高级搜索

油田油泥与煤在流化床中的混烧

,  ,  ,  ,  ,  , 

downloadPDF

上一篇

下一篇

林炳丞, 吴平, 吴丽萍, 林诚乾, 欧阳璐, 张琦, 黄群星. 油田油泥与煤在流化床中的混烧[J]. 环境工程学报, 2018, 12(4): 1237-1245. doi: 10.12030/j.cjee.201710057
引用本文: 林炳丞, 吴平, 吴丽萍, 林诚乾, 欧阳璐, 张琦, 黄群星. 油田油泥与煤在流化床中的混烧[J]. 环境工程学报, 2018, 12(4): 1237-1245. doi: 10.12030/j.cjee.201710057
shu
LIN Bingcheng, WU Ping, WU Liping, LIN Chengqian, OUYANG Lu, ZHANG Qi, HUANG Qunxing. Co-combustion of oily sludge and coal in fluidized bed[J]. Chinese Journal of Environmental Engineering, 2018, 12(4): 1237-1245. doi: 10.12030/j.cjee.201710057
Citation: LIN Bingcheng, WU Ping, WU Liping, LIN Chengqian, OUYANG Lu, ZHANG Qi, HUANG Qunxing. Co-combustion of oily sludge and coal in fluidized bed[J]. Chinese Journal of Environmental Engineering, 2018, 12(4): 1237-1245. doi: 10.12030/j.cjee.201710057
shu

油田油泥与煤在流化床中的混烧

  • 1.

    浙江大学热能工程研究所，能源清洁利用国家重点实验室，杭州 310027

  • 2.

    新疆宇澄热力股份有限公司，克拉玛依 834000

  • 3.

    浙江物华天宝能源环保有限公司，杭州 310007

  • 基金项目:

    克拉玛依市科技计划项目（sk2016-34）

Co-combustion of oily sludge and coal in fluidized bed

  • 1.

    State Key Laboratory of Clean Energy Utilization, Institute for Thermal Power Engineering, Zhejiang University, Hangzhou 310027, China

  • 2.

    Xinjiang Yucheng Heat Power Co.Ltd., Kelamayi 834000, China

  • 3.

    Zhejiang Best Energy and Environment Co.Ltd., Hangzhou 310007, China

  • Fund Project:

  • 摘要: 基于小型流化床焚烧实验平台，通过含油污泥与煤混合燃烧，分析气体污染物排放浓度以及灰渣特性。含油污泥与煤混烧后NOx、SO2的排放浓度均低于危险废物焚烧排放标准。根据灰渣中组分分析，煤中碱金属化合物能抑制SO2的排放。渣样的浸出毒性均在标准范围内，灰样的浸出毒性高于渣样，主要因为飞灰中更容易富集挥发和易溶形态的重金属。基于小试实验的结果，油泥在小型流化床上的燃烧不充分导致了CO排放浓度较高，且灰的灼减率较高，因此，在后续中试以及示范工程中，应保证油泥的充分燃烧，为灰渣的综合利用提供理论基础。
    Abstract: The co-combustion experiment of oily sludge and coal was carried out on a lab-scale fluidized bed incineration test platform to investigate the emission of gas pollutants and the characteristics of ash and residue. Results showed that the emission of NOx and SO2 was lower than the emission standards for hazardous waste incineration, which was due to the inhibition of SO2 emission by the alkali metal compounds in coal. The leaching toxicity of the residue was within the standard range. However, the leaching toxicity of the ash was higher than that of residue, due to the fact that the heavy metals in volatile and soluble forms were more likely to be concentrated in ash. The CO emission far exceeded the standard value and the ignition loss of ash was high, which was possibly attributed to the insufficient combustion of oily sludge in the lab-scale fluidized bed. Therefore, it is important to achieve the sufficient incineration of oily sludge in the subsequent pilot and demonstration projects. Results can provide theoretical support for the comprehensive utilization of ash and residue.
  • 加载中
  • [1] ZHANG J, LI J B, THRING R W, et al.Oil recovery from refinery oily sludge via ultrasound and freeze/thaw[J].Journal of Hazardous Materials,2012,203-204:195-203 10.1016/j.jhazmat.2011.12.016
    [2] 毛飞燕. 基于离心脱水的含油污泥油-水分离特性及分离机理研究[D]. 杭州: 浙江大学,2016
    [3] 崔鹏, 郭铁. 含油污泥药剂处理方法研究进展[J]. 当代化工,2013,42(7):999-1002 10.3969/j.issn.1671-0460.2013.07.036
    [4] 王万福, 金浩, 石丰, 等. 含油污泥热解技术[J]. 石油与天然气化工,2010,39(2):173-177 10.3969/j.issn.1007-3426.2010.02.024
    [5] YAN P, LU M, YANG Q, et al.Oil recovery from refinery oily sludge using a rhamnolipid biosurfactant-producing pseudomonas[J].Bioresource Technology,2012,116:24-28 10.1016/j.biortech.2012.04.024
    [6] HU G J, LI J B, ZENG G M.Recent development in the treatment of oily sludge from petroleum industry: A review[J].Journal of Hazardous Materials,2013,261:470-490 10.1016/j.jhazmat.2013.07.069
    [7] ZUBAIDY E A H, ABOUELNASR D M.Fuel recovery from waste oily sludge using solvent extraction[J].Process Safety and Environmental Protection,2010,88(5):318-326 10.1016/j.psep.2010.04.001
    [8] TAN W, YANG X G, TAN X F.Study on demulsification of crude oil emulsions by microwave chemical method[J].Separation Science and Technology,2007,42(6):1367-1377 10.1080/01496390701193736
    [9] XU N, WANG W X, HAN P F, et al.Effects of ultrasound on oily sludge deoiling[J].Journal of Hazardous Materials,2009,171(1/2/3):914-917 10.1016/j.jhazmat.2009.06.091
    [10] 韩旭, 毛飞燕, 黄群星, 等. 储运油泥中非油相组分对表观黏度的影响分析[J]. 浙江大学学报(工学版),2016,50(11):2064-2068 10.3785/j.issn.1008-973X.2016.11.004
    [11] 王凤超, 屈撑囤, 王益军. 含油污泥与煤混烧技术的研究进展[J]. 广州化工,2016,44(23):7-9 10.3969/j.issn.1001-9677.2016.23.004
    [12] 李广生. 流化床焚烧在含油污泥处理中的应用[J]. 工业安全与环保,2014,40(5):93-95 10.3969/j.issn.1001-425X.2014.05.028
    [13] 王锦, 龚春辰, 刘德民, 等. 铁路含油污泥的焚烧特性[J]. 中国铁道科学,2015,36(2):130-135 10.3969/j.issn.1001-4632.2015.02.19
    [14] 陈云华, 郭健, 解丽娟. 含油污泥固化与燃煤混烧的可行性[J]. 油气田环境保护,2010,20(4):33-34 10.3969/j.issn.1005-3158.2010.04.011
    [15] 刘晓辉, 许毓, 张明栋, 等. 含油污泥干化物与煤混烧的燃烧特性影响[J]. 石油石化绿色低碳,2016,1(6):37-40
    [16] 王志强, 邢奕, 洪晨, 等. 油田含油污泥掺煤资源化试验研究[J]. 安全与环境学报,2015,15(5):287-291 10.13637/j.issn.1009-6094.2015.05.060
    [17] HUANG Q X, MAO F Y, HAN X, et al.Characterization of emulsified water in petroleum sludge[J].Fuel,2014,118:214-219 10.1016/j.fuel.2013.10.053
    [18] 陶玲. 油漆渣-焦油渣工业危险废物焚烧特性的研究[D]. 哈尔滨: 哈尔滨工业大学,2010
    [19] 吴晓龙. 燃煤电站燃烧产物重金属元素赋存形态分析[D]. 北京: 华北电力大学,2016
  • 加载中
WeChat 点击查看大图
计量
  • 文章访问数:  2665
  • HTML全文浏览数:  2294
  • PDF下载数:  337
  • 施引文献:  0
出版历程
  • 刊出日期:  2018-04-22
林炳丞, 吴平, 吴丽萍, 林诚乾, 欧阳璐, 张琦, 黄群星. 油田油泥与煤在流化床中的混烧[J]. 环境工程学报, 2018, 12(4): 1237-1245. doi: 10.12030/j.cjee.201710057
引用本文: 林炳丞, 吴平, 吴丽萍, 林诚乾, 欧阳璐, 张琦, 黄群星. 油田油泥与煤在流化床中的混烧[J]. 环境工程学报, 2018, 12(4): 1237-1245. doi: 10.12030/j.cjee.201710057
shu
LIN Bingcheng, WU Ping, WU Liping, LIN Chengqian, OUYANG Lu, ZHANG Qi, HUANG Qunxing. Co-combustion of oily sludge and coal in fluidized bed[J]. Chinese Journal of Environmental Engineering, 2018, 12(4): 1237-1245. doi: 10.12030/j.cjee.201710057
Citation: LIN Bingcheng, WU Ping, WU Liping, LIN Chengqian, OUYANG Lu, ZHANG Qi, HUANG Qunxing. Co-combustion of oily sludge and coal in fluidized bed[J]. Chinese Journal of Environmental Engineering, 2018, 12(4): 1237-1245. doi: 10.12030/j.cjee.201710057
shu

油田油泥与煤在流化床中的混烧

  • 1. 浙江大学热能工程研究所，能源清洁利用国家重点实验室，杭州 310027
  • 2. 新疆宇澄热力股份有限公司，克拉玛依 834000
  • 3. 浙江物华天宝能源环保有限公司，杭州 310007
基金项目:

克拉玛依市科技计划项目（sk2016-34）

摘要: 基于小型流化床焚烧实验平台，通过含油污泥与煤混合燃烧，分析气体污染物排放浓度以及灰渣特性。含油污泥与煤混烧后NOx、SO2的排放浓度均低于危险废物焚烧排放标准。根据灰渣中组分分析，煤中碱金属化合物能抑制SO2的排放。渣样的浸出毒性均在标准范围内，灰样的浸出毒性高于渣样，主要因为飞灰中更容易富集挥发和易溶形态的重金属。基于小试实验的结果，油泥在小型流化床上的燃烧不充分导致了CO排放浓度较高，且灰的灼减率较高，因此，在后续中试以及示范工程中，应保证油泥的充分燃烧，为灰渣的综合利用提供理论基础。

English Abstract

参考文献 (19)

返回顶部

目录

/

返回文章
返回

Copyright © 2019 中国科学院生态环境研究中心