高级搜索

基于内循环微电解的焦化污水深度处理

,  ,  ,  , 

downloadPDF

上一篇

下一篇

张雷, 韩严和, 刘美丽, 张晓飞, 王敬贤. 基于内循环微电解的焦化污水深度处理[J]. 环境工程学报, 2018, 12(5): 1462-1470. doi: 10.12030/j.cjee.201710103
引用本文: 张雷, 韩严和, 刘美丽, 张晓飞, 王敬贤. 基于内循环微电解的焦化污水深度处理[J]. 环境工程学报, 2018, 12(5): 1462-1470. doi: 10.12030/j.cjee.201710103
shu
ZHANG Lei, HAN Yanhe, LIU Meili, ZHANG Xiaofei, WANG Jingxian. Advanced treatment of coking wastewater basing internal cycling micro-electrolysis technology[J]. Chinese Journal of Environmental Engineering, 2018, 12(5): 1462-1470. doi: 10.12030/j.cjee.201710103
Citation: ZHANG Lei, HAN Yanhe, LIU Meili, ZHANG Xiaofei, WANG Jingxian. Advanced treatment of coking wastewater basing internal cycling micro-electrolysis technology[J]. Chinese Journal of Environmental Engineering, 2018, 12(5): 1462-1470. doi: 10.12030/j.cjee.201710103
shu

基于内循环微电解的焦化污水深度处理

  • 1.

    北京石油化工学院环境工程系，北京 102617

  • 2.

    中国石油安全环保技术研究院，北京 102206

  • 3.

    北京农学院植物科学技术学院，农业应用新技术北京市重点实验室，北京 102206

  • 基金项目:

    国家自然科学基金资助项目(21677018)

Advanced treatment of coking wastewater basing internal cycling micro-electrolysis technology

  • 1.

    Department of Environmental Engineering, Beijing Institute of Petrochemical Technology, Beijing 102617,China

  • 2.

    China National Petroleum Corporation Research Institute of Safety & Environment Technology, Beijing 102206,China

  • 3.

    New Technological Key Laboratory of Agricultural Application in Beijing，College of Plant Science and Technology, Beijing University of Agricultural,Beijing 102206, China

  • Fund Project:

  • 摘要: 采用内循环微电解技术对某焦化厂生化混凝出水进行深度处理，以达到国家提标标准。通过单因素实验考察了pH、反应时间、曝气量和铁炭比对处理效果的影响，在此基础上，筛选出影响COD去除率的主控因子，并采用Box-Behnken响应曲面法对内循环微电解处理焦化污水的工艺条件进行优化，同时考察了各因素间的交互作用对COD去除率的影响。确定的最优运行参数为：pH 2.3、曝气量0.13 m3·h-1和铁炭比1:1。最优运行参数下的验证实验结果显示COD去除率和色度去除率分别达到67.77%和93.75%，当进水COD低于180 mg·L-1时，出水COD能够达到《炼焦化学工业污染物排放标准》（GB 16171-2012）直排标准。
    Abstract: In order to meet the new national standard, the internal cycling micro-electrolysis technology is adopted for treating the effluent from the flocculation sedimentation tank of coking plant. The effects of pH value, reaction time, aeration rate and iron-carbon ratio on the treatment performance were investigated by single-factor experiment. Based on the results obtained from the single-factor experiment, three main factors in terms of influencing COD removal rate were selected. Box-Behnken response surface method was used for optimizing the process conditions of the proposed treatment method, as well as, the interaction between any two factors was carried out. The optimal operating conditions were obtained, i.e., pH is 2.3, the aeration rate is 0.13 m3·h-1 and the iron/carbon ratio is 1:1. The COD removal efficiency and chroma removal rate under the optimal operating conditions were 67.77% and 93.75%, respectively. Therefore, when the inlet COD is lower than 180 mg·L-1, the effluent COD can meet the requirements of the first class of Coking Chemical Industry Pollutant Discharge Standard (GB16171-2012).
  • 加载中
  • [1] .JIN X W, LI E C, LU S G, et al.Coking wastewater treatment for industrial reuse purpose: Combining biological processes with ultrafiltration, nanofiltration and reverse osmosis[J].Journal of Environmental Sciences,2013,25(8):1565-1574 10.1016/S1001-0742(12)60212-5
    [2] . 环境保护部, 国家质量监督检验检疫总局. 炼焦化学工业污染物排放标准:GB 16171-2012[S]. 北京, 2012
    [3] .YING D W, PENG J, XU X Y, et al.Treatment of mature landfill leachate by internal micro-electrolysis integrated with coagulation: A comparative study on a novel sequencing batch reactor based on zero valentiron[J].Journal of Hazardous Materials,2012,229-230(5):426-433 10.1016/j.jhazmat.2012.06.037
    [4] . 李飞飞，李小明，曾光明. 铁炭微电解深度处理焦化废水的研究[J]. 工业用水与废水,2010,41(1):46-49
    [5] . 明云峰，姚立忱，刘伟.Fenton试剂-微电解处理焦化废水实验研究[J]. 工业水处理,2012,32(7):78-80
    [6] . 殷旭东，李德豪，毛玉凤，等.铁碳微电解/H2O2耦合类Fenton法预处理高浓度焦化废水[J]. 环境工程学报,2016,10(1):212-216
    [7] . 陈云云. 铁碳微电解法在制药废水预处理中的研究进展[J]. 能源环境保护,2015,29(2):51-53
    [8] .HAN Y H, LI H, LIU M L, et al.Purification treatment of dyes wastewater with a novel micro-electrolysis reactor[J].Separation and Purification Technology,2016,170:241-247 10.1016/j.seppur.2016.06.058
    [9] . 吕任生，贾尔恒·阿哈提，文方，等. 铁炭微电解-Fenton试剂法预处理半焦废水[J]. 环境工程学报,2013,7(11):4399-4404
    [10] . 赖鹏，赵华章，王超，等. 铁炭微电解深度处理焦化废水的研究[J]. 环境工程学报,2007,1(3):15-20
    [11] . 杨军，黄子宾，程振民. 低气液流速下三相固定床的传质特性[J]. 化学工程,2016,44(11):13-18 10.3969/j.issn.1005-9954.2016.11.003
    [12] .YANG L, TAN J, WANG K, et al.Mass transfer characteristics of bubbly flow in microchannels[J].Chemical Engineering Science,2014,109(16):306-314 10.1016/j.ces.2014.02.004
    [13] . 罗利佳. 内循环气升式反应器流动行为与传质特性研究[D]. 上海：上海交通大学,2012
    [14] .HUANG Q S, YANG C, YU G Z, et al.CFD simulation of hydrodynamics and mass transfer in an internal airlift loop reactor using a steady two-fluid model[J].Chemical Engineering Science,2010,65(20):5527-5536 10.1016/j.ces.2010.07.021
    [15] .SADEGHIZADEH A, RAHIMI R，FARHAD D F.Computational fluid dynamics modeling of carbon dioxide capture from air using biocatalyst in an airlift reactor[J].Bioresource Technology,2018,253:154-164 10.1016/j.biortech.2018.01.025
    [16] . 冯雅丽，张茜，李浩然，等. 铁炭微电解预处理高浓度高盐制药废水[J]. 环境工程学报,2012,6(11):3855-3860
    [17] .LIUWW, TUXY, WANGXP, et al.Pretreatment of coking wastewater by acid out, micro-electrolysis process with in situ electrochemical peroxidation reaction[J].Chemical Engineering Journal,2012,200-202(16):720-728 10.1016/j.cej.2012.06.057
    [18] . 宿程远，李伟光，王勇，等.Box-Behnken响应曲面优化铁炭微电解降解结晶紫[J]. 环境工程学报,2013,7(1):7-13
    [19] .ZHANGQ.Treatment of oilfield produced water using Fe/C micro-electrolysis assisted by zero-valent copper and zero-valentaluminium[J].Environmental Technology,2015,36(4):515-520 10.1080/09593330.2014.952678
    [20] .YANG Z M, MA Y P, LIU Y, et al.Degradation of organic pollutants in near-neutral pH solution by Fe-C micro-electrolysis system[J].Chemical Engineering Journal,2017,315:403-414 10.1016/j.cej.2017.01.042
  • 加载中
WeChat 点击查看大图
计量
  • 文章访问数:  2504
  • HTML全文浏览数:  2214
  • PDF下载数:  371
  • 施引文献:  0
出版历程
  • 刊出日期:  2018-05-19

基于内循环微电解的焦化污水深度处理

  • 1.  北京石油化工学院环境工程系，北京 102617
  • 2.  中国石油安全环保技术研究院，北京 102206
  • 3.  北京农学院植物科学技术学院，农业应用新技术北京市重点实验室，北京 102206
基金项目:

国家自然科学基金资助项目(21677018)

摘要: 采用内循环微电解技术对某焦化厂生化混凝出水进行深度处理，以达到国家提标标准。通过单因素实验考察了pH、反应时间、曝气量和铁炭比对处理效果的影响，在此基础上，筛选出影响COD去除率的主控因子，并采用Box-Behnken响应曲面法对内循环微电解处理焦化污水的工艺条件进行优化，同时考察了各因素间的交互作用对COD去除率的影响。确定的最优运行参数为：pH 2.3、曝气量0.13 m3·h-1和铁炭比1:1。最优运行参数下的验证实验结果显示COD去除率和色度去除率分别达到67.77%和93.75%，当进水COD低于180 mg·L-1时，出水COD能够达到《炼焦化学工业污染物排放标准》（GB 16171-2012）直排标准。

English Abstract

参考文献 (20)

目录

/

返回文章
返回

Copyright © 2019 中国科学院生态环境研究中心