高级搜索

Ag3PO4-MnO2/g-C3N4非均相臭氧催化对页岩气钻井废水的深度处理

,  ,  ,  ,  , 

downloadPDF

上一篇

下一篇

朱天菊, 陈春燕, 王兵, 任宏洋, 邹平, 向军. Ag3PO4-MnO2/g-C3N4非均相臭氧催化对页岩气钻井废水的深度处理[J]. 环境工程学报, 2018, 12(5): 1365-1371. doi: 10.12030/j.cjee.201709045
引用本文: 朱天菊, 陈春燕, 王兵, 任宏洋, 邹平, 向军. Ag3PO4-MnO2/g-C3N4非均相臭氧催化对页岩气钻井废水的深度处理[J]. 环境工程学报, 2018, 12(5): 1365-1371. doi: 10.12030/j.cjee.201709045
shu
ZHU Tianju, CHEN Chunyan, WANG Bing, REN Hongyang, ZOU Ping, XIANG Jun. Advanced treatment of shale gas drilling wastewater by heterogeneous ozone catalysis of Ag3PO4-MnO2/g-C3N4[J]. Chinese Journal of Environmental Engineering, 2018, 12(5): 1365-1371. doi: 10.12030/j.cjee.201709045
Citation: ZHU Tianju, CHEN Chunyan, WANG Bing, REN Hongyang, ZOU Ping, XIANG Jun. Advanced treatment of shale gas drilling wastewater by heterogeneous ozone catalysis of Ag3PO4-MnO2/g-C3N4[J]. Chinese Journal of Environmental Engineering, 2018, 12(5): 1365-1371. doi: 10.12030/j.cjee.201709045
shu

Ag3PO4-MnO2/g-C3N4非均相臭氧催化对页岩气钻井废水的深度处理

  • 1.

    西南石油大学化学化工学院，成都 610500

  • 基金项目:

    国家科技重大专项（2016ZX05062）

Advanced treatment of shale gas drilling wastewater by heterogeneous ozone catalysis of Ag3PO4-MnO2/g-C3N4

  • 1.

    College of Chemistry and Chemical Engineering, Southwest Petroleum University, Chengdu 610500, China

  • Fund Project:

  • 摘要: 采用热缩聚合成法、水热法制备Ag3PO4-MnO2/g-C3N4三元复合催化剂。利用XRD和SEM对其进行结构表征，并考察催化剂用量、废水pH、臭氧投加量等因素对页岩气钻井废水深度处理效果的影响。结果表明，Ag3PO4-MnO2/g-C3N4三元复合催化剂中，立方晶型Ag3PO4、纳米纤维状MnO2与经模板剂制得的管孔状g-C3N4成功复合，改变了其晶面的有序性并增大了比表面积。通过复合提高了Ag3PO4的稳定性及其与MnO2协同作用对臭氧的催化活性。在催化剂投加量为0.5 g·L-1，废水pH为11，臭氧投加量为3.2 mg·min-1，反应时间为40 min的条件下，对预处理后的页岩气钻井废水（COD含量为1 076 mg·L-1）COD的去除率为85.1%，该复合催化剂重复使用5次后仍保持良好的活性和稳定性。
    Abstract: The ternary catalyst Ag3PO4-MnO2/g-C3N4 was prepared by thermal polycondesation and hydrothermal synthesis. XRD and SEM investigated the structure characterization of the catalyst. The effects of catalyst dosage, pH of wastewater and ozone dosage on the advanced treatment of shale gas drilling wastewater were investigated. The results showed that the cubic crystal Ag3PO4 and the nano-fibri form of MnO2 were successfully attached to the tubular g-C3N4 prepared by the templates, which changed the orderliness of crystal surface and increased surface area of the catalyst. The stability of Ag3PO4 and the synergistic effect with MnO2 on the catalytic activity of ozone were improved. When the catalyst dosage was 0.5 g·L-1, pH 9.5 and the ozone dosage was 3.2 mg·min-1, the corresponding COD removing rate of pretreatment wastewater was 85.1% after 40 min reaction (the initial COD of wastewater was 1 076 mg·L-1), after 5 times used repeatedly, the catalyst still had good activity and stability.
  • 加载中
  • [1] 朱天菊, 王兵, 谢红丽, 等. 土著水生植物对页岩气钻井废水中Cu和Pb的去除及富集特征[J]. 环境科学研究,2017,30(3):478-483 10.13198/j.issn.1001-6929.2017.01.22
    [2] 张悦, 王兵, 任宏洋.O3/Mn2O3对钻井废水多相催化臭氧化试验研究[J]. 环境科学学报,2015,35(10):3185-3192 10.13671/j.hjkxxb.2015.0075
    [3] 王兵, 周鋆, 任宏洋,等.MgO催化臭氧氧化降解苯酚机理研究[J]. 环境科学学报,2016,36(11):4009-4016 10.13671/j.hjkxxb.2016.0038
    [4] 张国涛, 万新华, 李伟, 等. 微量臭氧催化氧化深度处理煤气化废水[J]. 环境工程学报,2013,7(1):263-267
    [5] 段菁溦. 臭氧催化氧化在难降解有机物深度处理中的应用研究[D]. 北京: 清华大学,2014
    [6] 姜传佳. 活性炭载锰-钯催化剂的制备及其催化分解臭氧性能研究[D]. 北京: 清华大学,2011
    [7] KUMAR N, KONOVA P, NAYDENOV A, et al.Ag-modified H-Beta, H-MCM-41 and SiO2 : Influence of support, acidity and Ag content in ozone decomposition at ambient temperature[J].Catalysis Today,2007,119(1):342-346 10.1016/j.cattod.2006.08.048
    [8] OYAMA S T, ZHANG W, HEISIG C.Decomposition of ozone using carbon-supported metal oxide catalysts[J].Applied Catalysis B: Environmental,1997,14(1):117-129 10.1016/S0926-3373(97)00017-9
    [9] 吴张雄. 新型碳基有序介孔材料的合成、功能化及性质与应用[D]. 上海:复旦大学, 2011
    [10] 赵珊珊. 基于g-C3N4或石墨烯的催化材料的制备及性能研究[D]. 大连: 大连理工大学, 2013
    [11] IKHLAQ A, BROWN D R, KASPRZYK-HORDERN B.Mechanisms of catalytic ozonation: An investigation into superoxide ion radical and hydrogen peroxide formation during catalytic ozonation on alumina and zeolites in water[J].Applied Catalysis B: Environmental,2013,129:437-449 10.1016/j.apcatb.2012.09.038
    [12] QI F, XU B, CHEN Z, et al.Catalytic ozonation of 2-isopropyl-3methoxypyrazine in water by γ-AlOOH and γ-Al2O3: Comparison of removalefficiency and mechanism[J].Chemical Engineering Journal,2013,219:527-536 10.1016/j.cej.2013.01.035
    [13] HUANG R H, LAN B Y, CHEN Z Y, et al.Catalytic ozonation of p-chlorobenzoic acid over MCM-41 and Fe loaded MCM-41[J].Chemical Engineering Journal,2012,180:19-24 10.1016/j.cej.2011.10.086
    [14] PUGAZHENTHIRAN N, SATHISHKUMAR P, MURUGESAN S, et al.Effective degradation of acid orange 10 by catalytic ozonation in the presence of Au-Bi2O3 nanoparticles[J].Chemical Engineering Journal,2011,168(3):1227-1233 10.1016/j.cej.2011.02.020
    [15] CHEN Y H, HSIEH D C, SHANG N C.Efficient mineralization of dimethyl phthalate by catalytic ozonation using TiO2/Al2O3 catalyst[J].Journal of Hazardous Materials,2011,192(3):1017-1025 10.1016/j.jhazmat.2011.06.005
    [16] LIU B, LI A M, XIA M F, et al.Preparation of manganese oxide oupported on activated carbon and its application in catalytic ozonation of 4-chlorophenol[J].Advanced Materials Research,2012,538-541:2285-2288 10.4028/www.scientific.net/AMR.538-541.2285
    [17] LI L S,YE W Y, ZHANG Q Y, et al.Catalytic ozonation of dimethyl phthalate over cerium supported on activated carbon[J].Journal of Hazardous Materials,2009,170(1):411-416 10.1016/j.jhazmat.2009.04.081
    [18] ZHAO L, MA J, SUN Z Z, et al.Catalytic ozonation for the degradation of nitrobenzene in aqueous solution by ceramic honeycomb-supported manganese[J].Applied Catalysis B: Environmental,2008,83(3):256-264 10.1016/j.apcatb.2008.02.009
    [19] DONG Y, YANG H, HE K, et al.Catalytic activity and stability of Y zeolite for phenol degradation in the presence of ozone[J].Applied Catalysis B: Environmental,2008,82(3/4):163-168 10.1016/j.apcatb.2008.01.023
    [20] ROSAL O, GONZALO M S, RODRíGUEZ A, et al.Catalytic ozonation of atrazine and linuron on MnOx/Al2O3 and MnOx/SBA-15 in a fixed bed reactor[J].Chemical Engineering Journal,2010,165(3):806-812 10.1016/j.cej.2010.10.020
    [21] ZHAI X, CHEN Z L, ZHAO S Q, et al.Enhanced ozonation of dichloroacetic acid in aqueous solution using nanometer ZnO powders[J].Journal of Environmental Sciences,2010,22(10):1527-1533 10.1016/S1001-0742(09)60284-9
    [22] 张鑫鑫,徐莉,李磊,等.微量Ag3PO4改性g-C3N4的可见光催化活性研究[J]. 河北科技大学学报,2015,36(3):255-262 10.7535/hbkd.2015yx03006
    [23] 陈路呀. 基于石墨烯或类石墨氮化碳光催化剂的制备、表征和及其光催化性能的研究[D]. 广州: 华南理工大学, 2014
    [24] 李军奇, 郭占云, 王德方, 等. 立方体形Ag3PO4可见光光催化剂的制备及其性能研究[J]. 陕西科技大学学报,2013,31(4):24-28
    [25] CHAI Y Y, WANG L, REN J, et al.A novel visible light-driven Ag3PO4/SBA-15 nanocomposite: Preparation and application in the photo-degradation of pollutants[J].Applied Surface Science,2015,324:212-220 10.1016/j.apsusc.2014.09.207
    [26] YAN S C, LI Z S, ZOU Z G.Photodegradation performance of g-C3N4 fabricated by directly heating melamine[J].Langmuir,2009,25(17):10397-10401 10.1021/la900923z
    [27] WANG X, CHEN X, THOMAS A, et al.Metal-containing carbon nitride compounds: A new functional organic–metal hybrid material[J].Advanced Materials,2010,21(16):1609-1612 10.1002/adma.200802627
    [28] 朱鹏飞, 万寅, 刘梅, 等. 可见光催化剂Ag3PO4/海泡石的制备及降解染料废水性能[J]. 安全与环境学报,2016,16(4):293-297
  • 加载中
WeChat 点击查看大图
计量
  • 文章访问数:  2691
  • HTML全文浏览数:  2268
  • PDF下载数:  401
  • 施引文献:  0
出版历程
  • 刊出日期:  2018-05-19

