煤堆内CO浓度分布与变化规律的数值模拟

刘尹霞; 马恒; 董子文

doi:10.12030/j.cjee.201701095

环境工程学报

煤堆内CO浓度分布与变化规律的数值模拟

, ,

刘尹霞, 马恒, 董子文. 煤堆内CO浓度分布与变化规律的数值模拟[J]. 环境工程学报, 2017, 11(11): 5963-5971. doi: 10.12030/j.cjee.201701095

引用本文:

刘尹霞, 马恒, 董子文. 煤堆内CO浓度分布与变化规律的数值模拟[J]. 环境工程学报, 2017, 11(11): 5963-5971. doi: 10.12030/j.cjee.201701095

LIU Yinxia, MA Heng, DONG Ziwen. Numerical simulation of concentration distribution and variation rule of CO in coal stockpile[J]. Chinese Journal of Environmental Engineering, 2017, 11(11): 5963-5971. doi: 10.12030/j.cjee.201701095

Citation:

LIU Yinxia, MA Heng, DONG Ziwen. Numerical simulation of concentration distribution and variation rule of CO in coal stockpile[J]. Chinese Journal of Environmental Engineering, 2017, 11(11): 5963-5971. doi: 10.12030/j.cjee.201701095

煤堆内CO浓度分布与变化规律的数值模拟

1.
辽宁工程技术大学安全科学与工程学院, 阜新 123000
2.
湖南工学院安全与环境工程学院, 衡阳 421002
基金项目:
国家自然科学基金资助项目（51274115，51274113）

辽宁省教育厅一般项目（L2012122）
中图分类号: X511

Numerical simulation of concentration distribution and variation rule of CO in coal stockpile

1.
College of Safety Science and Engineering, Liaoning Technical University, Fuxin 123000, China
2.
School of safety and environment Engineering, Hunan Institute of Technology, Hengyang 421002, China
Fund Project:

摘要: 为了明确空隙率和风速等对煤堆长期堆放过程中堆内CO浓度（体积浓度）的影响规律，为煤堆长期堆放过程中和受扰动后的安全及环境问题提供理论支持，使用COMSOLMultiphysics5.0建立二维数值模拟模型，研究了堆内CO浓度随堆放时间、空隙率、风速变化时的分布与变化规律。结果表明，空隙率和风速低时堆内CO分布具有"烟囱"现象，且浓度高，随堆放时间延长堆内最大CO浓度具有"增长-降低-稳定"三段式变化规律，风速低时最大浓度与时间之间服从Gauss Amp函数分布，风速较大或时间较长堆内最大CO浓度基本稳定。
- 煤堆 /
- CO /
- 空隙率 /
- 风速 /
- “烟囱”现象 /
- Gauss Amp函数
Abstract: To evaluate the effect rules of porosity and wind speed on CO volume concentration in coal stockpile, and provide theoretical supports for the safety and environmental issues in long time stacking process or be disturbed. Establish an 2D simulation model by use COMSOL Multiphysics 5.0, the concentration distribution and variation rule of CO in coal stockpile change with stacking time, porosity and wind speed were studied. The results show that, there is a chimney phenomenon and with higher concentration when the porosity and wind speed is low, the maximum CO concentration is three-step change rule of growth-lower-stability with the extension of stacking time. when wind speed is low, there is a Gauss Amp function relationship between stacking time and the maximum CO concentration, but the maximum CO concentration is basically stable when the wind speed is higher and the stacking time is longer.
- coal stockpile /
- CO /
- porosity /
- wind speed /
- chimney phenomenon /
- Gauss Amp function

