高级搜索

工程规模下碱类型对污泥预处理效果及发酵产酸的影响

,  ,  ,  ,  , 

downloadPDF

上一篇

下一篇

张闻多, 余雷, 刘和, 符波, 郑志永, 刘宏波. 工程规模下碱类型对污泥预处理效果及发酵产酸的影响[J]. 环境工程学报, 2018, 12(5): 1517-1527. doi: 10.12030/j.cjee.201709102
引用本文: 张闻多, 余雷, 刘和, 符波, 郑志永, 刘宏波. 工程规模下碱类型对污泥预处理效果及发酵产酸的影响[J]. 环境工程学报, 2018, 12(5): 1517-1527. doi: 10.12030/j.cjee.201709102
shu
ZHANG Wenduo, YU Lei, LIU He, FU Bo, ZHENG Zhiyong, LIU Hongbo. Effect of alkali types on sludge pretreatment and its fermentation for acid production in industrial scale[J]. Chinese Journal of Environmental Engineering, 2018, 12(5): 1517-1527. doi: 10.12030/j.cjee.201709102
Citation: ZHANG Wenduo, YU Lei, LIU He, FU Bo, ZHENG Zhiyong, LIU Hongbo. Effect of alkali types on sludge pretreatment and its fermentation for acid production in industrial scale[J]. Chinese Journal of Environmental Engineering, 2018, 12(5): 1517-1527. doi: 10.12030/j.cjee.201709102
shu

工程规模下碱类型对污泥预处理效果及发酵产酸的影响

  • 1.

    江南大学环境与土木学院，无锡 214122

  • 2.

    江苏省厌氧生物技术重点实验室，无锡 214122

  • 3.

    江苏省水处理技术与材料协同创新中心，苏州215009

  • 基金项目:

    国家科技支撑计划课题（2014BAD24B03）

    江南大学自主科研计划重点项目（JUSRP51633B）

Effect of alkali types on sludge pretreatment and its fermentation for acid production in industrial scale

  • 1.

    School of Environmental and Civil Engineering, Jiangnan University, Wuxi 214122, China

  • 2.

    Jiangsu Key Laboratory of Anaerobic Biotechnology, Wuxi 214122, China

  • 3.

    Jiangsu Collaborative Innovation Center of Technology and Material of Water Treatment, Suzhou 215009, China

  • Fund Project:

  • 摘要: 研究了工程规模下3种碱对剩余污泥热碱预处理效果以及厌氧发酵产酸的影响。结果表明，平均进泥浓度为70 g·L-1时，氢氧化钠的预处理效果要优于混碱（Ca(OH)2：NaOH=4:1）和过氧化钙，处理后污泥中溶解性化学需氧量（SCOD）的平均浓度是预处理前的8.45倍，水解率达到64.26%。但是，使用过氧化钙进行预处理可以有效提高污泥的发酵产酸效果，产酸效率明显优于混碱和氢氧化钠，总挥发性脂肪酸（TVFAs）的平均浓度为7.93 g·L-1，产酸率（以COD计）为273.93 mg·g-1VSS，且总酸中乙酸比例达到60.35%；发酵后平均TSS和VSS分别下降了24.42%和47.62%；同时，氨氮（NH4+-N）和总磷（TP）浓度最低，其平均浓度分别为286.33 mg·L-1和17.42 mg·L-1。此外，混碱组、过氧化钙组和氢氧化钠组污泥厌氧发酵的净利润分别为229.14、257.37和10.49 元·t-1（脱水污泥）。实验结果表明，热混碱和热过氧化钙预处理用于污泥厌氧发酵有望得到广泛的应用。
    Abstract: Effects of alkali types on thermal-alkaline pretreatment of waste activated sludge and its anaerobic fermentation for volatile fatty acids (VFAs) production were studied. Results show that the efficiency of sludge pretreatment by NaOH with the average sludge concentration of 70 g·L-1 was higher than those of mixed alkali（Ca(OH)2:NaOH=4:1）and calcium peroxide (CaO2). The average concentration of soluble chemical oxygen demand (SCOD) after NaOH pretreatment was 8.45 times that before pretreatment, and the hydrolysis rate reached 64.26%. However, CaO2 pretreatment effectively improved the acid production of sludge fermentation, and its efficiency is obviously higher than those of mixed alkali and NaOH. The average concentrations of TVFAs in the CaO2 group was 7.93 g·L-1, and acid production rates (expressed with COD concentration) was 273.93 mg·g-1VSS. Meanwhile, the ratio of acetic acid in the TVFAs of CaO2 group was 60.35%, and the average total suspended solid (TSS) and volatile suspended solid (VSS) decreased by 24.42% and 47.62%, respectively. The concentrations of NH4+-N and TP in the CaO2 group were lowest with their average concentrations of 286.33 mg·L-1 and 17.42 mg·L-1, respectively. However, the economic feasibility comparison indicates heat-mixed alkali and heat-CaO2 pretreatments for sludge anaerobic fermentation are promising for widely application, with the net profits of 229.14, 257.37 and 10.49 yuan·t-1 dewatered sludge for the mixed alkali, CaO2 and NaOH treatment, respectively.
  • 加载中
  • [1] UCISIK A S, HENZE M.Biological hydrolysis and acidification of sludge under anaerobic conditions: The effect of sludge type and origin on the production and composition of volatile fatty acids[J].Water Research,2008,42(14):3729-3738 10.1016/j.watres. 2008.06.010
    [2] HWANG K Y, SHIN E B, CHOI H B.A mechanical pretreatment of waste activated sludge for improvement of anaerobic digestion system[J].Water Science and Technology,1997,36(12):111-116 10.1016/S0273-1223(97)00731-2
    [3] CLIMENT M, FERRER I, DEL M B M, et al.Effects of thermal and mechanical pretreatments of secondary sludge on biogas production under thermophilic conditions[J].Chemical Engineering Journal,2007,133(1):335-342 10.1016/j.cej.2007.02.020
    [4] GHAFARZADEH M, ABEDINI R, RAJABI R.Optimization of ultrasonic waves application in municipal wastewater sludge treatment using response surface method[J].Journal of Cleaner Production,2017,150:361-370 10.1016/j.jclepro.2017.02.159
    [5] YIN Y, LIU Y J, MENG S J, et al.Enzymatic pretreatment of activated sludge, food waste and their mixture for enhanced bioenergy recovery and waste volume reduction via anaerobic digestion[J].Applied Energy,2016,179:1131-1137 10.1016/j.apenergy. 2016.07.083
    [6] LEE W S, CHUA A S M, YEOH H K, et al.A review of the production and applications of waste-derived volatile fatty acids[J].Chemical Engineering Journal,2014,235:83-99 10.1016/j.cej.2013.09.002
    [7] KANG J H, KIM D, LEE T J.Hydrogen production and microbial diversity in sewage sludge fermentation preceded by heat and alkaline treatment[J].Bioresource Technology,2012,109:239-243 10.1016/j.biortech.2012.01.048
    [8] RANI R U, KUMAR S A, KALIAPPAN S, et al.Low temperature thermo-chemical pretreatment of dairy waste activated sludge for anaerobic digestion process[J].Bioresource Technology,2012,103(1):415-424 10.1016/j.biortech.2011.09.124
    [9] LI H, JIN Y Y, MAHAR R B, et al.Effects and model of alkaline waste activated sludge treatment[J].Bioresource Technology,2008,99(11):5140-5144 10.1016/j.biortech.2007.09.019
    [10] 肖本益，刘俊新. 污水处理系统剩余污泥碱处理融胞效果研究[J]. 环境科学,2006,27(2):319-323 10.3321/ j.issn:0250-3301.2006.02.024
    [11] ZHU Y F, LIU H B, LIU H, et al.Filtration characteristics of anaerobic fermented sewage sludge for fatty acids production[J].Separation and Purification Technology,2015,142:8-13 10.1016/j.seppur.2014.11.037