Ag3PO4-MnO2/g-C3N4非均相臭氧催化对页岩气钻井废水的深度处理

  • 1. 西南石油大学化学化工学院，成都 610500
基金项目:

国家科技重大专项（2016ZX05062）

摘要: 采用热缩聚合成法、水热法制备Ag3PO4-MnO2/g-C3N4三元复合催化剂。利用XRD和SEM对其进行结构表征，并考察催化剂用量、废水pH、臭氧投加量等因素对页岩气钻井废水深度处理效果的影响。结果表明，Ag3PO4-MnO2/g-C3N4三元复合催化剂中，立方晶型Ag3PO4、纳米纤维状MnO2与经模板剂制得的管孔状g-C3N4成功复合，改变了其晶面的有序性并增大了比表面积。通过复合提高了Ag3PO4的稳定性及其与MnO2协同作用对臭氧的催化活性。在催化剂投加量为0.5 g·L-1，废水pH为11，臭氧投加量为3.2 mg·min-1，反应时间为40 min的条件下，对预处理后的页岩气钻井废水（COD含量为1 076 mg·L-1）COD的去除率为85.1%，该复合催化剂重复使用5次后仍保持良好的活性和稳定性。

English Abstract

参考文献 (28)

目录

/

返回文章
返回

Copyright © 2019 中国科学院生态环境研究中心