高级搜索

微波预处理对剩余污泥生化处理的影响

,  ,  ,  ,  , 

downloadPDF

上一篇

下一篇

李海兵, 刘志英, 林承顺, 赵宗锋, 徐炎华, 赵贤广. 微波预处理对剩余污泥生化处理的影响[J]. 环境工程学报, 2018, 12(4): 1254-1260. doi: 10.12030/j.cjee.201709173
引用本文: 李海兵, 刘志英, 林承顺, 赵宗锋, 徐炎华, 赵贤广. 微波预处理对剩余污泥生化处理的影响[J]. 环境工程学报, 2018, 12(4): 1254-1260. doi: 10.12030/j.cjee.201709173
shu
LI Haibing, LIU Zhiying, LIN Chengshun, ZHAO Zongfeng, XU Yanhua, ZHAO Xianguang. Effect of microwave pretreatment on biochemical treatment of waste activated sludge[J]. Chinese Journal of Environmental Engineering, 2018, 12(4): 1254-1260. doi: 10.12030/j.cjee.201709173
Citation: LI Haibing, LIU Zhiying, LIN Chengshun, ZHAO Zongfeng, XU Yanhua, ZHAO Xianguang. Effect of microwave pretreatment on biochemical treatment of waste activated sludge[J]. Chinese Journal of Environmental Engineering, 2018, 12(4): 1254-1260. doi: 10.12030/j.cjee.201709173
shu

微波预处理对剩余污泥生化处理的影响

  • 1.

    南京工业大学环境科学与工程学院,南京 211800

  • 2.

    中石化南京化工研究院有限公司,南京 210048

  • 基金项目:

Effect of microwave pretreatment on biochemical treatment of waste activated sludge

  • 1.

    College of Environmental Science and Engineering, Nanjing Tech University, Nanjing 211800, China

  • 2.

    Sinopec Nanjing Research Institute of Chemical Industry Co.Ltd., Nanjing 210048, China

  • Fund Project:

  • 摘要: 采用微波对污泥进行预处理，考察处理功率和处理时间对污泥破解效果的影响；通过生化处理考察处理后污泥的降解效果。结果表明：适当提高微波处理功率，延长微波处理时间，可有效提高污泥破解效果，提高污泥中溶解性有机物含量。在最佳条件 500?W、10?min下，污泥破解率（ω）、溶解性总氮（TDN）和溶解性总磷（TDP）分别为31.0%、179.6?mg·L-1和31.3?mg·L-1。红外光谱分析表明，经微波处理后，污泥中的基团性质有所增强。预处理后污泥的日产甲烷量高于未处理污泥，累积产甲烷量提高了45.3%，表明污泥得到有效降解。经生化处理后，化学需氧量（COD）去除率达到98%以上，TDP去除率达到80%~85%，出水的TDN高于进泥。因此，对剩余污泥采用微波预处理进行生化处理的技术路线是可行的。
    Abstract: In the present study, microwave was used to pretreat the waste activated sludge. The effect of microwave power and treatment period on sludge disruption, and degradation efficiency of disrupted sludge after the biochemical treatment were investigated. The results showed that when the microwave power increased and the treatment period extended appropriately, the sludge disruption efficiency could be improved and the content of dissolved organic compounds could be increased. Under the optimized condition (microwave power 500?W, treatment period 10?min), the sludge disintegration ratio (ω), the total dissolved nitrogen (TDN), and total dissolved phosphorus (TDP) were 31.0%，179.6?mg·L-1 and 31.3?mg·L-1, respectively. The analysis results of infrared spectroscopy showed that the properties of functional groups in sludge were enhanced after microwave treatment. Daily methane production of microwave pretreated sludge was higher that of untreated sludge, cumulative methane production was increased by 45.3%. This result illustrated that the sludge was degraded effectively. After biochemical treatment, the removal rate of chemical oxygen demand (COD) of sludge could reach above 98%, the removal rate of TDP could reach between 80% and 85%, and the TND content of effluent was higher than that of inflow sludge. In conclusion, the technical scheme adopting biochemical treatment of waste activated sludge after microwave pretreatment was feasible.
  • 加载中
  • [1] 董誉，汤兵，汤伟真，等.微波纳米磁粉协同作用处理污泥的研究[J].环境工程学报，2011，5(3)：680-684
    [2] RANI R U, KUMAR S A, KALIAPPAN S, et al.Impacts of microwave pretreatments on the semi-continuous anaerobic digestion of dairy waste activated sludge[J].Waste Management, 2013,33(5):1119-1127 10.1016/j.wasman.2013.01.016
    [3] PILLI S, BHUNIA P, YAN S, et al.Ultrasonic pretreatment of sludge:A review[J].Ultrasonics Sonochemistry,2011,18(1):1-18 10.1016/j.ultsonch.2010.02.014
    [4] FENG G, TAN W, ZHONG N, et al.Effects of thermal treatment on physical and expression dewatering characteristics of municipal sludge[J].Chemical Engineering Journal,2014,247(2):223-230 10.1016/j.cej.2014.03.005
    [5] LI C, LI H, ZHANG Y.Alkaline treatment of high-solids sludge and its application to anaerobic digestion[J].Water Science & Technology A Journal of the International Association on Water Pollution Research,2015,71(1):67-74 10.2166/wst.2014.469
    [6] TAI M, YANG C.Effect of ozone pretreatment on anaerobic digestion of high solid sludge[J].Chinese Journal of Environmental Engineering,2017,11(5):3115-3119
    [7] 程振敏，魏源送，刘俊新.微波辐射性作用下城市污水处理厂污泥的氮磷释放特性[J].过程工程学报， 2010，10(1):138-141
    [8] 孙德栋，马妮娜，郭思晓，等.微波联合活性炭纤维处理剩余污泥的研究[J].环境科学与技术，2011，34(8):143-146 10.3969/j.issn.1003-6504.2011.08.032
    [9] 阎鸿，程振敏，王亚炜，等.不同微波能量输入条件下污泥中碳、氮、磷的释放特性[J].环境科学，2009，30（12）：3639-3644 10.3321/j.issn:0250-3301.2009.12.032
    [10] 李学军,梁英,黄国平,等.微波、碱及其联合技术预水解市政污泥的研究[J].环境工程,2013,31(s1)：522-526
    [11] 刘吉宝，倪晓棠，魏源送，等.微波及其组合工艺强化污泥厌氧消化研究[J].环境科学，2014，35(9)：3455-3460 10.13227/j.hjkx.2014.09.029
    [12] 王艳杰，严媛媛，郭迎庆.微波强化预处理促进低有机质污泥厌氧消化[J].环境工程，2014，32(3)：92-95 10.13205/j.hjgc.201403022
    [13] 乔玮，王伟，徐衣显，等.碱辅助条件下的污泥微波热水解特性研究[J].环境科学，2009，30(9)：2678-2683 10.13227/j.hjkx.2009.09.022
    [14] 池勇志，刘晓敏，李玉友，等.微波预处理剩余污泥的研究进展[J].化工进展，2013，32(9)：2221-2226 10.3969/j.issn.1000-6613.2013.09.035
    [15] ESKICIOGLU C, TERZIAN N, KENNEDY K J, et al.Athermal microwave effects for enhancing digestibility of waste activated sludge[J].Water Research,2007,41(11):2457-2466 10.1016/j.watres.2007.03.008
    [16] ZHOU L, BAI X,XU X, et al.Ultrasonic technology combined with Ca(OH)2 for sewage sludge disintegration[J].Environmental Science & Technology,2014,37(9):120-125
    [17] 乔梦阳，孙德栋，王玲玲，等.过氧乙酸预处理污泥对厌氧消化的影响[J].大连工业大学学报，2014，33(3)：197-199
    [18] 徐慧敏，何国富，戴晓虎，等.超声联合碱解预处理对剩余污泥破解和厌氧消化的影响[J].环境工程学报，2017，11(5)：3073-3078 10.12030/j.cjee.201601202
    [19] 王在钊，贾通通，王蛟秦，等.水热+厌氧消化对污泥碳、氮、磷溶出的影响[J].环境工程技术学报，2017，7(3)：300-305 10.3969/j.issn.1674-991X.2017.03.043
  • 加载中
WeChat 点击查看大图
计量
  • 文章访问数:  2374
  • HTML全文浏览数:  1940
  • PDF下载数:  422
  • 施引文献:  0
出版历程
  • 刊出日期:  2018-04-22
李海兵, 刘志英, 林承顺, 赵宗锋, 徐炎华, 赵贤广. 微波预处理对剩余污泥生化处理的影响[J]. 环境工程学报, 2018, 12(4): 1254-1260. doi: 10.12030/j.cjee.201709173
引用本文: 李海兵, 刘志英, 林承顺, 赵宗锋, 徐炎华, 赵贤广. 微波预处理对剩余污泥生化处理的影响[J]. 环境工程学报, 2018, 12(4): 1254-1260. doi: 10.12030/j.cjee.201709173
shu
LI Haibing, LIU Zhiying, LIN Chengshun, ZHAO Zongfeng, XU Yanhua, ZHAO Xianguang. Effect of microwave pretreatment on biochemical treatment of waste activated sludge[J]. Chinese Journal of Environmental Engineering, 2018, 12(4): 1254-1260. doi: 10.12030/j.cjee.201709173
Citation: LI Haibing, LIU Zhiying, LIN Chengshun, ZHAO Zongfeng, XU Yanhua, ZHAO Xianguang. Effect of microwave pretreatment on biochemical treatment of waste activated sludge[J]. Chinese Journal of Environmental Engineering, 2018, 12(4): 1254-1260. doi: 10.12030/j.cjee.201709173
shu

微波预处理对剩余污泥生化处理的影响

  • 1. 南京工业大学环境科学与工程学院,南京 211800
  • 2. 中石化南京化工研究院有限公司,南京 210048
基金项目:

摘要: 采用微波对污泥进行预处理，考察处理功率和处理时间对污泥破解效果的影响；通过生化处理考察处理后污泥的降解效果。结果表明：适当提高微波处理功率，延长微波处理时间，可有效提高污泥破解效果，提高污泥中溶解性有机物含量。在最佳条件 500?W、10?min下，污泥破解率（ω）、溶解性总氮（TDN）和溶解性总磷（TDP）分别为31.0%、179.6?mg·L-1和31.3?mg·L-1。红外光谱分析表明，经微波处理后，污泥中的基团性质有所增强。预处理后污泥的日产甲烷量高于未处理污泥，累积产甲烷量提高了45.3%，表明污泥得到有效降解。经生化处理后，化学需氧量（COD）去除率达到98%以上，TDP去除率达到80%~85%，出水的TDN高于进泥。因此，对剩余污泥采用微波预处理进行生化处理的技术路线是可行的。

English Abstract

参考文献 (19)

返回顶部

目录

/

返回文章
返回

Copyright © 2019 中国科学院生态环境研究中心