高级搜索

Fenton活化制备污泥炭对水中Cr (Ⅵ)的吸附性能

,  ,  ,  , 

downloadPDF

上一篇

下一篇

覃理嘉, 王东波, 林荣科, 李师, 冯庆革. Fenton活化制备污泥炭对水中Cr (Ⅵ)的吸附性能[J]. 环境工程学报, 2017, 11(9): 5007-5012. doi: 10.12030/j.cjee.201609228
引用本文: 覃理嘉, 王东波, 林荣科, 李师, 冯庆革. Fenton活化制备污泥炭对水中Cr (Ⅵ)的吸附性能[J]. 环境工程学报, 2017, 11(9): 5007-5012. doi: 10.12030/j.cjee.201609228
shu
QIN Lijia, WANG Dongbo, LIN Rongke, LI Shi, FENG Qingge. Preparation of sludge carbon with Fenton activation and adsorption characteristics of hexavalent chromium[J]. Chinese Journal of Environmental Engineering, 2017, 11(9): 5007-5012. doi: 10.12030/j.cjee.201609228
Citation: QIN Lijia, WANG Dongbo, LIN Rongke, LI Shi, FENG Qingge. Preparation of sludge carbon with Fenton activation and adsorption characteristics of hexavalent chromium[J]. Chinese Journal of Environmental Engineering, 2017, 11(9): 5007-5012. doi: 10.12030/j.cjee.201609228
shu

Fenton活化制备污泥炭对水中Cr (Ⅵ)的吸附性能

  • 1.

    广西大学资源环境与材料学院, 南宁 530004

  • 2.

    广西高校环境保护重点实验室, 南宁 530004

  • 3.

    广西壮族自治区环境保护科学研究院, 南宁 530022

  • 基金项目:

    广西自然科学基金项目（2012GXNSFBA053130）

    广西科技攻关项目（桂科攻1598016-5）

  • 中图分类号: X703

Preparation of sludge carbon with Fenton activation and adsorption characteristics of hexavalent chromium

  • 1.

    School of Resources, Environment and Materials, Guangxi University, Nanning 530004, China

  • 2.

    Guangxi Higher School Key Laboratory of Environmental Protection, Nanning 530004, China

  • 3.

    Scientific Research Academy of Guangxi Environmental Protection, Nanning 530022, China

  • Fund Project:

  • 摘要: 利用Fenton活化法活化脱水污泥制备活性炭，研究了Fenton试剂投加量、活化时间、炭化温度、炭化时间和升温速率5种因素对制备污泥炭的影响。污泥炭的最佳制备工艺：Fenton试剂投加量为150 mL，活化时间为2.5 h，炭化温度为350℃，炭化时间为1 h，升温速率为20℃·min-1。污泥炭碘吸附值达到331.90 mg·g-1，BET比表面积为24.265 m2·g-1。总孔容为0.146 cm3·g-1，微孔率为17%。分析了吸附时间、pH值和吸附温度3种因素对污泥炭吸附水中Cr（Ⅵ）的影响。在吸附时间为90 min，pH=3，吸附温度为50℃时，污泥炭对Cr（Ⅵ）的吸附量为9.93 mg·g-1。吸附动力学符合准二级动力学模型描述，吸附过程符合Langmuir和Tempkin等温吸附模型描述。
    Abstract: Using Fenton activation method to prepare activated carbon through dewatered sludge. The effects of Fenton's reagent dosage, activation time, carbonization temperature, residence time and heating rate on the preparation of sludge carbon were studied. The optimum preparation conditions are as the following:Fenton's reagent dosage is 150 mL, activation time is 2.5 h, carbonization temperature is 350℃, residence time is 1 h, heating rate is 20℃·min-1. The iodine adsorption value of sludge carbon under this optimum preparation condition is 331.90 mg·g-1, and BET specific surface area is 24.265 m2·g-1, the total pore volume is 0.146 cm3·g-1, microporosity is 17%. The effects of contact time, pH value and temperature on the adsorption of Cr(Ⅵ) in sludge carbon had been analyzed. In the condition of 90 min contact time, pH value of 3 and temperature of 50℃, the adsorption capacity of Cr(Ⅵ) is 9.93 mg·g-1 in sludge carbon. The adsorption kinetics fit the pseudo-second order kinetics model, and the adsorption process is described well with the Langmuir and Tempkin isotherm model.
  • 加载中
  • [1] 周少奇.城市污泥处理处置与资源化[M].广州:华南理工大学出版社,2002:150-168
    [2] 李志华,孙全明.污泥活性炭的制备与应用研究进展[J].轻工科技,2012,28(4):101-103
    [3] 刘亚纳,周鸣,汤红妍,等.亚甲基蓝在污泥活性炭上的吸附[J].环境工程学报,2012,6(7):2339-2344
    [4] ELMOLLA E S,CHAUDHURI M.The feasibility of using combined Fenton-SBR for antibiotic wastewater treatment[J]. Desalination,2012,285:14-21
    [5] PHAM T T H,BRAR S K,TYAGI R D,et al.Influence of ultrasonication and Fenton oxidation pre-treatment on rheological characteristics of wastewater sludge[J]. Ultrasonics Sonochemistry,2010,17(1):38-45
    [6] 王亚琛,谷麟,王妙琳,等.Fenton法制备污泥基活性炭及其性能表征[J].环境污染与防治,2014,36(8):43-48
    [7] RAPOSO F, RUBIA M A D L,BORJA R.Methylene blue number as useful indicator to evaluate the adsorptive capacity of granular activated carbon in batch mode:Influence of adsorbate/adsorbent mass ratio and particle size[J]. Journal of Hazardous Materials,2009,165(1/2/3):291-299
    [8] TAY J H,CHEN X G,JEYASEELAN S,et al.Optimising the preparation of activated carbon from digested sewage sludge and coconut husk[J]. Chemosphere,2001,44(1):45-51
    [9] REN X L,LIANG B H,LIU M,et al.Effects of pyrolysis temperature,time and leaf litter and powder coal ash addition on sludge-derived adsorbents for nitrogen oxide[J]. Bioresource Technology,2012,125:300-304
    [10] 姚志恒,刘羽,牛志睿,等.城市污水处理厂剩余污泥制备活性炭的研究[J].延安大学学报(自然科学版),2015,34(2):70-72
    [11] 卫新来,俞志敏,吴克,等.KOH活化制备脱水污泥活性炭[J].应用化工,2015,44(3):463-465
    [12] 程国淡,黄青,张凯松.热解温度和时间对生物干化污泥生物炭性质的影响[J]. 环境工程学报,2013,7(3):1133-1138
    [13] 卢欢亮,叶向东,汪永红,等.热解温度对污泥生物炭的表面特性及重金属安全性的影响[J].环境工程学报,2015,9(3):1433-1439
    [14] 翁诗甫. 傅里叶变换红外光谱分析[M].2版.化学工业出版社,2010:291-332
    [15] 杨晓庆,方正,侯芳丽,等.甘蔗渣活性炭处理含铬电镀废水[J].电镀与涂饰,2014,33(23):1033-1035
    [16] KHEZAMI L,CAPART R.Removal of chromium(VI) from aqueous solution by activated carbons:Kinetic and equilibrium studies[J]. Journal of Hazardous Materials,2005,123(1/2/3):223-231
    [17] HUANG G L,SHI J X, LANGRISH T A G.Removal of Cr(Ⅵ) from aqueous solution using activated carbon modified with nitric acid[J]. Chemical Engineering Journal,2009,152(2/3):434-439
    [18] 任新.净水厂工艺废水中污泥制备吸附剂及对水中Cr6+的吸附特性[D].哈尔滨:哈尔滨工业大学,2014
    [19] 公绪金,李伟光,张妍妍,等.活性炭吸附水中六价铬机理及影响因素[J].山东建筑大学学报,2011,26(4):396-402
    [20] 汪爱河,张纯,张伟,等.硫酸活化市政污泥吸附Pb2+[J].环境工程学报,2015,9(6):2887-2892
    [21] TAO H C,ZHANG H R,LI J B,et al.Biomass based activated carbon obtained from sludge and sugarcane bagasse for removing lead ion from wastewater[J]. Bioresource Technology,2015,192:611-617
    [22] CHANG M Y,JUANG R S.Adsorption of tannic acid,humic acid,and dyes from water using the composite of chitosan and activated clay[J]. Journal of Colloid and Interface Science,2004,278(1):18-25
  • 加载中
WeChat 点击查看大图
计量
  • 文章访问数:  1998
  • HTML全文浏览数:  1541
  • PDF下载数:  504
  • 施引文献:  0
出版历程
  • 收稿日期:  2016-12-19
  • 刊出日期:  2017-08-26

Fenton活化制备污泥炭对水中Cr (Ⅵ)的吸附性能

  • 1.  广西大学资源环境与材料学院, 南宁 530004
  • 2.  广西高校环境保护重点实验室, 南宁 530004
  • 3.  广西壮族自治区环境保护科学研究院, 南宁 530022
  • 收稿日期:  2016-12-19
基金项目:

广西自然科学基金项目（2012GXNSFBA053130）

广西科技攻关项目（桂科攻1598016-5）

摘要: 利用Fenton活化法活化脱水污泥制备活性炭，研究了Fenton试剂投加量、活化时间、炭化温度、炭化时间和升温速率5种因素对制备污泥炭的影响。污泥炭的最佳制备工艺：Fenton试剂投加量为150 mL，活化时间为2.5 h，炭化温度为350℃，炭化时间为1 h，升温速率为20℃·min-1。污泥炭碘吸附值达到331.90 mg·g-1，BET比表面积为24.265 m2·g-1。总孔容为0.146 cm3·g-1，微孔率为17%。分析了吸附时间、pH值和吸附温度3种因素对污泥炭吸附水中Cr（Ⅵ）的影响。在吸附时间为90 min，pH=3，吸附温度为50℃时，污泥炭对Cr（Ⅵ）的吸附量为9.93 mg·g-1。吸附动力学符合准二级动力学模型描述，吸附过程符合Langmuir和Tempkin等温吸附模型描述。

English Abstract

    全文HTML

参考文献 (22)

目录

/

返回文章
返回

Copyright © 2019 中国科学院生态环境研究中心