高级搜索

微波耦合氯化铁调理对活性污泥脱水性能及热值的影响

,  ,  , 

downloadPDF

上一篇

下一篇

林浚铭, 吴璐超, 柯鹏, 官宝红. 微波耦合氯化铁调理对活性污泥脱水性能及热值的影响[J]. 环境工程学报, 2018, 12(12): 3475-3482. doi: 10.12030/j.cjee.201806086
引用本文: 林浚铭, 吴璐超, 柯鹏, 官宝红. 微波耦合氯化铁调理对活性污泥脱水性能及热值的影响[J]. 环境工程学报, 2018, 12(12): 3475-3482. doi: 10.12030/j.cjee.201806086
shu
LIN Junming, WU Luchao, KE Peng, GUAN Baohong. Effect of microwave irradiation coupled with ferric chloride conditioning on sludge dewaterability and calorific value[J]. Chinese Journal of Environmental Engineering, 2018, 12(12): 3475-3482. doi: 10.12030/j.cjee.201806086
Citation: LIN Junming, WU Luchao, KE Peng, GUAN Baohong. Effect of microwave irradiation coupled with ferric chloride conditioning on sludge dewaterability and calorific value[J]. Chinese Journal of Environmental Engineering, 2018, 12(12): 3475-3482. doi: 10.12030/j.cjee.201806086
shu

微波耦合氯化铁调理对活性污泥脱水性能及热值的影响

  • 1.

    浙江大学环境工程系，杭州 310058

  • 基金项目:

    国家重点研发计划项目（2016YFB0301800）

Effect of microwave irradiation coupled with ferric chloride conditioning on sludge dewaterability and calorific value

  • 1.

    Department of Environmental Engineering, Zhejiang University, Hangzhou 310058, China

  • Fund Project:

  • 摘要: 为实现活性污泥高效脱水和资源化利用，研究了微波耦合氯化铁调理活性污泥。主要考察微波耦合氯化铁对活性污泥脱水性能和热值的影响。微波辐射能够改善活性污泥的脱水性能，优化参数为功率700 W、时间100 s。微波耦合氯化铁调理进一步增强了活性污泥的脱水性能，先投加氯化铁后微波辐射的调理（氯化铁+微波）效果优于先微波辐射后投加氯化铁的调理（微波+氯化铁）效果，脱水效果的改善得益于活性污泥絮体的增大以及EPS的减少。微波调理后的活性污泥（干基）热值随着微波辐射时间的增长逐渐降低，而微波耦合氯化铁调理后的活性污泥（干基）热值随着氯化铁投加量的增加先增加后减少。
    Abstract: A novel method was performed by conditioning the sludge under microwave irradiation coupled with ferric chloride to achieve efficient dewatering and resource utilization of activated sludge, focusing on the improvement of dewaterability and the evolution of calorific value. The results showed that the sludge dewaterability was improved by microwave irradiation at the optimal conditions of 700 W and 100 s. The microwave irradiation stimulated the growth of sludge flocs, which neutralized the increase of SB-EPS and LB-EPS that deteriorates sludge dewaterability. Moreover, microwave irradiation coupled with ferric chloride conditioning further improved the sludge dewaterability. The conditioning effect by FeCl3 dosing-microwave irradiation was better than that by microwave irradiation-FeCl3 dosing. The increase of sludge flocs and the reduction of EPS resulted from microwave irradiation coupled with ferric chloride (FeCl3) are responsible for the sludge dewaterability improvement. The calorific value of the sludge gradually decreased with the time under microwave irradiation, while it increased first and then decreased with the increase of ferric chloride dosage. The calorific value is negatively correlated with the content of SB-EPS and LB-EPS in the activated sludge.
  • 加载中
  • [1] 林子增, 黄瑛, 乔红杰, 等. 城市污水厂污泥化学调理深度脱水技术述评[J]. 应用化工,2016,45(6):1159-1162
    [2] HALDE R.Concentration of impurities by progressive freezing[J].Water Research,1980,14(6):575-580 10.1016/0043-1354(80)90115-3
    [3] FENG X, DENG J, LEI H, et al.Dewaterability of waste activated sludge with ultrasound conditioning[J].Bioresource Technology,2009,100(3):1074-1081 10.1016/j.biortech.2008.07.055
    [4] YU Q, LEI H Y, YU G W, et al.Influence of microwave irradiation on sludge dewaterability[J].Chemical Engineering Journal,2009,155(1):88-93 10.1016/j.cej.2009.07.010
    [5] WOJCIECHOWSKA E.Application of microwaves for sewage sludge conditioning[J].Water Research,2005,39(19):4749-4754 10.1016/j.watres.2005.09.032
    [6] ESKICIOGLU C, KENNEDY K J, DROSTE R L.Enhancement of batch waste activated sludge digestion by microwave pretreatment[J].Water Environment Research A: Research Publication of the Water Environment Federation,2007,79(11):2304-2317 10.2175/106143007X184069
    [7] ESKICIOGLU C, KENNEDY K J, DROSTE R L.Initial examination of microwave pretreatment on primary, secondary and mixed sludges before and after anaerobic digestion[J].Water Science and Technology,2008,57(3):311-317 10.2166/wst.2008.010
    [8] YU Q, LEI H Y, LI Z, et al.Physical and chemical properties of waste-activated sludge after microwave treatment[J].Water Research,2010,44(9):2841-2849 10.1016/j.watres.2009.11.057
    [9] LIU J B, WEI Y S, LI K, et al.Microwave-acid pretreatment: A potential process for enhancing sludge dewaterability[J].Water Research,2016,90:225-234 10.1016/j.watres.2015.12.012
    [10] 林颐, 宁寻安, 温炜彬, 等. 高铁酸钾-微波耦合对印染污泥脱水性能的影响研究[J]. 环境科学学报,2014,34(7):1776-1780
    [11] 林宁波. 微波联合过硫酸钠耦合调理改善污泥脱水性能研究[D]. 长沙: 湖南大学,2014
    [12] ZHANG J, YANG K, WANG H Y, et al.Impact of microwave treatment on dewaterability of sludge during Fenton oxidation[J].Desalination & Water Treatment,2016,57(31):14424-14432 10.1080/19443994.2015.1065765
    [13] 中华人民共和国建设部. 城市污水处理厂污泥检验方法: CJ/T 221-2005[S]. 北京: 中国标准出版社,2006
    [14] LUO H J, NING X A, LIANG X J, et al.Effects of sawdust-CPAM on textile dyeing sludge dewaterability and filter cake properties[J].Bioresource Technology,2013,139:330-336 10.1016/j.biortech.2013.04.035
    [15] XIAO K K, CHEN Y, XIE J, et al.Characterization of key organic compounds affecting sludge dewaterability during ultrasonication and acidification treatments[J].Water Research,2016,105:470-478 10.1016/j.watres.2016.09.030
    [16] 许志楠. 模板聚合阳离子聚丙烯酰胺PDA 的合成及其污泥脱水性能研究[D]. 重庆: 重庆大学,2015
    [17] 王蓉. 化学混凝污泥脱水性能研究[D]. 广州: 广东工业大学,2008
    [18] 方琳. 微波能作用下污泥脱水和高温热解的效能与机制[D]. 哈尔滨: 哈尔滨工业大学,2007
    [19] YU G H, HE P J, SHAO L M, et al.Stratification structure of sludge flocs with implications to dewaterability[J].Environmental Science & Technology,2008,42(21):7944-7949 10.1021/es8016717
    [20] XIAO K K, CHEN Y, JIANG X, et al.Variations in physical, chemical and biological properties in relation to sludge dewaterability under Fe(II)-oxone conditioning[J].Water Research,2016,109:13-23 10.1016/j.watres.2016.11.034
    [21] LI H S, WEN Y, CAO A S, et al.The influence of additives (Ca2+, Al3+, and Fe3+) on the interaction energy and loosely bound extracellular polymeric substances (EPS) of activated sludge and their flocculation mechanisms[J].Bioresource Technology,2012,114(2):188-194 10.1016/j.biortech.2012.03.043
    [22] YU J, GUO M H, XU X H, et al.The role of temperature and CaCl2 in activated sludge dewatering under hydrothermal treatment[J].Water Research,2014,50(1):10-17 10.1016/j.watres.2013.11.034
    [23] GUAN B H, YU J, FU H L, et al.Improvement of activated sludge dewaterability by mild thermal treatment in CaCl2 solution[J].Water Research,2012,46(2):425-432 10.1016/j.watres.2011.11.014
    [24] ZHANG W J, CHEN Z C, CAO B D, et al.Improvement of wastewater sludge dewatering performance using titanium salt coagulants (TSCs) in combination with magnetic nano-particles: Significance of titanium speciation[J].Water Research,2016,110:102-110 10.1016/j.watres.2016.12.011
  • 加载中
WeChat 点击查看大图
计量
  • 文章访问数:  2137
  • HTML全文浏览数:  1958
  • PDF下载数:  117
  • 施引文献:  0
出版历程
  • 刊出日期:  2018-11-29

微波耦合氯化铁调理对活性污泥脱水性能及热值的影响

  • 1. 浙江大学环境工程系，杭州 310058
基金项目:

国家重点研发计划项目（2016YFB0301800）

摘要: 为实现活性污泥高效脱水和资源化利用，研究了微波耦合氯化铁调理活性污泥。主要考察微波耦合氯化铁对活性污泥脱水性能和热值的影响。微波辐射能够改善活性污泥的脱水性能，优化参数为功率700 W、时间100 s。微波耦合氯化铁调理进一步增强了活性污泥的脱水性能，先投加氯化铁后微波辐射的调理（氯化铁+微波）效果优于先微波辐射后投加氯化铁的调理（微波+氯化铁）效果，脱水效果的改善得益于活性污泥絮体的增大以及EPS的减少。微波调理后的活性污泥（干基）热值随着微波辐射时间的增长逐渐降低，而微波耦合氯化铁调理后的活性污泥（干基）热值随着氯化铁投加量的增加先增加后减少。

English Abstract

参考文献 (24)

目录

/

返回文章
返回

Copyright © 2019 中国科学院生态环境研究中心