蔬菜类废弃物甲烷发酵的产气潜能及过程特征
Biogas production potential and process character of methane fermentation of vegetable waste
-
摘要: 蔬菜废弃物具有适合厌氧发酵的特性。采用Batch实验方法,对5种常见的蔬菜废弃物的产气潜能进行研究,并在此基础上进一步对厌氧发酵过程限制性步骤及物质转化特征进行分析。研究结果表明:5种蔬菜废弃物累积产甲烷量在发酵0～10 d内增加较快,土豆和白菜废弃物产甲烷潜能最大,分别达到102 mL·g-1(VS),和83 mL·g-1(VS),而黄瓜废弃物的甲烷化潜能较低,只有35 mL·g-1(VS)左右。动力学参数拟合表明:土豆和白菜废弃物厌氧发酵水解、酸化、乙酸化和甲烷化各过程转化速率都明显高于其他废弃物,并且各过程最大转化潜能也较其他类蔬菜高出2倍之多。厌氧发酵限制性步骤分析表明,快速水解生成的SCOD不能有效地转化为VFAs,限制了白菜废弃物厌氧消化的后续转化,而VFAs的累积则是胡萝卜、黄瓜和土豆废弃物厌氧发酵的限制性步骤, SCOD以及VFAs同时累积是茄子废弃物发酵过程的显著特征。对各物质发酵过程物质转化特征分析表明,各废弃物由于4 d以后甲烷菌对乙酸的利用减慢,导致丙酸向乙酸的转化减慢而发生累积现象,10 d以后由于产酸过程的减弱,累积的丙酸盐逐渐转化。Abstract: Vegetable wastes are the promising source for methane fermentation. The aim of this present study to examine the biogas production by using five common vegetable wastes by batch test. Furthermore, the rate-limiting step and the characteristics of substance transform during methane fermentation were further analyzed. Results revealed that the cumulative methane production of five vegetable wastes evidently increased rapidly within 10 days. However, the highest methane production was obtained by potato and Chinese cabbage wastes,which were 102 mL·g-1(VS) and 83 mL·g-1(VS), respectively. On the other hand, the lowest methane production was received by cucumber waste down to 35 mL·g-1(VS). Consequently, kinetics analysis exposed that the rates of hydrolysis, acidification, acetification and methanation of potato and Chinese cabbage were higher than other vegetable wastes, the maximum conversion potential of them in each stage of methane fermentation was twice as much as others. The results of the staged character analysis on the rate-limiting step showed that the SCOD from rapid hydrolysis of Chinese cabbage was not highly effective to convert in VFAs during fermentation stages, but the conversion of the accumulative VFAs to acetic acid was the rate-limiting step of carrot, potato and cucumber. Moreover, eggplant considerably enhanced the accumulation of SCOD and VFA at the same time were characterized. In addition, the result of the matter transformation characteristics analysis during methane fermentation indicated that propionic accumulation which was evidently observed after 4 days in each waste due to the descent of the conversion rate of acitic acid to methane, after 10 days, the accumulated propionate content which was gradually degraded because of the reduction in acidogenesis process.
-
-
[1] 刘广民, 董永亮, 薛建良, 等.果蔬废弃物厌氧消化特征及固体减量研究[J].环境科学与技术, 2009,32(3):27-30 [2] VITURTIA A M, MATA-ALVAREZ J, CECCHI F, et al.Two-phase anaerobic digestion of a mixture of fruit and vegetable wastes[J].Biological Wastes,1989,9(3):189-199 [3] 刘芳, 邱凌, 李自林,等.蔬菜废弃物厌氧发酵产气特性[J].西北农业学报,2013,2(10):162-170 [4] BOUALLAGUI H, TOUHAMI Y, CHEIKH R B, et al.Bioreactor performance in anaerobic digestion of fruit and vegetable wastes[J].Process Biochemistry,2005,0(3):989-995 [5] 王清艺, 贺延龄, 杨树成,等.果汁生产废弃烂果的产甲烷能力及厌氧消化影响因素研究[J].中国沼气,2015,3(6):3-7 [6] 张艳, 汪建旭, 冯炜弘,等.娃娃菜废弃物厌氧发酵制取沼气的小试和中试[J].中国沼气,2015,3(5):54-59 [7] 刘荣厚, 王远远, 孙辰,等.蔬菜废弃物厌氧发酵制取沼气的试验研究[J].农业工程学报,2008,4(4):209-213 [8] 尹燕, 王兴田, 杨道兰,等.沼液预处理对花椰菜废弃物厌氧消化的影响[J].中国农机化学报,2017,8(2):114-119 [9] 于蕾, 江皓, 钱名宇, 等.沼气工程厌氧发酵过程的监测与控制[J].中国沼气, 2014,2(6):59-64 [10] 王远远.蔬菜废弃物沼气发酵工艺条件及沼气发酵残余物综合利用技术的研究[D].上海:上海交通大学, 2008 [11] 韩丽.餐厨垃圾与污泥混合发酵工艺优化控制技术研究[D].天津:天津大学, 2014 [12] 鲍瑞靖.核苷酸厂废水污泥甲烷化预处理及水解酸化研究[D].广州:华南理工大学, 2012 [13] LI Q, QIAO W, WANG X, et al.Kinetic characterization of thermophilic and mesophilic anaerobic digestion for coffee grounds and waste activated sludge[J].Waste Management,2015,6:77-85 [14] LAY J J, NOIKE T, LI Y Y.Mathematical model for methane production from landfill bioreactor[J].Journal of Environmental Engineering,1998,4:730-736 [15] 秦佳佳, 李轶冰, 杨改河, 等.人粪与不同原料配比对厌氧发酵产气影响[J].农业环境科学学报, 2010,9(3):571-577 [16] QIAN L, WEI Q, WANG X, et al.Kinetic characterization of thermophilic and mesophilic anaerobic digestion for coffee grounds and waste activated sludge[J].Waste Management, 2015,6:77-85 [17] 李鹏飞.中草药残渣好氧厌氧耦合发酵产甲烷特性[D].哈尔滨:东北农业大学, 2015 [18] 张玉静.餐厨垃圾厌氧水解产挥发性脂肪酸技术研究[D].北京:清华大学, 2013 [19] 孟旭升.零价铁强化厌氧丙酸转化乙酸过程的研究[D].大连:大连理工大学, 2013 [20] 黄国正, 郝小旋, 张姣, 等.污泥厌氧发酵液燃料电池的性能及电子供体分析[J].中国环境科学, 2015,5(12):3595-3601 [21] 郑福生, 郑淑文.碱度对厌氧体系的影响分析[J].中国高新技术企业, 2008(10):65 [22] BOUALLAGUI H, CHEIKH R B, MAROUANI L, et al.Mesophilic biogas production from fruit andvegetable waste in a tubular digester[J].Bioresource Technology, 2003,6(1):85-89 -
点击查看大图
计量
- 文章访问数: 3188
- HTML全文浏览数: 2772
- PDF下载数: 574
- 施引文献: 0
下载:
