 10.1016/j.biortech.2018.01.126

[45]

KAZEMZADEH A, EIN-MOZAFFARI F, LOHI A, et al.Effect of the rheological properties on the mixing of Herschel-Bulkley fluids with coaxial mixers: Applications of tomography, CFD, and response surface methodology[J].Canadian Journal of Chemical Engineering,2016,94(12):2394-2406 10.1002/cjce.22601

[46]

WICKLEIN E, BATSTONE D J, DUCOSTE J, et al.Good modelling practice in applying computational fluid dynamics for WWTP modelling[J].Water Science and Technology,2016,73(5):969-982 10.2166/wst.2015.565

[47]

曹秀芹，尹伟齐，赵振东. 不同含水率下污泥流变模型的显著性水平分析[J]. 北京工业大学学报,2017,43(1):150-157

[48]

ZHANG J S, HAWARD S J, WU Z G, et al.Evolution of rheological characteristics of high-solid municipal sludge during anaerobic digestion[J].Applied Rheology,2016,26(3):1-10 10.3933/ApplRheol-26-32973

[49]

ZHANG J S, XUE Y G, ESHTIAGHI N, et al.Evaluation of thermal hydrolysis efficiency of mechanically dewatered sewage sludge via rheological measurement[J].Water Research,2017,116:34-43 10.1016/j.watres.2017.03.020

[50]

SAFFARIAN M R, HAMEDI M H, SHAMS M.Numerical simulation of a secondary clarifier in a sewage treatment plant using modified Bingham model[J].Canadian Journal of Civil Engineering,2011,38(1):11-22 10.1139/L10-106

[51]

董登志，张静思，吴志根，等. 高含固污泥临界剪切应力影响因素的研究[J]. 西安交通大学学报,2017,51(11):57-62 10.7652/xjtuxb201711009

[52]

MICALE G, GRISAFI F, RIZZUTI I, et al.CFD simulation of particle suspension height in stirred vessels[J].Chemical Engineering Research and Design,2004,82(9):1204-1213 10.1205/cerd.82.9.1204.44171

[53]

WANG Z, MAO Z S, SHEN X Q.Numerical simulation of macroscopic mixing in a rushton impeller stirred tank[J].Chinese Journal of Process Engineering,2006,6(6):857-863 10.3321/j.issn:1009-606X.2006.06.001

[54]

BELLO M R, SHARRATT P N.Modelling the effects of imperfect mixing on the performance of anaerobic reactors for sewage sludge treatment[J].Journal of Chemical Technology and Biotechnology,1998,71:121-130 10.1002/(SICI)1097-4660(199802)71:2<121::AID-JCTB836>3.0.CO;2-7

[55]

王令闪，苏红军，徐世艾. 高黏体系中最大叶片式搅拌桨直径的CFD优化[J].化学工程,2011,39(7):9-12

[56]

尹伟齐，曹秀芹，张达飞. 猪粪流变特性及基于黏度曲线的反应器死区研究[J].中国沼气,2017,35(3):27-32

[57]

CAMP T R, STEIN P C.Velocity gradients and internal work in fluid motion[J].Journal of the Boston Society Civil Engineers, 1943,30:219-237

[58]

GRABER S D.A critical review of the use of the G-value (RMS velocity gradient) in environmental engineering[J].Development in Theoret & Applied Mechanics,1994,17:533-556

[59]

曹秀芹，杨平，赵振东. 污泥流变学及其厌氧消化混合特性数值模拟研究进展[J].环境工程学报,2015,9(3):997-1003

[60]

芦汉超. 机械搅拌厌氧消化池流态研究[D].北京:清华大学,2015

[61]

WANG F P, ZHANG C S, HUO S H.Influence of fluid dynamics on anaerobic digestion of food waste for biogas production Influence of fluid dynamics on anaerobic digestion of food waste for biogas production[J].Environmental Technology,2016,38(9):1160–1168 10.1080/09593330.2016.1220429

[62]

曹秀芹，杜金海，李彩斌，等. 污泥厌氧消化搅拌条件的优化分析[J].环境科学与技术,2015,38(1):100-105

[63]

KARIM K, KLASSON K T, HOFFMANN R, et al.Anaerobic digestion of animal waste: Effect of mixing [J].Bioresource Technology,2005,96:1607-1612 10.1016/j.biortech.2004.12.021

[64]

APPELS L, BAEYENS J, DEGREVE J, et al.Principles and potential of the anaerobic digestion of waste-activated sludg[J].Progress in Energy and Combustion Science,2008,34:755-781 10.1016/j.pecs.2008.06.002

[65]

KINYUA M N, ZHANG J, CAMACHO C F, et al.Use of physical and biological process models to understand the performance of tubular anaerobic digesters[J].Biochemical Engineering Journal,2016,107:35?44 10.1016/j.bej.2015.11.017

[66]

LEBRANCHU A, DELAUNAY S, MARCHAL P, et al.Impact of shear stress and impeller design on the production of biogas in anaerobic digesters[J].Bioresource Technology,2017,245:1139-1147 10.1016/j.biortech.2017.07.113

[67]

KESHTKAR A, MEYSSAMI B, ABOLHAMD G, et al.Mathematical modeling of non-ideal mixing continuous flow reactors for anaerobic digestion of cattle manure[J].Bioresource Technology,2003,87:113-124 10.1016/S0960-8524(02)00104-9

[68]

WU B X, BIBEAU E L, GEBREMEDHIN K G.Three-dimensional numerical simulation model of biogas production for anaerobic digesters[J].Canadian Biosystems Engineering,2009,51:81-87 10.13031/2013.20924

[69]

FLEMING J G.Novel simulation of anaerobic digestion using computational fluid dynamics[D].Raleigh, NC: North Carolina State University,2002

[70]

杨艳清.EGSB反应器处理低浓度挥发酸废水CFD-生化反应耦合模型及模拟研究[D].重庆:重庆大学,2015