    [12] JIN B D, WANG S Y, XING L Q, et al.Long term effect of alkali types on waste activated sludge hydrolytic acidification and microbial community at low temperature[J].Bioresource Technology,2016,200:587-597 10.1016/j.biortech.2015.10.036
    [13] LI Y M, WANG J, ZHANG A, et al.Enhancing the quantity and quality of short-chain fatty acids production from waste activated sludge using CaO2 as an additive[J].Water Research,2015,83:84-93 10.1016/j.watres.2015.06.021
    [14] ZHANG A, WANG J, LI Y M.Performance of calcium peroxide for removal of endocrine-disrupting compounds in waste activated sludge and promotion of sludge solubilization[J].Water Research,2015,71:125-139 10.1016/j.watres.2015.01.005
    [15] 邱坚，刘和，许科伟，等. 调控pH促进污泥产酸及两相耦合系统定向产乙酸[J]. 中国给水排水,2009,25(13):1-6
    [16] 陈兴春，郑颖，刘宏波，等. 基于pH调控的城市污泥厌氧发酵产酸小试研究[J]. 环境科学学报,2015,35(4):1067-1073 10.13671/j.hjkxxb.2014.0805
    [17] 国家环境保护总局. 水和废水监测分析方法[M]. 4版. 北京:中国环境科学出版社,2002
    [18] DUBOIS M, GILLES K A, HAMILTON J K, et al.Colorimetric method for determination of sugars and related substances[J].Analytical Chemistry,1956,28(3):350-356 10.1021/ac60111a017
    [19] BRADFORD M M.A rapid and sensitive method for the quantitation of microgram quantities of protein utilizing the principle of protein-dye binding[J].Analytical Biochemistry,1976,72(1/2):248-254 10.1016/0003-2697(76)90527-3
    [20] CARRèRE H, DUMAS C, BATTIMELLI A, et al.Pretreatment methods to improve sludge anaerobic degradability: A review[J].Journal of Hazardous Materials,2010,183(1):1-15 10.1016/j.jhazmat.2010.06.129
    [21] SuArez-Iglesias O, Urrea J L, Oulego P, et al.Valuable compounds from sewage sludge by thermal hydrolysis and wet oxidation: A review[J].Science of the Total Environment,2017:921-934 10.1016/j.scitotenv.2017.01.140
    [22] STUCKEY D C, MCCARTY P L.The effect of thermal pretreatment on the anaerobic biodegradability and toxicity of waste activated sludge[J].Water Research, 1984,18(11):1343-1353 10.1016/0043-1354(84)90002-2
    [23] 李桂荣，李雪，许文峰，等. 污泥浓度对碱预处理剩余污泥水解产酸的影响[J]. 给水排水,2011,37(7):132-135 10.3969/j.issn.1002-8471.2011.07.036
    [24] LI X, CHEN H, HU L F, et al.Pilot-scale waste activated sludge alkaline fermentation, fermentation liquid separation, and application of fermentation liquid to improve biological nutrient removal[J].Environmental Science & Technology,2011,45(5):1834-1839 10.1021/es1031882
    [25] YIN B, LIU H B, WANG Y Y, et al.Improving volatile fatty acids production by exploiting the residual substrates in post-fermented sludge: Protease catalysis of refractory protein[J].Bioresource Technology,2016,203:124-131 10.1016/j.biortech.2015.12.029
    [26] ZHANG X, GU X G, LU S G, et al.Degradation of trichloroethylene in aqueous solution by calcium peroxide activated with ferrous ion[J].Journal of Hazardous Materials,2015,284:253-260 10.1016/j.jhazmat.2014.11.030
    [27] 白润英，陈湛，张伟军，等. 过氧化钙预处理对活性污泥脱水性能的影响机制[J]. 环境科学,2017,38(3):1151-1158
    [28] CHEN H B, WANG D B, LI X M, et al.Enhancement of post-anoxic denitrification for biological nutrient removal: Effect of different carbon sources[J].Environmental Science & Pollution Research,2015,22(8):5887-5894 10.1007/s11356-014-3755-1
    [29] CHEN Y G, JIANG S, YUAN H Y, et al.Hydrolysis and acidification of waste activated sludge at different pHs[J].Water Research,2007,41(3):683-689 10.1016/j.watres.2006.07.030
    [30] ELEFSINIOTIS P, WAREHAM D G, SMITH M O.Use of volatile fatty acids from an acid-phase digester for denitrification[J].Journal of Biotechnology,2004,114(3):289-297 114 289 297 10.1016/j.jbiotec.2004.02.016
    [31] WANG Y Y, ZHANG Y L, WANG J B, et al.Effects of volatile fatty acid concentrations on methane yield and methanogenic bacteria[J].Biomass and Bioenergy,2009,33(5):848-853 10.1016/j.biombioe.2009.01.007
    [32] 李淮，黄天寅，刘锋，等. 污泥厌氧发酵产酸中试反应器的启动研究[J]. 中国给水排水,2015,31(23):43-47
    [33] FENG L Y, CHEN Y G, ZHENG X.Enhancement of waste activated sludge protein conversion and volatile fatty acids accumulation during waste activated sludge anaerobic fermentation by carbohydrate substrate addition: The effect of pH[J].Environmental Science & Technology,2009,43(12):4373-4380 10.1021/es8037142
    [34] 刘刚，杜俊琪，童志勇，等. 羟基自由基活性氧用于中水处理[J]. 工业水处理,2009,29(3):81-83 10.3969/j.issn. 1005-829X.2009.03.025
    [35] 苏高强，王淑莹，郑冰玉，等. 温度和污泥浓度对碱性条件下剩余污泥水解酸化的影响[J]. 环境工程学报,2013,7(4):1231-1236
    [36] 熊鑫，柯凡，李勇，等. 过氧化钙对水中低浓度磷的去除性能[J]. 湖泊科学,2015,27(3):493-501
    [37] 罗哲, 周光杰, 刘宏波, 等. 污泥厌氧产酸发酵液作碳源强化污水脱氮除磷中试研究[J]. 环境科学,2015,36(3):1000-1005
  • 加载中
WeChat 点击查看大图
计量
  • 文章访问数:  1953
  • HTML全文浏览数:  1709
  • PDF下载数:  316
  • 施引文献:  0
出版历程
  • 刊出日期:  2018-05-19

