高级搜索

脉冲弧光放电等离子体水解活性污泥

,  ,  ,  ,  ,  ,  ,  , 

downloadPDF

上一篇

下一篇

曹颖, 姜楠, 段丽娟, 郭贺, 任景俞, 王璞, 周集体, 李杰, 吴彦. 脉冲弧光放电等离子体水解活性污泥[J]. 环境工程学报, 2018, 12(3): 956-965. doi: 10.12030/j.cjee.201709072
引用本文: 曹颖, 姜楠, 段丽娟, 郭贺, 任景俞, 王璞, 周集体, 李杰, 吴彦. 脉冲弧光放电等离子体水解活性污泥[J]. 环境工程学报, 2018, 12(3): 956-965. doi: 10.12030/j.cjee.201709072
shu
CAO Ying, JIANG Nan, DUAN Lijuan, GUO He, REN Jingyu, WANG Pu, ZHOU Jiti, LI Jie, WU Yan. Activated sludge hydrolysis by pulse arc discharge plasma[J]. Chinese Journal of Environmental Engineering, 2018, 12(3): 956-965. doi: 10.12030/j.cjee.201709072
Citation: CAO Ying, JIANG Nan, DUAN Lijuan, GUO He, REN Jingyu, WANG Pu, ZHOU Jiti, LI Jie, WU Yan. Activated sludge hydrolysis by pulse arc discharge plasma[J]. Chinese Journal of Environmental Engineering, 2018, 12(3): 956-965. doi: 10.12030/j.cjee.201709072
shu

脉冲弧光放电等离子体水解活性污泥

  • 1.

    大连理工大学环境学院，大连 116024

  • 2.

    大连理工大学电气工程学院，大连 116024

  • 基金项目:

    国家自然科学基金资助项目 （51477025）

Activated sludge hydrolysis by pulse arc discharge plasma

  • 1.

    School of Environment, Dalian University of Technology, Dalian 116024, China

  • 2.

    School of Electrical Engineering, Dalian University of Technology, Dalian 116024, China

  • Fund Project:

  • 摘要: 活性污泥水解对提高污泥的稳定性、缩短厌氧消化时间和增大甲烷产率具有重要意义。研究了脉冲弧光放电等离子体（PADP）水解活性污泥方法，考察水解效果、影响因素和水解后的污泥性状。结果表明：随着峰值电压、频率和电导率的增加，污泥上清液营养物质含量呈增长趋势，溶胞率（R）升高；随着放电时间的增加，R增加，氨氮物质（NH4+-N）先增加后降低，可证明NH4+-N降解率逐渐上升且最终高于其释放率；污泥在14 kV、25 Hz、1 600 μS·cm-1条件下放电150 min，R增加到51.3%，NH4+-N、蛋白质和多糖等有机物大量释放；经过PADP处理，污泥沉降性降低，絮凝体结构改变，含固量和颗粒尺寸降低，污泥生物大量死亡，水解污泥生物由光滑、完整的表面结构变得粗糙、破裂，细胞壁（膜）受损明显，污泥发生水解。
    Abstract: It is very significance of activated sludge hydrolysis for improving sludge stability, shortening the anaerobic digestion time and increasing methane yield. Pulsed arc discharge plasma (PADP) was utilized to investigate the hydrolysis effect, influence factor and character of hydrolyzed sludge. The results showed that higher peak voltage, frequency and conductivity enhanced sludge hydrolysis. With the increase of discharge time, lysis rate (R) increased, concentration of ammonia nitrogen (NH4+-N) increased first and then decreased, which could demonstrate that the degradation rate of NH4+-N increased gradually and it was higher than the release rate at last. R could reach approximately 51.3% under 14 kV peak voltage, 25 Hz frequency and 1 600 μS·cm-1 conductivity with 150 min treatment time. In addition, NH4+-N, protein, polysaccharide and other organic matters of sludge could release extensively. After PADP treatment, the settleability of sludge reduced, the structure of flocs changed, the content of solid and the particle size decreased, sludge biological component died in large numbers, the complete and smooth surface structure of organisms became rough and rupture, respectively. The cell wall (membrane) was damaged significantly, activated sludge was finally hydrolyzed.
  • 加载中
  • [1] MOWLA D, TRAN H N, ALLEN D G.A review of the properties of biosludge and its relevance to enhanced dewatering processes[J].Biomass & Bioenergy,2013,58(21):365-378 10.1016/j.biombioe.2013.09.002
    [2] XIANG Y, XIANG Y, WANG L.Cobalt-60 gamma-ray irradiation pretreatment and sludge protein for enhancing enzymatic saccharification of hybrid poplar sawdust[J].Bioresource Technology, 2016,221:9-14 10.1016/j.biortech.2016.09.032
    [3] RANI R U, KUMAR S, KALIAPPAN S, et al.Low temperature thermo-chemical pretreatment of dairy waste activated sludge for anaerobic digestion process[J].Bioresource Technology,2011,103(1): 415-424 10.1016/j.biortech.2011.09.124
    [4] BOUGRIER C, DELGENES J P,CARRERE H.Effects of thermal treatments on five different waste activated sludge samples solubilisation, physical properties and anaerobic digestion[J].Chemical Engineering Journal,2007,139(2):236-244 10.1016/j.cej.2007.07.099
    [5] NAH I W, KANG Y W, HWANG K Y, et al.Mechanical pretreatment of waste activated sludge for anaerobic digestion process[J].Water Research,2000,34(8):2362-2368 10.1016/S0043-1354(99)00361-9
    [6] APPELS L, HOUTMEYERS S, DEGREVE J, et al.Influence of microwave pre-treatment on sludge solubilization and pilot scale semi-continuous anaerobic digestion[J].Bioresource Technology,2012,128(1):598-603 10.1016/j.biortech.2012.11.007
    [7] DEVLIN D C, ESTEVES S R, DINSDALE R M, et al.The effect of acid pretreatment on the anaerobic digestion and dewatering of waste activated sludge[J].Bioresource Technology,2011,102(5):4076-4082 10.1016/j.biortech.2010.12.043
    [8] WAN J J, JING Y H, ZHANG S C, et al.Mesophilic and thermophilic alkaline fermentation of waste activated sludge for hydrogen production: Focusing on homoacetogenesis[J].Water Research,2016,102:524-532 10.1016/j.watres.2016.07.002
    [9] HASEGAWA S, SHIOTA N, KATSURA K, et al.Solubilization of organic sludge by thermophilic aerobic bacteria as a pretreatment for anaerobic digestion[J].Water Science & Technology,2000,41(3):163-169
    [10] SUN B M, YIN S E, GAO X D.Development prospects of non-thermal plasma technology used in the thermal power plants in China[C]//The American Society of Mechanical Engineers.International Conference on Energy Sustainability Collocated with the Heat Transfer and Interpack 2009 Conferences,2009:647-655
    [11] ZHANG H, ZHANG X D, WEI C C, et al.Microstructure characterization of microcrystalline silicon thin films deposited by very high frequency plasma-enhanced chemical vapor deposition by spectroscopic ellipsometry[J].Thin Solid Films,2011,520(2):861-865 10.1016/j.tsf.2011.04.166
    [12] WANG H J, GUO H, WU Q S, et al.Effect of activated carbon addition on H2O2 formation and dye decoloration in a pulsed discharge plasma system[J].Vacuum,2016,128:99-105 10.1016/j.vacuum.2016.03.015
    [13] GUO H, WANG H J, WU Q S, et al.Kinetic analysis of acid orange 7 degradation by pulsed discharge plasma combined with activated carbon and the synergistic mechanism exploration[J].Chemosphere,2016,159:221-227 10.1016/j.chemosphere.2016.05.092
    [14] CHOI H, JEONG S W, CHUNG Y J.Enhanced anaerobic gas production of waste activated sludge pretreated by pulse power technique[J].Bioresource Technology,2006,97(2):198-203 10.1016/j.biortech.2005.02.023
    [15] GAUNT L F, BEGGS C B, GEORGHIOU G E.Bactericidal action of the reactive species produced by gas-discharge nonthermal plasma at atmospheric pressure: A review[J].IEEE Transactions on Plasma Science,2006,34(4):1257-1269 10.1109/TPS.2006.878381
    [16] PIERCE B, MALOTT C, SAYLER G S, et al.Decontamination of media by a gaseous discharge at atmospheric pressure[C]//IEEE.IEEE Conference on Plasma Science,Anniverasy,1998
    [17] MORRISON G R.Microchemical determination of organic nitrogen with Nessler reagent[J].Analytical Biochemistry,1971,43(2):527-532 10.1016/0003-2697(71)90283-1
    [18] WEI Y J, LI K A, TONG S Y.A linear regression method for the study of the Coomassie brilliant blue protein assay[J].Talanta,1997,44(5):923-930 10.1016/S0039-9140(96)02140-6
    [19] FONG J, SCHAFFER F L, KIRK P L.The ultramicrodetermination of glycogen in liver：A comparison of the anthrone and reducing-sugar methods[J].Archives of Biochemistry & Biophysics,1953,45(2):319-326 10.1016/S0003-9861(53)80009-3
    [20] ASSOCIATION A P H.Standard methods for the examination of water and wastewater including bottom sediments and sludges[J].Journal of Clinical Laboratory Analysis,1967,53(3):361-386
    [21] DEVINS J C, RZAD S J, SCHWABE R J.Breakdown and prebreakdown phenomena in liquids[J].Journal of Applied Physics,1981,52(7):4531-4545 10.1063/1.329327
    [22] JONES H M, KUNHARDT E E.Development of pulsed dielectric breakdown in liquids[J].Journal of Physics D: Applied Physics,1995,28(1):178-188 10.1088/0022-3727/28/1/025
    [23] YU H, PERNI S, SHI J J, et al.Effects of cell surface loading and phase of growth in cold atmospheric gas plasma inactivation of Escherichia coli K12[J].Journal of Applied Microbiology,2006,101:1323-13300 10.1111/j.1365-2672.2006.03033.x
    [24] JIN Y, REN C S，XIU Z L，et al.Comparison of yeast inactivation treated in He, air and N2 DBD plasma[J].Plasma Science & Technology,2006,8(6):720-723 10.1088/1009-0630/8/6/21
    [25] VUKUSIC T, SHI M, HERCEG Z, et al.Liquid-phase electrical discharge plasmas with a silver electrode for inactivation of a pure culture of Escherichia coli in water[J].Innovative Food Science & Emerging Technologies,2016,38:407-413 10.1016/j.ifset.2016.07.007
    [26] LOCKE B R, SATO M, SUNKA P, et al.Electrohydraulic discharge and nonthermal plasma for water treatment[J].Industrial & Engineering Chemistry Research,2006,45(3):882-905 10.1021/ie050981u
    [27] SUAREZ-LGLESIAS O, URREA J L, OULEGO P, et al.Valuable compounds from sewage sludge by thermal hydrolysis and wet oxidation： A review[J].Science of the Total Environment,2017,584:921-934 10.1016/j.scitotenv.2017.01.140
    [28] ZHOU L F, HUANG B B, HUANG D W, et al.A feasible strategy for promoting activated sludge hydrolysis by using ironporphyrin modified Fe3O4 nanoparticles as an efficient biomimic catalyst[J].Chemical Engineering Journal,2015,280:248-255 10.1016/j.cej.2015.06.023
    [29] URREA J L, COLLADO S, LACA A, et al.Rheological behaviour of activated sludge treated by thermal hydrolysis[J].Journal of Water Process Engineering,2014,5:153-159 10.1016/j.jwpe.2014.06.009
    [30] XIN X D, HE J G, FENG J H, et al.Solubilization augmentation and bacterial community responses triggered by co-digestion of a hydrolytic enzymes blend for facilitating waste activated sludge hydrolysis process[J].Chemical Engineering Journal,2016,284:979-988 10.1016/j.cej.2015.09.060
    [31] LI D H, GANCZARCZYK J J.Structure of activated sludge flocs[J].Biotechnology & Bioengineering,1990,35(1):57-65
    [32] YANG S F, Li X Y.Influences of extracellular polymeric substances (EPS) on the characteristics of activated sludge under non-steady-state conditions[J].Process Biochemistry,2009,44(1):91-96 10.1016/j.procbio.2008.09.010
    [33] PAN X, LIU J, ZHANG D, et al.Binding of dicamba to soluble and bound extracellular polymeric substances (EPS) from aerobic activated sludge: A fluorescence quenching study[J].Journal of Colloid & Interface Science,2010,345(2):442-447 10.1016/j.jcis.2010.02.011
    [34] 王淑莹, 崔有为, 于德爽, 等. 无机盐对活性污泥沉降性的影响[J]. 环境工程, 2003, 21(5):7-9
    [35] PEYROUS R.The effect of relative humidity on ozone production by corona discharge in oxygen or air：A numerical simulation-Part I:oxygen[J].Ozone: Science & Engineering,1990,12(1):19-40 10.1080/01919519008552454
    [36] HOWARD D, STURTEVANT B.In vitro study of the mechanical effects of shock-wave lithotripsy[J].Ultrasound in Medicine & Biology,1997,23(7):1107-1122
    [37] WATTS R J, WASHINGTON D, HOWSAWKENG J, et al.Comparative toxicity of hydrogen peroxide, hydroxyl radicals, and superoxide anion to Escherichia coli[J].Advances in Environmental Research,2003,7(4):961-968 10.1016/S1093-0191(02)00100-4
  • 加载中
WeChat 点击查看大图
计量
  • 文章访问数:  2302
  • HTML全文浏览数:  2000
  • PDF下载数:  558
  • 施引文献:  0
出版历程
  • 刊出日期:  2018-03-22
曹颖, 姜楠, 段丽娟, 郭贺, 任景俞, 王璞, 周集体, 李杰, 吴彦. 脉冲弧光放电等离子体水解活性污泥[J]. 环境工程学报, 2018, 12(3): 956-965. doi: 10.12030/j.cjee.201709072
引用本文: 曹颖, 姜楠, 段丽娟, 郭贺, 任景俞, 王璞, 周集体, 李杰, 吴彦. 脉冲弧光放电等离子体水解活性污泥[J]. 环境工程学报, 2018, 12(3): 956-965. doi: 10.12030/j.cjee.201709072
shu
CAO Ying, JIANG Nan, DUAN Lijuan, GUO He, REN Jingyu, WANG Pu, ZHOU Jiti, LI Jie, WU Yan. Activated sludge hydrolysis by pulse arc discharge plasma[J]. Chinese Journal of Environmental Engineering, 2018, 12(3): 956-965. doi: 10.12030/j.cjee.201709072
Citation: CAO Ying, JIANG Nan, DUAN Lijuan, GUO He, REN Jingyu, WANG Pu, ZHOU Jiti, LI Jie, WU Yan. Activated sludge hydrolysis by pulse arc discharge plasma[J]. Chinese Journal of Environmental Engineering, 2018, 12(3): 956-965. doi: 10.12030/j.cjee.201709072
shu

脉冲弧光放电等离子体水解活性污泥

  • 1. 大连理工大学环境学院，大连 116024
  • 2. 大连理工大学电气工程学院，大连 116024
基金项目:

国家自然科学基金资助项目 （51477025）

摘要: 活性污泥水解对提高污泥的稳定性、缩短厌氧消化时间和增大甲烷产率具有重要意义。研究了脉冲弧光放电等离子体（PADP）水解活性污泥方法，考察水解效果、影响因素和水解后的污泥性状。结果表明：随着峰值电压、频率和电导率的增加，污泥上清液营养物质含量呈增长趋势，溶胞率（R）升高；随着放电时间的增加，R增加，氨氮物质（NH4+-N）先增加后降低，可证明NH4+-N降解率逐渐上升且最终高于其释放率；污泥在14 kV、25 Hz、1 600 μS·cm-1条件下放电150 min，R增加到51.3%，NH4+-N、蛋白质和多糖等有机物大量释放；经过PADP处理，污泥沉降性降低，絮凝体结构改变，含固量和颗粒尺寸降低，污泥生物大量死亡，水解污泥生物由光滑、完整的表面结构变得粗糙、破裂，细胞壁（膜）受损明显，污泥发生水解。

English Abstract

参考文献 (37)

返回顶部

目录

/

返回文章
返回

Copyright © 2019 中国科学院生态环境研究中心