高级搜索

叠式空气隙膜蒸馏组件膜污染实验研究

,  ,  , 

downloadPDF

上一篇

下一篇

杨晓宏, 田瑞, 马淑娟, 吕海莉. 叠式空气隙膜蒸馏组件膜污染实验研究[J]. 环境工程学报, 2013, 7(3): 963-968.
引用本文: 杨晓宏, 田瑞, 马淑娟, 吕海莉. 叠式空气隙膜蒸馏组件膜污染实验研究[J]. 环境工程学报, 2013, 7(3): 963-968.
shu
Yang Xiaohong, Tian Rui, Ma Shujuan, Lü Haili. Experimental study on membrane pollution of stacked air-gap membrane distillation module[J]. Chinese Journal of Environmental Engineering, 2013, 7(3): 963-968.
Citation: Yang Xiaohong, Tian Rui, Ma Shujuan, Lü Haili. Experimental study on membrane pollution of stacked air-gap membrane distillation module[J]. Chinese Journal of Environmental Engineering, 2013, 7(3): 963-968.
shu

叠式空气隙膜蒸馏组件膜污染实验研究

  • 1.

    内蒙古工业大学能源与动力工程学院,呼和浩特 010051

  • 2.

    内蒙古可再生能源重点实验室,呼和浩特 010051

  • 基金项目:

    国家自然科学基金资助项目(51266007)

    内蒙古重大自然科学基金资助项目(2010ZD09)

  • 中图分类号: TQ028.8

Experimental study on membrane pollution of stacked air-gap membrane distillation module

  • 1.

    College of Energy and Power Engineering, Inner Mongolia University of Technology, Hohhot 010051, China

  • 2.

    Renewable Energy Laboratory in Inner Mongolia, Hohhot 010051, China

  • Fund Project:

摘要

  • 摘要: 采用一种具有旋流结构的多层层叠式空气隙膜蒸馏膜组件,以20 g/L氯化钠盐水为热工质,考察在70℃条件下膜污染情况,实验结果表明,一个周期的连续运行和间歇性操作膜表面在高温下较快进入膜污染,8个周期后膜通量下降为初始通量的42%。膜表面有大量黄色附着物,电镜SEM分析显示,膜表面被不均匀堆积的颗粒状污染物及长方体结晶物覆盖,能谱EDS分析,污染物有极少量NaCl结晶的Na、Cl元素,还有O、C、Mg、Cu和Fe等元素。污染膜经5%盐酸溶液清洗后无机垢沉淀被去除,表观效果较好。
    Abstract: A stacked AGMD module with rotational flow structure was designed to investigate the membrane pollution situation, when the hot working medium was NaCl solution of 20 g/L and 70 ℃. The experimental results showed that membrane pollution appeared faster on membrane module under the high temperature condition in one experimental period of intermittent and continuous operation, after eight experimental periods, the flux dropped down to 42% of initial flux. The membrane surface was covered by a large number of yellow attachments. The SEM analysis showed that the yellow attachments were uneven accumulated granular pollutants and cuboid crystals. The EDS analysis showed that the pollutants had a minimum amount of Na and Cl element of NaCl crystallization, and also some O,C,Mg,Cu,Fe elements. The inorganic-scale precipitation on the fouling membrane can be wiped off with 5% hydrochloric acid solution, and the effect is good.
  • [1] Alklaibi A.M., Noam Lior. Membrane-distillation desalination:Status and potential. Desalination, 2005, 171(2): 111-131
    [2] Tomaszewska M., Mientka A.Separation of HCl from HCI-H2SO4 solutions by membrane distillation. Desalination, 2009,280(1-3):244-250
    [3] 唐娜,陈明玉,袁建军. 海水淡化浓盐水真空膜蒸馏研究. 膜科学与技术,2007,27(6):93-96 Tang Na, Chen Mingyu, Yuan Jianjun. Vacuum membrane distillation for brine from SWRO desalination process. Membrane Science and Technology,2007,27(6):93-96(in Chinese)
    [4] Marek Gryta.Fouling in direct contact membrane distillation process. Journal of Membrane Science, 2008, 325(1): 383-394
    [5] Mariah L.,Buckley C.A.,Brouckaert C.J.,et al. Membrane distillation of concentrated brines-Role of water activities in the evaluation of driving force. Journal of Membrane Science,2006,280(1-2):937-947
    [6] 环国兰,张宇峰,杜启云.膜污染分析与防治.水处理技术,2003,29(1):1-4 Huan Guolan,Zhang Yufeng,Du Qiyun.Membrane pollution analysis and control.Water Treatment Technology, 2003,29(1):1-4(in Chinese)
    [7] 杨久坡. 反渗透膜微生物污染特性及其控制研究. 邯郸:河北工程大学硕士论文,2007.1-5 Yang Jiupo.Study on the characteristics and control of membrane biofouling of RO. Handan: Master Dissertation of Hebei University of Engineering,2007.1-5 (in Chinese)
    [8] Hsu S.T.,Cheng K. T., Chou J. S.Seawater desalination by direct contact membrane distillation. Desalination, 2002, 143(3): 279-287
    [9] Chang I. S.Application of ceramic membrane as a pretreatment in anaerobic digestion of alcohol-distillery waste. Membrane science,1994,90(1-2):131-139
    [10] 付婉霞,李海俊,张璐璐.膜生物反应器中膜污染控制方法的研究. 环境工程,2004,22 (6):15-16 Fu Wanxia, Li Haijun, Zhang Lulu. Study on methods of preventing membrane fouling of membrane bioreactor.Environmental Engineering,2004,22(6):15-16(in Chinese)
    [11] Peter-Varbanets M., Hammes F., Vital M., et al. Stabilization of flux during dead-end ultra-low pressure ultrafiltration. Water Research, 2010, 44(12): 3607-3616
    [12] Marek Gryta .Fouling in direct contact membrane distillation process. Journal of Membrane Science, 2008,325(1):383-394
    [13] Koschikowskia J., Wieghausa M., Rommela M. Experimental investigations on solar driven stand-alone membrane distillation systems for remote areas. Desalination. 2009,248(1-3):125-131
    [14] Ding Z.,Liu L.,EI-bourawi M.S.,et al. Analysis of a solar-powered membrane distillation System. Desalination, 2005, 172(1):27-40
    [15] 贾立庄,杨晓宏,田瑞.新型多层并接式膜组件的设计研究. 膜科学与技术, 2011,31(1):10-16 Jia Lizhuang,Yang Xiaohong,Tian Rui. New multi parallel type membrane module design study. Membrane Science and Technology,2011,31(1) :10-16 (in Chinese)
    [16] 马素娟.层叠式膜组件PTFE膜渗透性能及膜污染实验研究. 呼和浩特:内蒙古工业大学硕士学位论文,2011.22-31 Ma Sujuan. Experimental study of PTFE membrane permeabil-ity and membrane fouling of layering module. Hohhot: Master Dissertation of Inner Mongolia University of Technology, 2011. 22-31(in Chinese)
    [17] 何铁锋.膜蒸馏系统传热传质过程优化实验研究. 呼和浩特:内蒙古工业大学硕士学位论文, 2009.25-28 He Tiefeng, Experimental Studies of the mass and heat transfer optimization of membrane distillation system. Hohhot: Master Dissertation of Inner Mongolia University of Technology, 2009.25-28(in Chinese)
  • 加载中
WeChat 点击查看大图
计量
  • 文章访问数:  1932
  • HTML全文浏览数:  982
  • PDF下载数:  1162
  • 施引文献:  0
出版历程
  • 收稿日期:  2012-12-29
  • 刊出日期:  2013-03-18
杨晓宏, 田瑞, 马淑娟, 吕海莉. 叠式空气隙膜蒸馏组件膜污染实验研究[J]. 环境工程学报, 2013, 7(3): 963-968.
引用本文: 杨晓宏, 田瑞, 马淑娟, 吕海莉. 叠式空气隙膜蒸馏组件膜污染实验研究[J]. 环境工程学报, 2013, 7(3): 963-968.
shu
Yang Xiaohong, Tian Rui, Ma Shujuan, Lü Haili. Experimental study on membrane pollution of stacked air-gap membrane distillation module[J]. Chinese Journal of Environmental Engineering, 2013, 7(3): 963-968.
Citation: Yang Xiaohong, Tian Rui, Ma Shujuan, Lü Haili. Experimental study on membrane pollution of stacked air-gap membrane distillation module[J]. Chinese Journal of Environmental Engineering, 2013, 7(3): 963-968.
shu

叠式空气隙膜蒸馏组件膜污染实验研究

  • 1.  内蒙古工业大学能源与动力工程学院,呼和浩特 010051
  • 2.  内蒙古可再生能源重点实验室,呼和浩特 010051
  • 收稿日期:  2012-12-29
基金项目:

国家自然科学基金资助项目(51266007)

内蒙古重大自然科学基金资助项目(2010ZD09)

摘要: 采用一种具有旋流结构的多层层叠式空气隙膜蒸馏膜组件,以20 g/L氯化钠盐水为热工质,考察在70℃条件下膜污染情况,实验结果表明,一个周期的连续运行和间歇性操作膜表面在高温下较快进入膜污染,8个周期后膜通量下降为初始通量的42%。膜表面有大量黄色附着物,电镜SEM分析显示,膜表面被不均匀堆积的颗粒状污染物及长方体结晶物覆盖,能谱EDS分析,污染物有极少量NaCl结晶的Na、Cl元素,还有O、C、Mg、Cu和Fe等元素。污染膜经5%盐酸溶液清洗后无机垢沉淀被去除,表观效果较好。

English Abstract

    全文HTML

参考文献 (17)

返回顶部

目录

/

返回文章
返回

Copyright © 2019 中国科学院生态环境研究中心