[1]	MOGHTADERI B, DLUGOGORSKI B Z, KENNEDY E M. Effects of wind flow on self-heating characteristics of coal stockpiles[J]. Process Safety & Environmental Protection, 2000, 78(6):445-453
[2]	RIBEIRO J, SILVA E F D, LI Z, et al. Petrographic, mineralogical and geochemical characterization of the Serrinha coal waste pile (Douro Coalfield, Portugal) and the potential environmental impacts on soil, sediments and surface waters[J]. International Journal of Coal Geology, 2010, 83(4):456-466
[3]	董希琳,田丽. 湿煤堆自热过程的非稳态数学模拟[J].中国安全科学学报,1999,8(3):38-43
[4]	徐精彩. 空气在煤堆中的渗流规律探讨[J].西安矿业学院学报,1995,15(4):289-293
[5]	张瑞新,谢和平. 煤堆自然发火的试验研究[J].煤炭学报,2001,26(2):168-171
[6]	张瑞新,谢和平,谢之康.露天煤体自然发火的试验研究[J].中国矿业大学学报,2000,29(3):235-238
[7]	杨永良.煤最短自然发火期测试及煤堆自燃防治技术研究[D].徐州:中国矿业大学,2009
[8]	董子文,吴宪,齐庆杰,等.不同堆放条件下煤堆压实最低不适用风速研究[J].热能动力工程, 2016,31(10):63-71
[9]	董子文,吴宪,齐庆杰,等.风障联合压实防治煤堆自燃技术工艺参数优化[J].中国安全生产科学技术,2016,12(3):15-20
[10]	齐庆杰,王欢,董子文,等.基于OMSOL软件分析确定煤堆初始自燃区域[J].煤炭科学技术,2016,44(10):18-23
[11]	ALAZMI B, VAFAI K. Analysis of variants within the porous media transport models[J] Journal of Heat Transfer, 2000,122(2):303-326
[12]	HOOMAN K, GURGENCI H. Effects of Temperature-dependent viscosity on forced convection inside a porous medium[J].Transport in Porous Media, 2008, 75(2):249-267
[13]	KGUNA F A, ESSENHIGH R H. Self-ignition characteristics of coal stockpiles:Theoretical prediction from a two-dimensional unsteady-state model[J]. Fuel, 2001, 80(3):409-415
[14]	EJLALI A, AMINOSSADATI S M, HOOMAN K, et al. A new criterion to design reactive coal stockpiles[J]. International Communications in Heat and Mass Transfer, 2009,36(7):669-673
[15]	EJLALI A, HOOMAN K, BEAMISH B. Effects of porosity changes on the self-heating characteristics of coal stockpiles[J]. Journal of Porous Media, 2012,15(9):869-876
[16]	EJLALI A, MEE D J, HOOMAN K, et al. Numerical modelling of the self-heating process of a wet porous medium[J]. International Journal of Heat & Mass Transfer, 2011, 54(25):5200-5206
[17]	FIERRO V, MIRANDAA J L, ROMEROA C, et al. Prevention of spontaneous combustion in coal stockpiles experimental results in coal storage yard[J]. Fuel Processing Technology, 1999,59(1):23-34
[18]	SAMUEL LEONARD GROSSMAN, INA WEGENER WOLFGANG, WAN Z L, et al. Molecular hydrogen evolution as a consequence of atmospheric oxidation of coal:3.Thermogravimetric flow reactor studies[J]. Fuel,1994,73(5):762-767
[19]	白刚,周西华,孙宝铁,等.不同变质程度煤燃烧特性参数试验研究[J].中国安全科学学报,2016,26(9):56-61
[20]	URI GREEN, ZEEV AIZENSHTAT, LIONEL METZGER, et al. Field and laboratory simulation study of hot spots in stockpiled bituminous coal[J]. Energy Fuels, 2012, 26(12):7230-7235

点击查看大图

计量

文章访问数: 1594
HTML全文浏览数: 1282
PDF下载数: 206
施引文献: 0

煤堆内CO浓度分布与变化规律的数值模拟

1. 辽宁工程技术大学安全科学与工程学院, 阜新 123000
2. 湖南工学院安全与环境工程学院, 衡阳 421002

收稿日期: 2017-04-25

基金项目:

国家自然科学基金资助项目（51274115，51274113）

辽宁省教育厅一般项目（L2012122）

关键词:

摘要: 为了明确空隙率和风速等对煤堆长期堆放过程中堆内CO浓度（体积浓度）的影响规律，为煤堆长期堆放过程中和受扰动后的安全及环境问题提供理论支持，使用COMSOLMultiphysics5.0建立二维数值模拟模型，研究了堆内CO浓度随堆放时间、空隙率、风速变化时的分布与变化规律。结果表明，空隙率和风速低时堆内CO分布具有"烟囱"现象，且浓度高，随堆放时间延长堆内最大CO浓度具有"增长-降低-稳定"三段式变化规律，风速低时最大浓度与时间之间服从Gauss Amp函数分布，风速较大或时间较长堆内最大CO浓度基本稳定。

English Abstract

Numerical simulation of concentration distribution and variation rule of CO in coal stockpile

1. College of Safety Science and Engineering, Liaoning Technical University, Fuxin 123000, China
2. School of safety and environment Engineering, Hunan Institute of Technology, Hengyang 421002, China

Received Date: 2017-04-25

Fund Project:

Keywords:

Abstract: To evaluate the effect rules of porosity and wind speed on CO volume concentration in coal stockpile, and provide theoretical supports for the safety and environmental issues in long time stacking process or be disturbed. Establish an 2D simulation model by use COMSOL Multiphysics 5.0, the concentration distribution and variation rule of CO in coal stockpile change with stacking time, porosity and wind speed were studied. The results show that, there is a chimney phenomenon and with higher concentration when the porosity and wind speed is low, the maximum CO concentration is three-step change rule of growth-lower-stability with the extension of stacking time. when wind speed is low, there is a Gauss Amp function relationship between stacking time and the maximum CO concentration, but the maximum CO concentration is basically stable when the wind speed is higher and the stacking time is longer.

全文HTML

参考文献 (20)

下载: 全尺寸图片幻灯片

返回文章

用微信扫码二维码

分享至好友和朋友圈

煤堆内CO浓度分布与变化规律的数值模拟

Numerical simulation of concentration distribution and variation rule of CO in coal stockpile

计量

出版历程

煤堆内CO浓度分布与变化规律的数值模拟

English Abstract

Numerical simulation of concentration distribution and variation rule of CO in coal stockpile

全文HTML

目录