高级搜索

纤维种类对纤维束过滤器除尘性能的影响

,  ,  ,  , 

downloadPDF

上一篇

下一篇

付群飞, 房杰, 时杰, 曹晓强, 吕宪俊. 纤维种类对纤维束过滤器除尘性能的影响[J]. 环境工程学报, 2019, 13(3): 701-707. doi: 10.12030/j.cjee.201809079
引用本文: 付群飞, 房杰, 时杰, 曹晓强, 吕宪俊. 纤维种类对纤维束过滤器除尘性能的影响[J]. 环境工程学报, 2019, 13(3): 701-707. doi: 10.12030/j.cjee.201809079
shu
FU Qunfei, FANG Jie, SHI Jie, CAO Xiaoqiang, LYU Xianjun. Effect of fiber type on dust removal performance of fiber bundle filters[J]. Chinese Journal of Environmental Engineering, 2019, 13(3): 701-707. doi: 10.12030/j.cjee.201809079
Citation: FU Qunfei, FANG Jie, SHI Jie, CAO Xiaoqiang, LYU Xianjun. Effect of fiber type on dust removal performance of fiber bundle filters[J]. Chinese Journal of Environmental Engineering, 2019, 13(3): 701-707. doi: 10.12030/j.cjee.201809079
shu

纤维种类对纤维束过滤器除尘性能的影响

  • 1.

    山东科技大学化学与环境工程学院，青岛 266590

  • 2.

    山东泰山钢铁集团有限公司，莱芜 271199

  • 基金项目:

    国家自然科学基金资助项目51674161

    山东省自然科学基金重大基础研究项目ZR2017ZC070735国家自然科学基金资助项目(51674161)

    山东省自然科学基金重大基础研究项目(ZR2017ZC070735)

Effect of fiber type on dust removal performance of fiber bundle filters

  • 1.

    College of Chemical and Environmental Engineering, Shandong University of Science and Technology, Qingdao 266590, China

  • 2.

    Shandong Taishan Steel Group Co.Ltd., Laiwu 271199, China

  • Fund Project:

  • 摘要: 为了探究聚丙烯腈纤维、玻璃纤维和聚丙烯纤维3种纤维对纤维束过滤器除尘性能的影响，以路面扬尘为研究对象，在入口颗粒物浓度0.58 g·m-3、风速1.0 m·s-1、流量63.62 m3·h-1、纤维填充率0.67%的条件下，研究不同过滤单元材质(聚丙烯腈纤维、玻璃纤维和聚丙烯纤维)除尘效率和压降的变化情况。结果表明，3种材质中聚丙烯腈纤维束除尘性能最好，除尘效率为70%~80%，其除尘效率比聚丙烯纤维束整体高20%。通过过滤介质表面电荷密度测定发现，在实验过程中，3种纤维表面都存在电荷，且聚丙烯腈纤维电荷密度>玻璃纤维电荷密度>聚丙烯纤维电荷密度。通过SEM检测发现，粉尘颗粒以静电吸附和纤维间填充2种方式赋存于过滤器内部，这表明纤维束过滤器除尘机理为静电作用和机械拦截作用的联合。
    Abstract: In order to study the effect of filter materials on the dust removal performance of fiber bundle filter,road dust was taken as a removal object, polyacrylonitrile fiber, glass fiber and polypropylene fiber were used in the filters with 0.67% fiber filling rate, respectively. Then the dust collection efficiency and pressure drop of these filters were studied under the conditions of inlet particle concentration of 0.58 g·m-3, air flow speed of 1.0 m·s-1, air flow rate of 63.62 m3·h-1.The surface charge density of the fiber was determined by an electrostatic charge tester,and the dust occurrence in the fiber bundle was recorded by a scanning electron microscope. The results showed that the polyacrylonitrile fiber bundle had the best dust removal performance among the three materials, its dust removal efficiency was 70%~80% and 20% higher than that of the polypropylene fiber bundle. The surface charge density of the filter media indicated that three fibers had surface charges, and the surface charge density order was polyacrylonitrile > glass > polypropylene. Through SEM observation, the dust particles existed in the filter by electrostatic adsorption and filling in fibers, which implied that the dust removal mechanism of fiber bundle filter was the combination of electrostatic interaction and mechanical interception.
  • 加载中
  • [1] S?B? A, POPEK R, NAWROT B, et al. Plant species differences in particulate matter accumulation on leaf surfaces[J]. Science of the Total Environment, 2012, 427-428(5): 347-354.
    [2] HOYLE C R, BOY M, DONAHUE N M, et al. A review of the anthropogenic influence on biogenic secondary organic aerosol[J]. Atmospheric Chemistry & Physics, 2011, 11(1): 321-343.
    [3] DZIERZANOWSKI K, POPEK R, GAWRO?SKA H, et al. Deposition of particulate matter of different size fractions on leaf surfaces and in waxes of urban forest species[J]. International Journal of Phytoremediation, 2011, 13(10): 1037-1046.
    [4] SHAUGHNESSY W J, VENIGALLA M M, TRUMP D. Health effects of ambient levels of respirable particulate matter (PM) on healthy, young-adult population[J]. Atmospheric Environment, 2015, 123: 102-111.
    [5] BAULIG A, SOURDEVAL M, MEYER M, et al. Biological effects of atmospheric particles on human bronchial epithelial cells. Comparison with diesel exhaust particles[J]. Toxicology in Vitro, 2003, 17(5/6): 567-573.
    [6] 戴海霞, 宋伟民, 高翔, 等. 上海市A城市大气PM10.0、PM2.5污染与居民死亡数的相关性[J]. 卫生研究, 2004, 33(3)： 293-297.
    [7] 侯力强, 张小庆, 卢文静, 等. 金属纤维毡在高温除尘上的性能测试与分析[J]. 过滤与分离, 2016, 26(1): 28-32.
    [8] 水甜甜, 沈恒根, 杨学宾, 等. 驻极体空气过滤器对办公环境PM2.5的净化效果[J]. 环境工程学报, 2015, 9(6): 2933-2940.
    [9] DEY L, VENKATARAMAN C. A wet electrostatic precipitator (WESP) for soft nanoparticle collection[J]. Aerosol Science & Technology, 2012, 46(7): 750-759.
    [10] LEE J K, KIM S C, SHIN J H, et al. Performance evaluation of electrostatically augmented air filters coupled with a corona charger[J]. Aerosol Science Technology, 2001, 35(4): 785-791.
    [11] KIM H J, HAN B, KIM Y J, et al. Fine particle removal performance of a two stage wet electrostatic precipitator using a nonmetallic pre-charger[J]. Journal of the Air & Waste Management Association, 2011, 61(12): 1334-1343.
    [12] KIM H J, HAN B, KIM Y J, et al. Characteristics of an electrostatic precipitator for submicron particles using non-metallic electrodes and collection plates[J]. Journal of Aerosol Science, 2010, 41(11): 987-997.
    [13] 夏钟福. 驻极体[M]. 北京: 科学出版社, 2001.
    [14] 周刘轲, 沈恒根, 马欢, 等. 风机盘管回风口加装驻极体过滤器过滤PM2.5性能分析[J]. 环境工程学报, 2017, 11(1): 432-438.
    [15] 黄翔, 顾群, 吴生. 聚合物驻极体过滤材料(器)在空调中的应用[J]. 洁净与空调技术, 2003(4): 38-42.
    [16] LI K, JO Y M. Dust collection by a fiber bundle electret filter in an MVAC system[J]. Aerosol Science & Technology, 2010, 44(7): 578-587.
    [17] PARK H, KIM W, JO Y. Field application of a double filtration process to control fine dust in a metro subway station[J]. Journal of Korean Society for Atmospheric Environment, 2013, 29(5): 625-633.
    [18] NOH K C, LEE J H, KIM C, et al. Filtration of submicron aerosol particles using a carbon fiber ionizer-assisted electret filter[J]. Aerosol & Air Quality Research, 2011, 11(7): 811-821.
    [19] NOH K C, PARK J H, JUNG Y K, et al. Characteristics of submicron-sized aerosol filtration and pressure drop of an electret filter installed in an air diffuser in a residential apartment unit[J]. Aerosol & Air Quality Research, 2011, 11(1): 80-89.
    [20] EFIMOV A A, IVANOV V V, VOLKOV I A, et al. Filtration of nanosized particle aerosols by electret fibrous filters[J]. Nanotechnologies in Russia, 2013, 8(11/12): 789-798.
    [21] 胡笙坚. 摩擦带电机理的探讨和静电带电量的测量[J]. 铁道科学与工程学报, 1988(2): 94-101.
    [22] 章新喜, 段超红, 于凤芹, 等. 微粉煤的电性质及摩擦带电研究[J]. 中国矿业大学学报, 2005, 34(6): 694-697.
  • 加载中
WeChat 点击查看大图
计量
  • 文章访问数:  3037
  • HTML全文浏览数:  3006
  • PDF下载数:  112
  • 施引文献:  0
出版历程
  • 刊出日期:  2019-03-14

纤维种类对纤维束过滤器除尘性能的影响

  • 1. 山东科技大学化学与环境工程学院，青岛 266590
  • 2. 山东泰山钢铁集团有限公司，莱芜 271199
基金项目:

国家自然科学基金资助项目51674161

山东省自然科学基金重大基础研究项目ZR2017ZC070735国家自然科学基金资助项目(51674161)

山东省自然科学基金重大基础研究项目(ZR2017ZC070735)

摘要: 为了探究聚丙烯腈纤维、玻璃纤维和聚丙烯纤维3种纤维对纤维束过滤器除尘性能的影响，以路面扬尘为研究对象，在入口颗粒物浓度0.58 g·m-3、风速1.0 m·s-1、流量63.62 m3·h-1、纤维填充率0.67%的条件下，研究不同过滤单元材质(聚丙烯腈纤维、玻璃纤维和聚丙烯纤维)除尘效率和压降的变化情况。结果表明，3种材质中聚丙烯腈纤维束除尘性能最好，除尘效率为70%~80%，其除尘效率比聚丙烯纤维束整体高20%。通过过滤介质表面电荷密度测定发现，在实验过程中，3种纤维表面都存在电荷，且聚丙烯腈纤维电荷密度>玻璃纤维电荷密度>聚丙烯纤维电荷密度。通过SEM检测发现，粉尘颗粒以静电吸附和纤维间填充2种方式赋存于过滤器内部，这表明纤维束过滤器除尘机理为静电作用和机械拦截作用的联合。

English Abstract

    全文HTML

参考文献 (22)

目录

/

返回文章
返回

Copyright © 2019 中国科学院生态环境研究中心