工程规模下碱类型对污泥预处理效果及发酵产酸的影响

  • 1. 江南大学环境与土木学院，无锡 214122
  • 2. 江苏省厌氧生物技术重点实验室，无锡 214122
  • 3. 江苏省水处理技术与材料协同创新中心，苏州215009
基金项目:

国家科技支撑计划课题（2014BAD24B03）

江南大学自主科研计划重点项目（JUSRP51633B）

摘要: 研究了工程规模下3种碱对剩余污泥热碱预处理效果以及厌氧发酵产酸的影响。结果表明，平均进泥浓度为70 g·L-1时，氢氧化钠的预处理效果要优于混碱（Ca(OH)2：NaOH=4:1）和过氧化钙，处理后污泥中溶解性化学需氧量（SCOD）的平均浓度是预处理前的8.45倍，水解率达到64.26%。但是，使用过氧化钙进行预处理可以有效提高污泥的发酵产酸效果，产酸效率明显优于混碱和氢氧化钠，总挥发性脂肪酸（TVFAs）的平均浓度为7.93 g·L-1，产酸率（以COD计）为273.93 mg·g-1VSS，且总酸中乙酸比例达到60.35%；发酵后平均TSS和VSS分别下降了24.42%和47.62%；同时，氨氮（NH4+-N）和总磷（TP）浓度最低，其平均浓度分别为286.33 mg·L-1和17.42 mg·L-1。此外，混碱组、过氧化钙组和氢氧化钠组污泥厌氧发酵的净利润分别为229.14、257.37和10.49 元·t-1（脱水污泥）。实验结果表明，热混碱和热过氧化钙预处理用于污泥厌氧发酵有望得到广泛的应用。

English Abstract

参考文献 (37)

目录

/

返回文章
返回

Copyright © 2019 中国科学院生态环境研究中心