高级搜索

基于重金属提取的垃圾焚烧飞灰无害化处理

,  ,  ,  ,  , 

downloadPDF

上一篇

下一篇

林涛, 谢巧玲, 陈福明, 王丹丹, 杨波, 张淑然. 基于重金属提取的垃圾焚烧飞灰无害化处理[J]. 环境工程学报, 2018, 12(9): 2642-2649. doi: 10.12030/j.cjee.201804067
引用本文: 林涛, 谢巧玲, 陈福明, 王丹丹, 杨波, 张淑然. 基于重金属提取的垃圾焚烧飞灰无害化处理[J]. 环境工程学报, 2018, 12(9): 2642-2649. doi: 10.12030/j.cjee.201804067
shu
LIN Tao, XIE Qiaoling, CHEN Fuming, WANG Dandan, YANG Bo, ZHANG Shuran. Innocuous treatment of MSWI fly ash by heavy metal extraction[J]. Chinese Journal of Environmental Engineering, 2018, 12(9): 2642-2649. doi: 10.12030/j.cjee.201804067
Citation: LIN Tao, XIE Qiaoling, CHEN Fuming, WANG Dandan, YANG Bo, ZHANG Shuran. Innocuous treatment of MSWI fly ash by heavy metal extraction[J]. Chinese Journal of Environmental Engineering, 2018, 12(9): 2642-2649. doi: 10.12030/j.cjee.201804067
shu

基于重金属提取的垃圾焚烧飞灰无害化处理

  • 1.

    深圳大学化学与环境工程学院，深圳 518060

  • 2.

    深圳清华大学研究院，深圳 518057

  • 3.

    深圳市工业应用分离技术重点实验室，深圳 518057

  • 基金项目:

    深圳市科技研发基金资助项目（JCYJ20170307145847484）

Innocuous treatment of MSWI fly ash by heavy metal extraction

  • 1.

    College of Chemistry and Environmental Engineering, Shenzhen University, Shenzhen 518060, China

  • 2.

    Research Institute of Tsinghua University in Shenzhen, Shenzhen 518057, China

  • 3.

    Shenzhen Key Laboratory of Separation Technology, Shenzhen 518057, China

  • Fund Project:

  • 摘要: 采用加酸浸出工艺对垃圾焚烧飞灰进行无害化处理。研究证明盐酸能有效分离飞灰中重金属，重金属浸出率与盐酸浓度及液固比有关；重金属在实验的盐酸浓度和液固比下都能达到高浸出率，但液固比越低，浸出液中重金属的浓度就越高，越有利于重金属的回收。当盐酸浓度为5 mol·L-1、液固比为2（mL:g）时，Pb、Cd和Zn浸出率均达到95%以上，而Cu的浸出率也达到81.38%，Pb、Cd、Zn和Cu的浓度分别为468.10、78.12、2 268.80和347.78 mg·L-1。残灰采用加盐水洗工艺后，浸出毒性超标的重金属Pb和Cd浸出毒性低于GB 16889-2008标准限值，符合填埋要求。
    Abstract: A effective method of acid leaching for waste incineration fly ash harmless was applied in this study. Hydrochloric acid leaching was shown to be a more effective approach than sulfuric leaching and nitric acids leaching for heave metal separation from fly ash. Concentration of hydrochloric acid and solid/liquid ratio were the major factors influenced the heavy metal leaching, and a higher hydrochloric acid concentration and solid/liquid ratio can contribute to the enhancement of heavy metal leaching. The concentration of Pb, Cd, Zn and Cu in leachate was 468.10, 78.12, 2 268.80 and 347.78 mg·L-1 with the leaching rate of 99.30%, 99.03%, 97.75% and 81.38%, respectively, by using hydrochloric acid of 5 mol·L-1 and under the solid/liquid ratio of 2 (mL:g). The concentrations of heavy metals in residual ash were below the minimum requirements of the China national standard for landfill (GB 16889-2008).
  • 加载中
  • [1] 王春峰，陈冠飞.不同粒径垃圾焚烧飞灰重金属毒性浸出及生物可给性[J].环境科学,2016,37(12):4891-4898 10.13227/j.hjkx.201605141
    [2] 刘剑.我国垃圾焚烧发电项目的技术经济评价研究[D].长春：吉林大学,2013
    [3] 刘军伟，雷延宙，杨树华，等.浅议我国垃圾焚烧发电的现状及发展趋势[J].中外能源,2012,17(6):29-34
    [4] 邝薇，钟山，陈孟林，等.垃圾焚烧飞灰中重金属的污染特性[J].环境科学与技术,2012,35(8):143-148
    [5] SHI S H,KAB L L.Leaching behavior of heavy metals from municipal solid wastes incineration (MSWI) fly ash used in concrete[J].Joumal of Hazardous Materials,2009,164(2):750-754 10.1016/j.jhazmat.2008.08.077
    [6] RICHARD D A, SHINICHI M, NAOKI H, et al.Recovery of heavy metals from MSW molten fiy ash by carrier-in-pulp method: Fe powder as carrier[J].Minerals Engineering,2008,21(15):1094-1101 10.1016/j.mineng.2008.02.005
    [7] 罗忠涛，肖宇领，杨久俊，等.垃圾焚烧飞灰有毒重金属固化稳定技术研究综述[J].环境污染与防治,2012,34(8):58-68
    [8] LI W M, ZHANG F,DAMAN K, et al.Develpopment of low-carbon cementitious materials via carbonating Portland cement-fly ash-mangnesia blends under various curing scenarios: A comparative study[J].Journal of Cleaner Production,2017,163:252-261 10.1016/j.jclepro.2016.01.066
    [9] HOY M L,HORPIBULSUK S K,ARULRAGAH A.Strength development of recycled asphalt pavement-fly ash geopolymer as a road construction material[J].Construction and Building Materials ,2016,117:209-219 10.1016/j.conbuildmat.2016.04.136
    [10] 王金波,秦瑞香，袁茂林,等.2013.复合化学螯合药剂稳定垃圾焚烧飞灰中重金属[J].化学研究与应用,25(10):1397-1402
    [11] FEDJE K K, EKBERG C, SKARNEMARK G, et al.Removal of hazardous metals from MSW fly ash: An evalution of ash leaching methods[J].Journal of Hazardous Materials,2010,173:310-317 10.1016/j.jhazmat.2009.08.094
    [12] RAM L C,MASTO R E.Fly ash for soil amelioration:A review on the influence of ash blending with inorganic and organic amendments[J].Earth-Science Reviews,2014,128(1):52-74 10.1016/j.earscirev.2013.10.003
    [13] SCHINNER F,BURGSTALLER W G.Extraction of zinc from industrial waste by Penicillium sp[J].Applied and Environmental Microbiology,1989,55(5):1153-1156
    [14] MISHRA D,RDEE Y H.Microbial leaching of metals from solid industrial wastes[J].Journal of Microbioliogy,2014,52(1):1-7 10.1007/s12275-014-3532-3
    [15] BOOM A D,DEGREZ M.Combining sieving and washing,a way to treat MSWI boiler fly[J].Waste Management,2015,39: 179–188 10.1016/j.wasman.2015.01.040
    [16] 环境保护部.固体废物浸出毒性浸出方法 醋酸缓冲溶液法:HJ/T 300-2007[S].北京: 中国环境科学出版社,2007
    [17] TORO M A, CALMANO W, ECKE H.Wet extraction of heavy mentals and chloride from MSWI and straw combustion fly ashes[J].Waste Management,2009,29(9):2494-2499 10.1016/j.wasman.2009.04.013
    [18] 梁梅，黎小宝，刘海威，等.生活垃圾焚烧飞灰基本特性及稳定化研究[J].环境卫生工程,2014,22(3):1-3
    [19] 李瑞月，陈德，李恋卿，等.不同作物秸秆生物炭对溶液中Pb2+、Cd2+的吸附[J].农业环境科学学报,2015,35(5):1001-1008
    [20] 多丽娜，魏国侠，刘汉娇，等.铁浆法回收垃圾焚烧飞灰中重金属的实验研究[J].环境卫生工程,2013,21(4):1-4
  • 加载中
WeChat 点击查看大图
计量
  • 文章访问数:  2446
  • HTML全文浏览数:  2335
  • PDF下载数:  120
  • 施引文献:  0
出版历程
  • 刊出日期:  2018-09-20

基于重金属提取的垃圾焚烧飞灰无害化处理

  • 1. 深圳大学化学与环境工程学院，深圳 518060
  • 2. 深圳清华大学研究院，深圳 518057
  • 3. 深圳市工业应用分离技术重点实验室，深圳 518057
基金项目:

深圳市科技研发基金资助项目（JCYJ20170307145847484）

摘要: 采用加酸浸出工艺对垃圾焚烧飞灰进行无害化处理。研究证明盐酸能有效分离飞灰中重金属，重金属浸出率与盐酸浓度及液固比有关；重金属在实验的盐酸浓度和液固比下都能达到高浸出率，但液固比越低，浸出液中重金属的浓度就越高，越有利于重金属的回收。当盐酸浓度为5 mol·L-1、液固比为2（mL:g）时，Pb、Cd和Zn浸出率均达到95%以上，而Cu的浸出率也达到81.38%，Pb、Cd、Zn和Cu的浓度分别为468.10、78.12、2 268.80和347.78 mg·L-1。残灰采用加盐水洗工艺后，浸出毒性超标的重金属Pb和Cd浸出毒性低于GB 16889-2008标准限值，符合填埋要求。

English Abstract

参考文献 (20)

目录

/

返回文章
返回

Copyright © 2019 中国科学院生态环境研究中心