高级搜索

铁氧体法处理锂电池废液及其产物臭氧催化性能

,  ,  ,  ,  , 

downloadPDF

上一篇

下一篇

陈思锦, 顾卫星, 周品, 沈棒, 徐波, 孙同华. 铁氧体法处理锂电池废液及其产物臭氧催化性能[J]. 环境工程学报, 2018, 12(1): 265-271. doi: 10.12030/j.cjee.201703186
引用本文: 陈思锦, 顾卫星, 周品, 沈棒, 徐波, 孙同华. 铁氧体法处理锂电池废液及其产物臭氧催化性能[J]. 环境工程学报, 2018, 12(1): 265-271. doi: 10.12030/j.cjee.201703186
shu
CHEN Sijin, GU Weixing, ZHOU Pin, SHENG Bang, XU Bo, SUN Tonghua. Ferrite process disposing lithium ion battery wastewater and ozone catalytic performance of as-prepared ferrites[J]. Chinese Journal of Environmental Engineering, 2018, 12(1): 265-271. doi: 10.12030/j.cjee.201703186
Citation: CHEN Sijin, GU Weixing, ZHOU Pin, SHENG Bang, XU Bo, SUN Tonghua. Ferrite process disposing lithium ion battery wastewater and ozone catalytic performance of as-prepared ferrites[J]. Chinese Journal of Environmental Engineering, 2018, 12(1): 265-271. doi: 10.12030/j.cjee.201703186
shu

铁氧体法处理锂电池废液及其产物臭氧催化性能

  • 1.

    上海交通大学环境科学与工程学院,上海 200240

  • 2.

    上海巨浪环保有限公司,上海 201711

  • 基金项目:

    上海张江国家自主创新示范区专项发展资金重点项目(201505-QP-B108-006)

    国家自然科学基金资助项目(21377083)

Ferrite process disposing lithium ion battery wastewater and ozone catalytic performance of as-prepared ferrites

  • 1.

    School of Environmental Science and Engineering, Shanghai Jiao Tong University, Shanghai 200240, China

  • 2.

    Shanghai Julang Protecting Environment Co.Ltd., Shanghai 201711, China

  • Fund Project:

  • 摘要: 利用共沉淀法将锂电池废液中的有价金属(Me:Co、Ni、Mn)固定在铁氧体晶格中,得到一种掺杂钴镍锰的铁氧体,不仅可以去除废液中的金属污染物,还可作为理想的臭氧氧化催化剂。研究表明,在T=90 ℃,Fe/Me(摩尔比)=20的条件下,掺杂钴、镍的铁氧体最佳pH为9,掺杂锰的铁氧体最佳pH为11。进一步分析了在不同pH条件下,铁氧体形成α-Fe2O3、γ-Fe2O3、Fe3O4 3种晶型的原因并探讨钴镍锰掺杂的铁氧体对臭氧催化降解苯酚效率的影响。
    Abstract: The coprecipitation process was involved in fixing valuable metals Co/Ni/Mn from the spent lithium ion batteries (LIBs) wastewater into ferrites crystal lattice, obtaining a Co/Ni/Mn doped ferrite which not only realize the goal of removing valuable metals from LIBs wastewater but also could be a distinguished ozone oxidation catalyst. The results showed that when the molar ratio of Fe/valuable metals was 20 and temperature of solutions reached at 90 ℃, the optimum pH of Co/Ni doped ferrites was 9 while the optimum pH of Mn doped ferrites was 11. Moreover, the formations of α-Fe2O3, γ-Fe2O3, Fe3O4 in different pH conditions were discussed and the reasons of a higher catalytic degradation speed after adding valuable metals doped ferrites were analyzed.
  • 加载中
  • [1] 周品, 沈棒, 张宏波,等.利用废旧三元锂电池制备δ-MnO2及其催化氧化甲苯的性能研究[C]//中国环境科学学会.中国环境科学学会学术年会论文集.海南,2016:3931-3936
    [2] 王玲, 李平, 范丽珍,等.废旧锂离子电池回收再利用研究进展[J].电源技术,2015,39(6):1315-1318
    [3] 姚璐.废旧锂离子电池正极材料回收再利用研究[D].新乡:河南师范大学,2016
    [4] 倪婷, 李良超, 孙代红.铁氧体-共沉淀法处理工业废水的模拟研究[J].华中师范大学学报(自然科学版),2014,48(2):228-232
    [5] 许会道.以废旧电池为原料制备钴镍铁氧体的研究[D].新乡:河南师范大学,2015
    [6] HUANG S Q, GU L, ZHU N W, et al.Heavy metal recovery from electroplating wastewater by synthesis of mixed-Fe3O4@SiO2/metal oxide magnetite photocatalysts[J].Green Chemistry,2014,16:2696-2705
    [7] REN Y M, DONG Q, FENG J,et al.Magnetic porous ferrospinel NiFe2O4:A novel ozonation catalyst with strong catalytic property for degradation of di-nbutyl phthalate and convenient separation from water[J].Journal of Colloid and Interface Science,2012,382:90-96
    [8] 操时荣.铁系氧化物催化臭氧化降解模拟苯酚废水的研究[D].杭州: 浙江工业大学,2015
    [9] 陈俊明.湿法制备铁氧体磁粉的新途径[M].北京:国防工业出版社,2001:5-7
    [10] HUANG Y F, HAN G H, LIU J T, et al.A stepwise recovery of metals from hydrid cathodes of spent Li-ion batteries with leaching-flotation-precipitation process[J].Jounal of Power Sources,2016,325:555-564
    [11] 洪浩峰, 潘湛昌, 许磊,等.臭氧催化氧化处理苯酚废水研究[J].环境科学与技术,2010,33(6E):301-304
    [12] LU A H, HU C, NIE Y L, et al.Catalytic ozonation of toxic pollutants over magnetic cobalt-doped Fe3O4 suspensions[J].Applied Catalysis B: Environmental,2012,118:246-252
    [13] REN Y M, DONG Q, FENG J, et al.Magnetic porous ferrospinel NiFe2O4: A novel ozonation catalyst with strong catalytic property for degradation of di-n-butyl phthalate and convenient separation from water[J].Journal of Colloid and Interface Science,2012,382:90-96
    [14] CHEN J, WEN W J, KONG L J, et al.Magnetically separable and durable MnFe2O4 for efficient catalytic ozonation of organic pollutants[J].Industrial & Engineering Chemistry Research,2014,3:6297-6306
    [15] SHAHAMAT Y D, FARZADKIA M, NASSERI S, et al.A stepwise recovery of metals from hybrid cathodes of spent Li-ion batteries with leaching-flotation-precipitation process[J].Journal of Environmental Health Science and Engineering,2014,12:50-62
    [16] 周明华, 吴祖成, 汪大翚.不同电催化工艺下苯酚的降解特性[J].高等学校化学报,2003,24(9):1637-1641
    [17] 张轶, 黄若男, 王晓敏,等.TiO2光催化联合技术降解苯酚机制及动力学[J].环境科学,2013,34(2):596-603
  • 加载中
WeChat 点击查看大图
计量
  • 文章访问数:  2585
  • HTML全文浏览数:  2294
  • PDF下载数:  498
  • 施引文献:  0
出版历程
  • 刊出日期:  2018-01-14
陈思锦, 顾卫星, 周品, 沈棒, 徐波, 孙同华. 铁氧体法处理锂电池废液及其产物臭氧催化性能[J]. 环境工程学报, 2018, 12(1): 265-271. doi: 10.12030/j.cjee.201703186
引用本文: 陈思锦, 顾卫星, 周品, 沈棒, 徐波, 孙同华. 铁氧体法处理锂电池废液及其产物臭氧催化性能[J]. 环境工程学报, 2018, 12(1): 265-271. doi: 10.12030/j.cjee.201703186
shu
CHEN Sijin, GU Weixing, ZHOU Pin, SHENG Bang, XU Bo, SUN Tonghua. Ferrite process disposing lithium ion battery wastewater and ozone catalytic performance of as-prepared ferrites[J]. Chinese Journal of Environmental Engineering, 2018, 12(1): 265-271. doi: 10.12030/j.cjee.201703186
Citation: CHEN Sijin, GU Weixing, ZHOU Pin, SHENG Bang, XU Bo, SUN Tonghua. Ferrite process disposing lithium ion battery wastewater and ozone catalytic performance of as-prepared ferrites[J]. Chinese Journal of Environmental Engineering, 2018, 12(1): 265-271. doi: 10.12030/j.cjee.201703186
shu

铁氧体法处理锂电池废液及其产物臭氧催化性能

  • 1. 上海交通大学环境科学与工程学院,上海 200240
  • 2. 上海巨浪环保有限公司,上海 201711
基金项目:

上海张江国家自主创新示范区专项发展资金重点项目(201505-QP-B108-006)

国家自然科学基金资助项目(21377083)

摘要: 利用共沉淀法将锂电池废液中的有价金属(Me:Co、Ni、Mn)固定在铁氧体晶格中,得到一种掺杂钴镍锰的铁氧体,不仅可以去除废液中的金属污染物,还可作为理想的臭氧氧化催化剂。研究表明,在T=90 ℃,Fe/Me(摩尔比)=20的条件下,掺杂钴、镍的铁氧体最佳pH为9,掺杂锰的铁氧体最佳pH为11。进一步分析了在不同pH条件下,铁氧体形成α-Fe2O3、γ-Fe2O3、Fe3O4 3种晶型的原因并探讨钴镍锰掺杂的铁氧体对臭氧催化降解苯酚效率的影响。

English Abstract

参考文献 (17)

返回顶部

目录

/

返回文章
返回

Copyright © 2019 中国科学院生态环境研究中心