高级搜索

热电厂双膜法中水深度处理系统运行效果与问题分析

,  ,  ,  ,  ,  ,  , 

downloadPDF

上一篇

下一篇

王钢, 岳增刚, 郑利兵, 张春, 郁达伟, 夏森, 梁国良, 魏源送. 热电厂双膜法中水深度处理系统运行效果与问题分析[J]. 环境工程学报, 2019, 13(4): 773-783. doi: 10.12030/j.cjee.201812040
引用本文: 王钢, 岳增刚, 郑利兵, 张春, 郁达伟, 夏森, 梁国良, 魏源送. 热电厂双膜法中水深度处理系统运行效果与问题分析[J]. 环境工程学报, 2019, 13(4): 773-783. doi: 10.12030/j.cjee.201812040
shu
WANG Gang, YUE Zenggang, ZHENG Libing, ZHANG Chun, YU Dawei, XIA Sen, LIANG Guoliang, WEI Yuansong. Performance and limitations of a full-scale dual membrane process for advanced treatment and reuse of reclaimed water in a thermal power plant[J]. Chinese Journal of Environmental Engineering, 2019, 13(4): 773-783. doi: 10.12030/j.cjee.201812040
Citation: WANG Gang, YUE Zenggang, ZHENG Libing, ZHANG Chun, YU Dawei, XIA Sen, LIANG Guoliang, WEI Yuansong. Performance and limitations of a full-scale dual membrane process for advanced treatment and reuse of reclaimed water in a thermal power plant[J]. Chinese Journal of Environmental Engineering, 2019, 13(4): 773-783. doi: 10.12030/j.cjee.201812040
shu

热电厂双膜法中水深度处理系统运行效果与问题分析

  • 1.

    华能嘉祥发电有限公司，济宁 272400

  • 2.

    中国科学院生态环境研究中心，环境模拟与污染控制国家重点联合实验室，北京 100085

  • 3.

    中国科学院生态环境研究中心，水污染控制实验室，北京 100085

  • 4.

    华能济宁电厂，济宁 272121

  • 5.

    中国科学院大学，北京 100049

  • 基金项目:

    国家重点研发计划政府间国际科技创新合作重点专项2016YFE0118500

    江西省重点研发项目S2017ZPYFE0411国家重点研发计划政府间国际科技创新合作重点专项(2016YFE0118500)

    江西省重点研发项目(S2017ZPYFE0411)

Performance and limitations of a full-scale dual membrane process for advanced treatment and reuse of reclaimed water in a thermal power plant

  • 1.

    Huaneng Jiaxiang Power Generation Co.Ltd., Jining 272400, China

  • 2.

    State Key Joint Laboratory of Environment Simulation and Pollution Control, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China

  • 3.

    Laboratory of Water Pollution Control Technology, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China

  • 4.

    Huaneng Jining Power Generation Co.Ltd., Jining 272121, China

  • 5.

    University of Chinese Academy of Sciences, Beijing 100049, China* Correspording author, E-mail: lbzheng@rcees.ac.cn

  • Fund Project:

  • 摘要: 中水已成为热电厂的重要水源，其深度处理是影响电厂水处理系统的关键。为评估双膜法在电厂深度处理中的潜力与稳定性，考察了山东某热电厂石灰混凝-超滤(UF)-反渗透(RO)系统不同季节的处理效果及污染物去除特征与各工段贡献率。研究表明：双膜法对浊度、色度、电导、碱度、COD和TOC的去除率分别达95.82%、96.62%、96.73%、98.22%、96.42%和89.13%，在夏季严重膜污堵的条件下，也可保障产水达标，是一种有效的中水深度处理技术。预处理仅去除某些大分子腐殖酸类有机物、硬度类物质、悬浮物，富里酸类有机物、氮等其他溶解性物质主要由RO去除(去除率均60%)，因此，存在膜结垢和污堵的风险。不同季节污染物浓度变化不显著，但夏季高温条件下微生物代谢和繁殖速率较高，荧光指数(fluorescence index, FI)大于2，生物指数(biological index, BIX)为1.2左右，这是夏季膜污堵爆发的关键原因。
    Abstract: Reclaimed water has been an important water source in thermal power plant (TPP) and the advanced treatment was the key process for its TPP application. In order to evaluate the potential and stability of a dual membrane process for advanced treatment of reclaimed water in a thermal power plant, the treatment performance in different seasons, pollutant removal characteristic and contribution rate of each treatment unit were investigated for a full-scale lime coagulation- UF- RO process in a TPP in Shandong province. The results showed that the remove efficiencies of the dual-membrane system for turbidity, color, conductivity, alkalinity, COD and TOC were 95.82%, 96.62%, 96.73%, 98.22%, 96.42% and 89.13%, respectively. Even under the condition of severe membrane fouling during summer, its effluent still met the related standards, which indicated its effectivity on the advanced treatment of reclaimed water. The pretreatment units only removed some high molecular weight humic acids, hardness and suspending matters, while RO mainly removed fulvic acids, nitrogen and other dissolved matters with 60% removal efficiencies. Thus, this phenomenon would cause the risk for membrane scaling and fouling. The variations of pollutants concentration were not significant, but the high rates of microbe metabolism and propagation occurred in summer, which led to high microbe activity (FI>2, BIX≈1.2) in water. The corresponding biofouling is the key reason for the outbreak of membrane fouling.
  • 加载中
  • [1] 魏源送, 郑利, 张春, 等. 热电厂中水回用深度处理技术与国内应用进展[J]. 水资源保护, 2018, 34(6): 1-11.
    [2] 于海琴, 刘正修, 李进, 等. 火电厂中水回用RO膜污染特征研究[J]. 膜科学与技术, 2012, 32(3): 75-78.
    [3] 李倩, 汪后港, 于萍, 等. 超滤-反渗透双膜法用于中水回用的中试研究[J]. 膜科学与技术, 2013, 33(3): 88-91.
    [4] KENT F C, FARAHBAKHSH K, MAHENDRAN B, et al. Water reclamation using reverse osmosis: Analysis of fouling propagation given tertiary membrane filtration and MBR pretreatments[J]. Journal of Membrane Science, 2011, 382(1): 328-338.
    [5] GOOSEN M F A, SABLANI S S, ALHINAI H, et al. Fouling of reverse osmosis and ultrafiltration membranes: A critical review[J]. Separation Science and Technology, 2005, 39(10): 2261-2297.
    [6] 国家环境保护总局. 水和废水监测分析方法 [M]. 4版. 北京: 中国环境科学出版社, 2002.
    [7] YOU S H, TSENG D H, GUO G L. A case study on the wastewater reclamation and reuse in the semiconductor industry[J]. Resources, Conservation and Recycling, 2001, 32(1): 73-81.
    [8] LIU X, JUNGANG L, QIANYA Z, et al. The analysis and prediction of scale accumulation for water-injection pipelines in the Daqing Oilfield[J]. Journal of Petroleum Science and Engineering, 2009, 66(3): 161-164.
    [9] ZHENG L, YU D, WANG G, et al. Characteristics and formation mechanism of membrane fouling in a full-scale RO wastewater reclamation process: Membrane autopsy and fouling characterization[J]. Journal of Membrane Science, 2018, 563: 843-856.
    [10] BI R, LU Q, YUAN T, et al. Electrochemical and spectroscopic characteristics of dissolved organic matter in a forest soil profile[J]. Journal of Environmental Sciences, 2013, 25(10): 2093-2101.
    [11] KHAN M T, BUSCH M, MOLINA V G, et al. How different is the composition of the fouling layer of wastewater reuse and seawater desalination RO membranes?[J]. Water Research, 2014, 59: 271-282.
    [12] 高嵩, 于海琴, 陈福泰. 超滤用于钢铁厂污水回用的中试研究[J]. 环境工程学报, 2007, 1(2): 43-45.
    [13] TAN Y J, SUN L J, LI B T, et al. Fouling characteristics and fouling control of reverse osmosis membranes for desalination of dyeing wastewater with high chemical oxygen demand[J]. Desalination, 2017, 419: 1-7.
    [14] ZHANG W, CAO B, WANG D, et al. Influence of wastewater sludge treatment using combined peroxyacetic acid oxidation and inorganic coagulants re-flocculation on characteristics of extracellular polymeric substances (EPS)[J]. Water Research, 2016, 88: 728-739.
    [15] JEONG S, KIM S J, HEE K L, et al. Foulant analysis of a reverse osmosis membrane used pretreated seawater[J]. Journal of Membrane Science, 2013, 428: 434-444.
    [16] 张广彩, 王雅南, 常昕, 等. 应用多元统计研究蘑菇湖水体DOM紫外光谱特征[J]. 环境科学研究, 2018, 31(12): 1-10.
  • 加载中
WeChat 点击查看大图
计量
  • 文章访问数:  4931
  • HTML全文浏览数:  4694
  • PDF下载数:  226
  • 施引文献:  0
出版历程
  • 刊出日期:  2019-04-15

热电厂双膜法中水深度处理系统运行效果与问题分析

  • 1. 华能嘉祥发电有限公司，济宁 272400
  • 2. 中国科学院生态环境研究中心，环境模拟与污染控制国家重点联合实验室，北京 100085
  • 3. 中国科学院生态环境研究中心，水污染控制实验室，北京 100085
  • 4. 华能济宁电厂，济宁 272121
  • 5. 中国科学院大学，北京 100049
基金项目:

国家重点研发计划政府间国际科技创新合作重点专项2016YFE0118500

江西省重点研发项目S2017ZPYFE0411国家重点研发计划政府间国际科技创新合作重点专项(2016YFE0118500)

江西省重点研发项目(S2017ZPYFE0411)

摘要: 中水已成为热电厂的重要水源，其深度处理是影响电厂水处理系统的关键。为评估双膜法在电厂深度处理中的潜力与稳定性，考察了山东某热电厂石灰混凝-超滤(UF)-反渗透(RO)系统不同季节的处理效果及污染物去除特征与各工段贡献率。研究表明：双膜法对浊度、色度、电导、碱度、COD和TOC的去除率分别达95.82%、96.62%、96.73%、98.22%、96.42%和89.13%，在夏季严重膜污堵的条件下，也可保障产水达标，是一种有效的中水深度处理技术。预处理仅去除某些大分子腐殖酸类有机物、硬度类物质、悬浮物，富里酸类有机物、氮等其他溶解性物质主要由RO去除(去除率均60%)，因此，存在膜结垢和污堵的风险。不同季节污染物浓度变化不显著，但夏季高温条件下微生物代谢和繁殖速率较高，荧光指数(fluorescence index, FI)大于2，生物指数(biological index, BIX)为1.2左右，这是夏季膜污堵爆发的关键原因。

English Abstract

    全文HTML

参考文献 (16)

目录

/

返回文章
返回

Copyright © 2019 中国科学院生态环境研究中心